METCAL MSA-35L Smoke Absorber User Guide
- June 9, 2024
- METCAL
Table of Contents
METCAL MSA-35L Smoke Absorber User Guide
SPECIFICATIONS
| Model | MSA-35L-11 | MSA-35L-23 | MSA-35L-24 |
|---|---|---|---|
| Input Voltage | 120 VAC | 220 VAC | 220 VAC |
| Input Frequency | 60 Hz | 50 Hz | 50 Hz |
| Absorption Capacity Vertical Position | 1.1 m³/min (38 cfm) | 0,9 m³/min (32 | |
| cfm) | 0,9 m³/min (32 cfm) | ||
| Absorption Capacity Horizontal Position | 0.5 m³/min (18 cfm) | 0,45 m³/min (16 | |
| cfm) | 0,45 m³/min (16 cfm) | ||
| Noise level | 48 dBA | 45 dBA | 45 dBA |
| Related Input Power | 25 W | 24 W | 24 W |
| Dimensions H/W/D (mm) | 217 (H) x 186 (W) x 111 (D) | 217 (H) x 186 (W) x 111 | |
| (D) | 217 (H) x 186 (W) x 111 (D) | ||
| Dimensions H/W/D (inches) | 8.54” (H) x 7.32” (W) x 4.37” (D) | 8.54” (H) x | |
| 7.32” (W) x 4.37” (D) | 8.54” (H) x 7.32” (W) x 4.37” (D) | ||
| Certifications | CSA | CE | UKCE |
| Weight | 0.93 kg/2.05 lbs. | 0.91 g /2.0 lbs. | 0.91 kg /2.0 lbs. |
READ AND SAVE THESE INSTRUCTIONS
Add Filter
Plug into outlet
Position Unit Horizontally or Vertically
Power on
WARNING
To reduce the risk of fire or electric shock, do not use with any solid-state
speed control devices. Disconnect the power cord before servicing. Failure
could result in electric shock. For safe and successful operation of the unit,
read these instructions completely. If the instructions are not observed, the
manufacturer can assume no responsibility. Retain this manual for future
reference. Consult your “safety department” when using the unit on flammable
gases. This unit is not explosion safe and can only be used for the extraction
of vapors, which have concentration levels well below the lower explosive
limits. Do not use the unit to extract corrosive substances. Do not expose the
connecting cable to heat, oil, or sharp edges. Make sure the unit stands
stable and secure. Use only original equipment filters or authorized filter
replacements. Do not operate the unit without filter inserts. Contaminants in
the extracted air will damage the fan. Always disconnect the power supply
before servicing the unit. Never cover exhaust openings. Never cover all air
inlet openings simultaneously. Observe general safety regulations for the
handling of chemicals such as adhesives and sealants. Do not absorb
combustible or explosive gas with the absorber. Use genuine Metcal or
authorized replacement parts. If the supply cord is damaged, it must be
replaced by the manufacturer, its service agent, or similarly qualified
persons to avoid a hazard. This appliance can be used by children aged from 8
years and above and persons with reduced physical, sensory, or mental
capabilities or lack of experience and knowledge if they have been given
supervision or instruction concerning use of the appliance in a safe way and
understand the hazards involved. Children shall not play with the appliance.
Cleaning and user mainte- nance shall not be made by children without
supervision. this appliance is designed to be used in commercial areas. They
shall state that prior to cleaning or other maintenance, the appliance must
be disconnected from the supply mains.
CAUTION
Be sure to observe all the instructions.
a) “Do not operate any fan with a damaged cord or plug. Discard fan or
return to an authorized service facility for examination and/or repair.”
b) “Do not run cord under carpeting. Do not cover cord with throw rugs,
runners, or similar coverings. Do not route cord under furniture or
appliances. Arrange cord away from traffic area and where it will not be
tripped over.” When replacing parts or repairing, take sufficient care not to
expose live electrical parts or damage insulation materials. Be sure to
ground the unit during use.
MAINTENANCE
Absorption power will decrease when the filter needs to be changed. Replace the filter when the filter turns white or when dust adheres to the surface of the filter. (Do not allow the filter to get wet).
Removing the filter
When replacing the filter, place your fingers on the filter and remove it by
pulling it outward.
Attaching the filter
Place the filter on the absorber so that it aligns with the face of the unit.
Then place the filter behind the fourretaining tabs.
WARRANTY
OK International warrants this product against any defects in material or workmanship for (1) year from the date of purchase by the original owner. This Warranty excludes normal maintenance and shall not apply to any opened, misused, abused, altered, or damaged items. If the product should become defective within the warranty period, Ok International will repair or replace the product free of charge as its sole option. The repaired or replacement item will be shipped, freight prepaid, to the original purchaser. The warranty period will start from the date of purchase. If the date of purchase cannot be substantiated the date of manufacture will be used as the start date of the warranty period.
Waste Electrical and Electronic Equipment Directive – WEEE (2002/96/EC).
When this MSA-35L is no longer required, if it cannot be re-used, we ask our
customers not to dispose of it as unsorted municipal waste but to
appropriately recycle the MSA-35L. In Europe, please contact your OK
International distributor who can advise the recycling options available
(www.okinternational.com ). Please visit Metcal’s web page (www.metcal.com)
where you will find available information on systems, accessories, technical
notes, user guide, and more.
Metcal Corporate Headquarters
10800 Valley View Street
Cypress, California, 90630, USA
Tel: 1-714-799-9910
Fax: 1-714-828-2001
E-mail: metcal.com/contact-us
References
- Alabama Local News, Breaking News, Sports & Weather
- Metcal - Advanced Manufacturing Solutions
- Contact Us - Metcal
- Metcal - Advanced Manufacturing Solutions
- OK International - Global Advanced Manufacturing Equipment
- Contact Us - Metcal
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>