KARCHER T7/1 Classic ProT 200 Vacuum Cleaner User Manual

Makes a different
T 7/1 Classic
ProT 200 Vacuum Cleaner
User Manual

T7/1 Classic ProT 200 Vacuum Cleaner

Please read and comply with these original instructions prior to the initial operation of your appliance and store them for later use or subsequent owners.
– Before first start-up it is definitely necessary to read the safety indications Nr. 5.956-249.0!
– The non-compliance of the operating and safety instructions may lead to damages of the appliance and to dangers for the operator and other persons.
– In case of transport damage inform vendor immediately.

Environmental protection

****| The packaging material can be recycled. Please do not throw the packaging material into household waste; please send it for recycling.
---|---
| Old appliances contain valuable materials that can be recycled; these should be sent for recycling. Batteries, oil, and similar substances must not enter the environment. Please dispose of your old appliances using appropriate collection systems.

Notes about the ingredients (REACH)
You will find current information about the ingredients at: www.kaercher.com/REACH

Danger or hazard levels

DANGER
Pointer to immediate danger, which leads to severe injuries or death.
WARNING
Pointer to a possibly dangerous situation, which can lead to severe injuries or death.
CAUTION
Pointer to a possibly dangerous situation, which can lead to minor injuries.
ATTENTION
Pointer to a possibly dangerous situation, which can lead to property damage.

Proper use

WARNING
The appliance is not suitable for vacuuming dust which endangers health.
ATTENTION
This unit is only to be used indoors.
– Not 1.527-180.0:
This universal vacuum cleaner is intended for dry cleaning of floor and wall surfaces.
– 1.527-180.0 only:
This hard floor vacuum cleaner is intended for dry cleaning of floor and wall surfaces.
– 1.527-180.0 only:
The provided floor nozzle is not suitable for the use on carpets.
– This appliance is suited for the commercial use, e.g. to clean buildings (offices, hotels, etc.), for handymen on construction sites, for carpenters and for interior remodeling.

Device elements

1. Fleece filter bag
2. Suction support
3. Suction hose
4. Nameplate
5. Carrying handle
6. Hose switch
7. Cable clamp
8. Power cord
9. Suction head
10. Suction head lock| 11. Steering roller
12. Dirt receptacle
13. Main switch
14. Switch between hard surface/carpet (depending on model)
15. Floor nozzle
16. Suction tube
17. Suction force regulator (continuous) (depending on model)
18. Bender
19. Main filter basket
20. Motor protection filter
---|---

Start up

⇒ Check whether main filter basket has been inserted into the appliance.
Operating modes

1. Operation with filter bag
2. Operation without filter bag

Installation of the filter bag
⇒ Release and remove the suction head.
⇒ Remove the main filter basket.
⇒ Insert the fleece filter bag.
⇒ Insert main filter basket.
⇒ Insert and lock the suction head.

Operation

Turning on the Appliance
⇒ Plug in the mains plug.
⇒ Switch on the appliance at the main switch.
Cleaning operations
⇒ Not 1.527-180.0:
Set the selection switch of the floor nozzle to hard surface or carpet.
⇒ ProT 200 only:
Regulate the suction force on the suction force regulator (continuous).
⇒ Perform the cleaning operation.
Turn off the appliance
⇒ Switch off the appliance at the main switch.
⇒ Pull out the mains plug.
After each operation
⇒ Empty the container.
⇒ Vacuum and wipe the appliance inside and outside with a damp cloth.

Transport

CAUTION
Risk of injury and damage! Observe the weight of the appliance when you transport it.
⇒ When transporting in vehicles, secure the appliance according to the guidelines from slipping and tipping over.

Storage

CAUTION
Risk of injury and damage! Note the weight of the appliance in case of storage.
This appliance must only be stored in interior rooms.

Care and maintenance

DANGER
First pull out the plug from the mains before carrying out any tasks on the machine.
Clean main filter basket
⇒ Main filter basket (washable), clean it under running water if necessary.
ATTENTION
Risk of damage! Never insert the main filter basket while wet.
Replace motor protection filter
⇒ Release and remove the suction head.
⇒ Remove the motor protection filter.
⇒ Insert new motor protection filter.
⇒ Insert and lock the suction head.

Troubleshooting

DANGER
First pull out the plug from the mains before carrying out any tasks on the machine.
The appliance shuts off during the operation
– Motor thermal protector has responded.
⇒ Replace fleece filter bag.
⇒ Replace motor protection filter.
⇒ Check all parts for plugging.
Switching back on after the motor turbine has cooled off, after approx. 30 to 40 minutes.
Suction turbine does not run
⇒ Check the receptacle and the fuse of the power supply.
⇒ Check the power cable and the power plug of the device.
⇒ Turn on the appliance.
Suction capacity decreases
⇒ Remove choking of suction nozzle, suction tube or suction hose.
⇒ Replace fleece filter bag.
⇒ Clean the main filter basket under running water.
⇒ Insert/lock the suction head correctly.
⇒ Replace defective suction hose.
⇒ Replace motor protection filter.
Dust comes out while vacuuming
⇒ Replace fleece filter bag.
⇒ Check the fleece filter bag.
⇒ Insert/lock the suction head correctly.
⇒ Insert undamaged main filter basket.
⇒ Reinsert motor protection filter correctly.
Customer Service
If malfunction can not be fixed, the device must be checked by customer service.

Warranty

The warranty terms published by the relevant sales company are applicable in each country. We will repair potential failures of your appliance within the warranty period free of charge, provided that such failure is caused by faulty material or defects in manufacturing. In the event of a warranty claim please contact your dealer or the nearest authorized Customer Service centre. Please submit the proof of purchase.

Accessories and Spare Parts

Only use original accessories and spare parts, they ensure the safe and trouble-free operation of the device.
For information about accessories and spare parts, please visit www.kaercher.com.

EU Declaration of Conformity

We hereby declare that the machine described below complies with the relevant basic safety and health requirements of the EU Directives, both in its basic design and construction as well as in the version put into circulation by us. This declaration shall cease to be valid if the machine is modified without our prior approval.
Product: Dry vacuum cleaner
Type: 1.527-xxx
Relevant EU Directives
2006/42/EC (+2009/127/EC)
2014/30/EU
2011/65/EU
2009/125/EC
Applied harmonized standards
EN 55014–1: 2006+A1: 2009+A2: 2011
EN 55014–2: 2015
EN 60335–1
EN 60335–2–69
EN 61000–3–2: 2014
EN 61000–3–3: 2013
EN 62233: 2008
EN 50581
EN 60312: 2013
Applied national standards
–
Applied regulations
666/2013
5.966-384
The undersigned act on behalf and under the power of attorney of the company management.

Authorised Documentation Representative
S. Reiser

Alfred Kärcher GmbH Co. KG
Alfred-Kärcher-Str. 28 – 40
71364 Winnenden (Germany)
Phone: +49 7195 14-0
Fax: +49 7195 14-2212
Winnenden, 2017/01/01

Technical specifications

| T 7/1 Classic| T 7/1 Classic
1.527-180.0| ProT 200
---|---|---|---
Mains voltage| V| 220-240| 220-240| 220-240
Frequency| Hz| 1— 50-60| 1— 50-60| 1— 50-60
Container capacity| I| 7| 7| 7
Air volume (max.)| Us| 40| 40| 40
Negative pressure (max.)| kPa (mbar)| 23,5 (235)| 23,5 (235)| 23,5 (235)
Protective class| | II| II| II
Suction hose connection (C-DN/ C-ID)| mm| 35| 35| 32
Length x width x height| mm| 375 x 285 x 310| 375 x 285 x 310| 375 x 285 x 310
Typical operating weight| kg| 3,5| 3,5| 3,5
Max. ambient temperature| °C| +40| +40| +40
Values determined to EN 60335-2-69
Sound pressure level LP„| dB(A)| 62| 62| 62
Uncertainty Ka„| dB(A)| 1| 1| 1
Hand-arm vibration value| m/s’| <2,5| <2,5| <2,5
Uncertainty K| m/s2| 0,2| 0,2| 0,2
Eco design as per 666/2013
Energy efficiency category| —| C| A| C
Indicative annual energy con- sumption| kWh/a| 37,5| 26,6| 37,6
Carpet cleaning class| —| E| —| E
Hard floor cleaning class| —| C| C| C
Dust emission class| —| D| D| D
Sound power level LAA| dB(A)| 75| 75| 75
Rated power input| W| 850| 850| 850
Power cord| H05VV-F 2×1,0 mm²
---|---
Part no.:| Cable length
EU| 6.650-621.0| 7,5 m
Power cord| H05VV-F 2×0,75 mm²
---|---
Part no.:| Cable length
GB| 6.650-649.0| 7,5 m

http://www.kaercher.com/dealersearch
59678770 Register and win!
www.kaercher.com/register-and-win

References

• motor.Si
• Cleaning equipment and pressure washers | Kärcher International
• Dealer Search | Kärcher International
• Reinigungsgeräte und Hochdruckreiniger | Kärcher

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>