noqon Solar Pad NMS Series Solar Module Instruction Manual

: June 9, 2024
: noqon

Table of Contents

Introduction
Explanation of the symbols
General safety instructions for installation
Scope of delivery
Overview
Installation
**Clean the surface of the solar panel
Troubleshooting
Integrated USB-Ports
Service / Complaint
Warranty
Disposal
Read User Manual Online (PDF format)
Download This Manual (PDF format)

MONOCRYSTALLINE
Solar Module
Solar Pad
NMS Series Installation and
Operating Instructions
NOQON – Solar Pad

Introduction

This user manual contains important information on the installation and use of the + SunCase Plus solar module.
We therefore ask you to read this manual carefully and attentively before using the product.
The user manual is intended for the installer and end user of the Noqon Solar Pad solar module. ”
This is the original manual, keep it in a safe place!

Explanation of the symbols

This operating manual contains important safety and installation instructions that are required for proper and safe operation.
The following icons are in the guide to highlight dangerous and important situations.
Please note these symbols in the appropriate place and exercise caution.
Warning!
Failure to observe this notice may result in serious injury or death.
Attention!
Failure to observe this notice may interfere with the function of the device or cause damage to the device.
Note!
Additional information on how to operate the device.

General safety instructions for installation

Before installing, read the User’s Guide carefully. It is designed to make it easier for you to operate and install safely the Noqon Solar Pad solar module. It is essential that any person working on or with the solar module knows the contents of this User’s Guide and follows the instructions and safety instructions contained therein.
Warning!
Restricted user base
The following persons should use this product only under the supervision of another responsible person:

Persons with limited physical abilities.
Persons with limited mental abilities.
Persons with limited sensory abilities.
Children under 12 years of age.
Use the device only for proper use.
Keep the device out of reach of children.
Maintenance and repair may only be carried out by a specialist who is familiar with all current guidelines.

Warning!
Notes on installation

The installation of the device may only be carried out by appropriately trained personnel and only in compliance with all applicable safety regulations and guidelines.
Especially when using the device on boats, corrosion damage can occur due to faulty installations. The installation should therefore be carried out by trained boat electricians.

Warning!
Important installation instructions!
In order to avoid danger, in particular due to fire hazard, injury and electric shock, the following instructions must be observed:

Do not use the solar module if it is damaged or not functioning properly.
Do not allow water to enter a connected charge controller.
Prevent sharp objects from damaging the surface of the solar module.
Make sure that all connections to the batteries are correct and tight; avoid short circuits.
The solar module does not contain any parts that can be serviced by the user. Do not disassemble or attempt to repair the solar module.
Do not touch exposed wires or terminals

Scope of delivery

Model	MC4 to Small Anderson	XT60 to MC4

Overview

Sun Pad| NMS
60| NMS
80| NMS
100| NMS
120| NMS
160| NMS
200| NMS
300
---|---|---|---|---|---|---|---
Rated Power (Wp)| 60 W| 80 W| 100 W| 120 W| 160 W| 200 W| 300 W
Rated Current IMPP (V)| 20,9 V| 17,6 V| 18,7 V| 20,9 V| 17,6 V| 18,7 V| 19,8 V
Rated Current IMPP (A)| 2,87 A| 4,55 A| 5,35 A| 5,74 A| 9,09 A| 10,70 A| 15,15 A
Performance Tolerance| +/- 3 %| +/- 3 %| +/- 3 %| +/- 3 %| +/- 3 %| +/- 3 %| +/- 3 %
Opencircuit Voltage UoC| 24,7 V| 20,8 V| 22,1 V| 24,7 V| 20,8 V| 22,1 V| 23,4 V
Shortcicuit Current Isc| 3,38 A| 5,06 A| 5,86 A| 6,25 A| 9,61 A| 11,21 A| 15,67 A
Dimension (mm) L x B x H| 880 x
530 x
3 mm| 1080 x
525 x
25 mm| 1210 x
565 x
25 mm| 1600 x
530 x
25 mm| 2000 x
525 x
25mm| 2280 x
575 x
25 mm| 2940 x
595 x
3 mm
Dimension (mm) folded| 440 x
530 x
50 mm| 540 x
525 x
50 mm| 600 x
565 x
50 mm| 440 x
530 x
50 mm| 535 x
525 x
50 mm| 600 x
575 x
50 mm| 770 x
595 x
50 mm
Weight(Kg)| 2,20 Kg| 2,50 Kg| 4,00 Kg| 4,00 Kg| 6,70 Kg| 8,30 Kg| 12,5 Kg

Installation

Place the solar module in a location with sunlight that is free of branches and other obstacles.
Unfold the module and make sure that the solar module is facing the sun.
This will maximise the power output of the module.
Connect the module to the appropriate inputs of a compatible solar charge controller.
Connect the battery you wish to charge to the correct outputs of the charge controller.
Make sure that all connections are secure and avoid short circuits.
Compatible batteries and devices
With a suitable charge controller, this solar module can be used to charge or power the following batteries and devices:

Sealed lead-acid batteries
Colloidal lead-acid batteries
Lead-acid batteries (wet)
Lithium batteries
Mobile phones
Tablets
Navigation systems, etc.

**Clean the surface of the solar panel

Remove dust and dirt from the surface of the solar module with a soft brush and then wipe it clean with a damp cloth.
Bird droppings should be removed as soon as possible to avoid a negative effect on the performance of the solar module.

Troubleshooting

If the battery does not charge even though the solar panel is facing directly towards the sun, this may indicate a problem in the connections.
Make sure that the solar module is connected correctly and that no connections are reversed.
Also, the solar charge controller may be damaged. In this case, it must be replaced.
Note!
Always read and follow the operating instructions of the solar charge controller that you connect to the solar module.

Integrated USB-Ports

The Noqon Solar Pad solar panels have three built-in USB ports:

2x USB-A (5V, 3A)
1x USB-C (5V, 3A / 9V, 2A / 12V, 1.5A)
which you can use to charge or power devices such as mobile phones or digital cameras.

Indicator LED
The built-in LED informs about the operation of the solar module. The LED lights up red as soon as the solar module is in operation.

Service / Complaint

If you have any questions about your product after the purchase or during operation, we will be happy to help you.
In most cases, a pre-information by e-mail with explanation of the problem and pictures is usually helpful.
Tip: If you contact us directly, have your customer or invoice number and the item number ready.
In the event of a return of the product, please note the following instructions for quick processing:

If possible, use the original packaging as a shipping box.
Please enclose to the return:
Copy of the invoice
(Service Form)
Reason for the return
An accurate and detailed error description

Warranty

In principle, the statutory warranty period applies. If you have a complaint, please contact the manufacturer’s branch in your country or the relevant point of sale.
The warranty is limited to the repair or replacement of a defective device. Removal and service costs will not be reimbursed.
In order to achieve the fastest possible warranty processing, you must send the following information.

A copy of the invoice with a purchase date.
A complaint or a description of the error.

Note!
Liability for damages is excluded in the following cases:

Damage to the device due to overvoltages and mechanical influences.
Assembly errors and connection faults.
Use of the device for purposes other than described.
Structural modifications to the device without written permission from the manufacturer.
Consequential damage caused by the use of Noqon solar module
Any errors in this manual and consequential damages resulting therefrom.

Noqon products are manufactured according to the strictest quality criteria and Noqon guarantees that the product will be delivered in perfect condition.
Noqon provides the legal warranty for production and material defects that were present at the time of delivery of the product.
There is no liability for typical signs of wear and tear.
The warranty does not apply to defects caused by natural wear/tear, improper use or lack of maintenance.
Any use of the product follows at your own risk.
A warranty claim can only be accepted if a copy of the proof of purchase is attached when the product is sent.
The warranty in no case exceeds the value of the product.
By commissioning the product, you acknowledge the warranty conditions and assume full responsibility for the use of this product.
The weight, size or otherwise values given by Noqon shall be understood as a guideline.
Noqon does not undertake any formal obligation for such specific information, as technical changes made in the interest of the product may result in different values.
By opening the device – by unauthorizeds personnel – the warranty expires in any case.

Disposal

Please dispose of all packaging material properly or recycle it.
Do not dispose of this product in your normal household waste, but in accordance with local regulations.
Note!
If the device is decommissioned, please contact the nearest recycling centre or your point of sale and be informed about the latest disposal regulations.
Your municipality or local authority can provide information on disposal.
Read the instruction before using your product.
**RoHS**The Restriction of the use of certain , hazardous substances in electrical and efectronic equipment

Conform to European standards
For indoor use only
Layer Limited
Handle wite Care
All information is provided to the best of the author’s knowledge. However, the latter cannot accept any liability for errors or incorrect operation.
No liability is assumed for printing errors or operating errors and their consequential damages.
Technical changes are possible without prior notice.
All rights reserved. The content of this document may not be reproduced, passed on or distributed in any form, in whole or in part, without the prior written consent of the
manufacturer.