Rocktrail IAN 455397_2307 Single Burner Camping Stove Instruction Manual

Rocktrail IAN 455397_2307 Single Burner Camping Stove Instruction Manual

PRODUCT OVERVIEW

INSTALLATION INSTRUCTION

Introduction

IMPORTANT: Read these instructions carefully to familiarize yourself with the appliance before connecting it to the gas cartridge. Keep the instructions in a safe place so that you can consult them at a later stage.

Congratulations on the purchase of your new camping stove. You have selected a high-quality product.
These operating instructions are an integral part of the product. They contain important information on safety, use and disposal. Be sure to familiarise yourself with all operating and safety instructions before assembling and using the product for the first time. Use the product only as described and for the specified areas of application. Please hand over all documents to third parties when passing on the product.

Symbols used
The following symbols and signal words are used in these instructions, on the camping stove, the accessories or on the packaging.

WARNING
Indicates a hazard which, if not avoided, can result in death or serious injury.

CAUTION!
Indicates a hazard which, if not avoided, can result in minor or moderate injury.

This product complies with all the applicable legislation of the European Economic Area

Various disposal and recycling pictograms. The product and packaging must be disposed of in an environmentally-friendly manner and in accordance with the regulations. Please observe the disposal instructions in the “Recycling” section.

Scope of delivery / Parts designation
(See illustrations on fold-out page)

1. Burner
2. Pan supports (4x)
3. Folding side protection
4. Cartridge compartment cover
5. Gas control and ignition button. Positions:
6. **Cartridge lever. Positions:

released

locked**

7. Flap for cartridge slot
8. Gas inlet
9. Seal (internal)
10. towage case (without illustration)
11. Operating instructions (operating and safety instructions) (without illustration)

Technical data

for the single-burner camping stove, IAN 455397_2307

butane cartridge or the Nola “Art. No. 707” butane cartridge. It can be dangerous to attempt to connect other types of gas cartridge or container.
Nominal heat load / consumption:| 2,1 kW / 150 g/h
Use:| Only use outdoors or in well-ventilated areas
Pan / pot diameter:| 12- 23 cm

2531

Safety

Read all safety warnings and instructions. Failure to comply with these safety instructions can cause serious injury. Keep all safety information and instructions for future reference. Please also hand over all documents to third parties when passing on the camping stove.

Intended use

This appliance is designed for preparing and heating food in the hobby and leisure sector. The device may only be used outdoors or in well-ventilated spaces and only according to the instructions in this manual and not for any other purpose. All other uses or any alteration to the device are deemed improper and can lead to property damage and even personal injury. The manufacturer or vendor assumes no liability for damage caused by improper or incorrect use. The device is not intended for commercial use.
General safety instructions for the single-burner camping stove, IAN 455397_2307

• Check that the seal 9 (between the appliance and the gas cartridge) is present and in good condition before connecting the gas cartridge.

• Do not use appliances with damaged or worn seals.

• Do not use appliances that are leaking, defective or not working properly.

• The appliance may only be used outdoors or in well-ventilated spaces. The national requirements apply

• to the supplying of combustion air and

• to avoid the build up of dangerous quantities of unburned gas.

• The appliance must be used on a horizontal surface on which its operation is not restricted (free from dry grass, sand, etc.)

• The appliance must be used at a safe distance from flammable materials. A minimum lateral safety distance of 0.5 m must be maintained from all nearby surfaces (walls) and objects, as well as a minimum safety distance of 1 m from objects positioned above the appliance.

• Never place two stoves closely beside one other. The above-mentioned safety distance must be maintained at all times.

• Make sure that the ventilation slots in the cartridge component cover 4 are free at all times.

• Gas cartridges must be replaced in a well-ventilated area, preferably outdoors away from all potential sources of ignition such as naked flames, pilot lights and electrical cooking appliances and away from other people.

• WARNING! When replacing the gas cartridge, check that the burner 1 has gone out completely before loosening. Risk of explosion!

• CAUTION! The gas cartridge could be hot. Risk of injury!

• WARNING! Remove cookware from the camping stove before replacing the cartridge.
  Risk of injury!

• WARNING! If gas is leaking from your appliance (smell of gas), take it outside immediately to a place with good air circulation and no sources of ignition, where the leak can be located and repaired. Only check the leak tightness of your appliance when outdoors. Never use flame to locate a leak, use soapy water instead!

• WARNING! If a pressure-sensitive safety device is triggered, this means that a critical level has been reached in the gas cartridge and the appliance must not be used until it has cooled down completely. The pressure-sensitive safety device cannot be bypassed.

• CAUTION! Accessible parts may be very hot. Keep children and toddlers away from the appliance. Risk of injury!

• WARNING! Do not use pans or pots with a diameter of less than 12 cm or more than 23 cm. Containers that are too small cannot be kept in a stable position, containers that are too large can cause a build-up of heat leading to overheating of the gas cartridge. Risk of explosion! Take care always to place cookware on a non-combustible, heat-resistant surface.

Before use

Selecting the gas cartridge
Only use gas cartridges that are suitable for the appliance. This product may only be used with the Kemper “Type 577” butane cartridge or the Nola “Art. No. 707” butane cartridge. It can be dangerous to attempt to connect other types of gas cartridge or container.
Fitting the gas cartridge (figs. A, B and C)

• Gas cartridges must be fitted in a well-ventilated area, preferably outdoors away from all potential sources of ignition such as naked flames, pilot lights and electrical cooking appliances and away from other people.
• Make sure that the gas control and ignition button 5 is in the “closed” position.
• Make sure that the cartridge lever 6 is in the “released” position.
• Open the cartridge compartment cover 4 by folding it upwards.
• Check that the seal between the appliance and the gas cartridge 9 is present and in good condition.
• Remove the protective cap from the gas cartridge and keep it safe so that the gas cartridge can be stored at a later stage.
• Position the gas cartridge so that the flap 7 fits into the cartridge slot and the gas cartridge valve extends into the 8 gas inlet.
• Close the cartridge compartment cover 4 .
• Push the cartridge lever 6 down to the “locked” position. The gas cartridge is now firmly connected to the gas inlet 8 and the side protection 3 is folded up.
• Check whether the connection is tight by listening and smelling. The connection is not tight if you can smell gas or hear gas escaping. Take the appliance outside immediately to a place with good air circulation and no sources of ignition, and do not attempt to switch on the camping stove under any circumstances.
• The camping stove is ready for use once it has passed the leak test.
  The camping stove is now ready to use.

4. Use

Switching on and off, adjusting the flame (Fig. D)
Proceed as follows to ignite the camping stove and adjust the flame:

• Make sure that the cartridge lever 6 is in the “locked” position.
• Turn the gas control and ignition button 5 anticlockwise until it locks into the “maximum gas flow” position.
• Continue to turn the gas control and ignition button 5 anticlockwise using a short, sharp hand movement until you hear a “click”, repeating several times if necessary until the flame ignites. The camping stove is now burning at its highest level.
• Wait for around 30 seconds until the flame has stabilized and then turn the gas control and ignition button, if required, 5 clockwise towards “reduced gas flow” to obtain a smaller flame.

Proceed as follows to switch off the camping stove:

• Turn the gas control and ignition button 5 clockwise until it locks into the “closed” position.
• Make sure that the flame has gone out.
• Allow the camping stove to cool down before storing it away.
• Remove the gas cartridge from the camping stove as described below if the appliance is not going to be used for a long time.

Removing and replacing the gas cartridge
WARNING! When replacing the gas cartridge, check that the burner 1 has gone out completely before loosening. Risk of explosion! Take care as the gas cartridge could be hot. Gas cartridges must be removed / replaced in a well- ventilated area, preferably outdoors away from all potential sources of ignition such as naked flames, pilot lights and electrical cooking appliances and away from other people.

Proceed as follows to remove and / or replace the gas cartridge:

• Fold up the cartridge compartment cover 4 .
• Remove the gas cartridge from the camping stove.
• Insert a new gas cartridge as described in the section “Fitting the gas cartridge”

Safety equipment

Folding side protection
The folding side protection 3 prevents you from using a cooking pot that is too wide. If the cooking pot is too wide, the heat from the burner may radiate onto the gas cartridge causing it to overheat, which can lead to dangerous situations (risk of explosion).

• Functionality: when a downward force is applied to the side protection, for example due to the weight of a pan, it will fold down. At the same time, the gas cartridge is released from the gas inlet 8 and the flame goes out.
• As specified, only use pans or pots with a maximum diameter of 23 cm. This will prevent this safety equipment from being triggered.
• Never attempt to bypass this safety equipment.

Pressure-sensitive safety equipment
Pressure-sensitive safety equipment 8 is integrated in the gas inlet. This prevents the camping stove from being used if the pressure in the gas cartridge is too high.

• Functionality: The pressure of butane gas in the gas cartridge increases when heated. If the pressure in the gas cartridge exceeds a critical point, the gas cartridge is released from the gas inlet (8) and the flame goes out.
• If this happens, proceed as follows:
• Allow the camping stove and the gas cartridge to cool down until they have reached room temperature.
• Identify and rectify the cause of overheating or overpressure. This is usually caused by insufficient safety distances or blocked ventilation slots.
• Only switch the camping stove on when you are confident that it cannot overheat again.
• Never attempt to bypass this safety equipment.

Maintenance, cleaning, storage and transport

Maintenance and repairs

• Do not make any alterations to the appliance.
• Check regularly for any damage to the rubber seal.
• Make sure that all connections are tight.
• Regularly carry out a visual inspection of the general aspects of the device and, if necessary, remove any contaminants such as sand, insects or grass.
• Regularly check the proper operation of the gas cartridge connection/release system.
• Contact our customer services in advance in the event of operating faults or necessary repairs (see below). (Point 10)

Cleaning
Clean the camping stove with a damp cloth if necessary. Do not use any aggressive abrasive cleaning agents, solvents or petrol. The camping stove and its accessories must not be sprayed with or soaked in water.

Storage and transport conditions

• Remove the gas cartridge when the appliance is not in use and store the camping stove and gas cartridge in a secure, cool, dry, well-ventilated place out of reach of children. Protect the camping stove and gas cartridge from sunlight and never expose them to temperatures in excess of 50°C.
• It is preferable to store and transport the camping stove with the storage case provided to protect it from damage.
• Only transport the gas cartridge with the protective cap on.

Declaration of conformity

The EU declaration of conformity can be requested from the manufacturer’s customer service.

Recycling

Dispose of the product and packaging in an environmentally friendly manner and according to all regulations.

Packaging disposal

Sort the packaging materials properly before disposing of them. Cardboard goes in the waste paper bin, foil in the recyclable materials collection bin.

“Truman” – Symbol for France: The packaging materials are recyclable. Please dispose of them separately to optimize waste processing.

Disposing of the camping stove and accessories
Dispose of the stove and the storage case according to the regulations in force in your country. Hand in any unusable appliances for recycling at a recycling collection point. Do not dispose of the stove with household waste. Information on collection points for used appliances can be obtained from your local council, the public waste disposal authority or your waste collection service.

Disposing of gas cartridges
Make sure that the gas cartridge is completely empty and hand it in at a recycling collection point.

Warranty

Smartmaxx GmbH warranty Dear customer, This device comes with a three-year warranty from the purchase date. You have statutory rights vis-à-vis the seller of the product in the event of product defects. These statutory rights are not limited by our warranty outlined below.

Warranty conditions
The warranty period begins on the purchase date. Please keep the original receipt in a safe place. It will be required as proof of purchase. If a material or manufacturing defect occurs within three years of the purchase date of this product, we will repair or replace the product or refund the purchase price at our discretion. This warranty service requires you to return the defective device with proof of purchase (receipt) within the three-year period, together with a brief written description of the defect and when it occurred.
If the defect is covered by our warranty, you will receive the repaired device or a new product. A new warranty period does not begin when a product has been repaired or replaced.

Warranty period and statutory claims for defects
The warranty period is not extended by the warranty. This also applies to replaced and repaired parts.
Any damage and defects present at the time of purchase must be notified as soon as the product has been unpacked. Any repairs made on expiry of the warranty period will incur a charge.

Scope of warranty
This device has been carefully produced according to strict quality guidelines and meticulously tested before delivery.
The warranty service applies to material and manufacturing defects. This warranty does not cover product parts that are subject to normal wear and tear and can therefore be considered as wear parts or damage to fragile parts, e.g. switches, batteries or glass parts. This warranty is void if the product has been damaged or improperly used, maintained or transported. All the operating instructions provided in this manual for proper use of the product must be observed. All uses and actions that are advised against or warned against in the operating instructions must be avoided without exception.
The product is intended for private use only and not for commercial use. The warranty will not apply in the event of abusive or improper handling, use of force and interventions that are not carried out by our authorised service branch.

Processing in the event of a warranty claim
Please follow the instructions below to ensure that your request is processed quickly:

• For all inquiries, please be ready to provide the receipt and item number (IAN 455397_2307) as proof of purchase.
• In the event of functional errors or other defects, please contact the service department named below first by telephone or email. If a product is found to be defective, you can send it postage paid with proof of purchase (receipt) and a description of the fault and when it occurred to the service address provided.

Service / Supplier

In the case of service and warranty, please contact:
Smartmaxx GmbH Schulzstraße 2c 85579 Neubiberg GERMANY
Hotline: +49 89 678 45 06 – 0
E-mail: office@smartmaxx.info

Supplier:
Smartmaxx GmbH Schulzstraße 2c 85579 Neubiberg GERMANY

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>