Honeywell 60000 Air Cleaner Owner’s Manual

: July 11, 2024
: Honeywell

**Honeywell 60000 Air Cleaner Owner’s Manual

**

IMPORTANT SAFETY INSTRUCTIONS

READ AND SAVE THESE SAFETY INSTRUCTIONS BEFORE USING THIS AIR PURIFIER

When using electrical appliances, basic precautions should always be followed to reduce the risk of fire, electric shock, and injury to persons, including the following:

Read all instructions before operating the air purifier.
Place air purifier where it is not easily knocked over by persons in the household.
Always turn the air purifier to the OFF position and unplug from the wall outlet when not in use.
To disconnect the air purifier, first turn control to the OFF position, grip the plug and pull it from the wall outlet. Never pull by the cord.
Do not use any product with a damaged cord or plug or if product malfunctions, is dropped or damaged in any manner. Keep the cord away from heated surfaces.
Do not use air purifier outdoors.
Never use air purifier unless it is fully assembled.
Do not run power cord under carpets, and do not cover with throw rugs. Arrange cord such that it will not be tripped over.
Do not use air purifier where combustible gases or vapors are present.
Do not expose the air purifier to rain, or use near water, in a bathroom, laundry area or other damp location.
The air purifier must be used in its upright position.
Do not allow foreign objects to enter ventilation or exhaust opening as this may cause electric shock or damage to the air purifier. Do not block air outlets or intakes.
Locate air purifier near the outlet and avoid using an extension cord.
This appliance has a polarized plug (one blade is wider than the other). To reduce the risk of shock, this plug is intended to fit only one way in a polarized outlet. If the plug does not fit fully in the outlet, reverse the plug. If it still does not fit, contact a qualified electrician. DO NOT attempt to defeat this safety feature.
A loose fit between the AC outlet (receptacle) and plug may cause overheating and a distortion of the plug. Contact a qualified electrician to replace loose or worn outlet.
Do not sit, stand or place heavy objects on the air purifier.
Disconnect power supply before servicing.

WARNING: To Reduce The Risk of Fire or Electric Shock, Do Not Use This Air Purifier With Any Solid State Speed Control Device.

INTRODUCTION

Thank you for purchasing the enviracaire ® IFD Air Purifier with a breakthrough technology in air purification. Please read below on how to operate and care for your new air purifier.

YOUR IFD AIR PURIFIER

Fig. 1

SET-UP

Select a firm, level and flat location. For proper air flow, locate the unit at least 3 feet (1 M) from any wall or furniture.
Ensure the exit grille faces away from the closest wall or furniture.
Ensure no grilles are blocked.
Plug into a grounded 120 V outlet. See IMPORTANT SAFETY INSTRUCTIONS.

OPERATION

Ensure the air purifier is plugged into a working outlet and the Control Knob is in the OFF position.
Rotate the Control Knob to the desired speed level: TURBO or QUIET (Fig. 2).
The Indicator Light will illuminate when the power is on.
Turn the Control Knob to the OFF position to turn off the air purifier.

ELECTRONIC FILTER INDICATOR (Select Models)

Certain IFD air purifier models are equipped with an electronic filter indicator to serve as
a convenient guideline for cleaning the IFD and pre-filter based on the air purifier’s hours
of use and operating power level. Once the filter has reached its capacity level, the light
will remain on until it is RESET. You may unplug the air purifier without interrupting the
filter indicator. A red LED light will illuminate and blink when it is time to clean the filters.
Please clean the filters according to the directions outlined in the next section.

To RESET the Electronic Filter Indicator:
When the filter indicator light blinks, it is time to check/clean the IFD Filter and reset the Electronic Filter Indicator, if needed. With the unit powered on, insert the tip of a ball point pen or paperclip into the Filter Reset Button located above the Indicator Light. Hold down for approximately 5 seconds until the light turns off (Fig. 3).

Depending upon your individual usage (environment and hours used), you may need to check and clean the filter more or less frequently. If the IFD Filter is cleaned before the filter indicator light turns on, the Electronic Filter Indicator should be reset at the same time.

REMOVING / CLEANING THE IFD FILTER

To remove the IFD filter:

Turn the Control Knob to the OFF position and UNPLUG the air purifier.
Pull the notch to release the rear grille (Fig. 4).
Remove the rear grille.
Gently pull the IFD Filter out of its housing by grasping the center of the filter and pulling towards you (Fig. 5).

To clean the IFD filter:

DO NOT USE WATER OR OTHER LIQUIDS TO CLEAN THE IFD FILTER.
After removing the IFD Filter from the air purifier, gently tap the filter onto a firm surface within a trash receptacle to release the captured particles.
To vacuum-clean the filter, lay the filter on. a flat surface and run a vacuum cleaner with a nozzle or brush attachment along the filter to pick-up dirt (Fig. 6).

If the IFD Filter clogs or you have difficulty cleaning the filter, please visit our website at www.kaz.com or call us at 1-800-332-1110.

CLEANING THE PRE-FILTER

The particle pre-filter helps pick-up large airborne particles that enter the rear grille. This pre-filter can be removed and rinsed by hand under warm water. Let the pre-filter dry completely before inserting it back into the unit.

INSTALLING THE FILTERS

Please make certain that the Control Knob is in the OFF position and the air purifier is unplugged. To install the IFD Filter and pre-filter:
Hold the filter with the top arrows pointing up ( ) and the insert arrows pointing towards the unit( ) (Fig. 7).
Gently insert the I F D Filter into the filter compartment.
Make certain that the I F D Filter is secure in the unit.
Grasp the p r e-filter at the top and align to cover the I F D Filter.
Snap the rear grille into place.

CLEANING AND MAINTENANCE

Use a clean, dry cloth to wipe the external surfaces of the air purifier. DO NOT USE
WATER, GASOLINE, POLISH, OR ANY CHEMICAL SOLUTION.
The IFD filter and pre-filter should be cleaned at least once a month, or sooner depending on the air quality of the room (See “Removing/Cleaning the IFD Filter” or “Cleaning the Pre-Filter” respectively).

FREQUENTLY ASKED QUESTIONS

How often is cleaning required?

About every four weeks depending on the air quality of the room.

Is the IFD Air Purifier considered an ozone generator?

No. Ozone generators produce large amounts of ozone and the EPA considers these unsafe for household use.

CONSUMER RELATIONS

Mail questions or comments to:| Call us toll-free at: 1-800-332-1110
---|---
Kaz, Inc.| E-mail: consumerrelations@kaz.com
Consumer Relations Dept.
250 Turnpike Road| Or visit our website at: www.kaz.com
South borough, MA 01772| Please be sure to specify a model number.

NOTE : IF YOU EXPERIENCE A PROBLEM, PLEASE CONTACT CONSUMER RELATIONS FIRST, RETURN THE AIR PURIFIER TO THE ORIGINAL PLACE OF PURCHASE OR SEE YOUR WARRANTY. DO NOT ATTEMPT TO OPEN THE MOTOR HOUSING YOURSELF, DOING SO MAY VOID YOUR WARRANTY AND CAUSE DAMAGE TO THE AIR PURIFIER OR PERSONAL INJURY.

REPLACEMENT FILTERS

To order a replacement pre-filter for the IFD Air Purifier model 60000, visit our website at www.kaz.com or call us at 1-800-332-1110.
Washable Pre-Filter #60006: $6.25.

IMPORTANT NOTE

The ionizing process used by the air purifier produces small amounts of ozone as a byproduct. The air purifier complies with U.S. Government limits for acceptable levels of ozone (less than 50 parts per billion by volume of air circulating through the product).
People with a history of respiratory problems or heart/lung disease should consult a physician prior to using this product.

5 YEAR LIMITED WARRANTY

You should first read all instructions before attempting to use this product.

Register your product on-line at www.kaz.com or complete and return the Consumer Response Card within 7 days.

A. This 5 year limited warranty applies to repair or replacement of product found to be defective in material or workmanship. This warranty does not apply to damage resulting from commercial, abusive, unreasonable use or supplemental damage. Defects that are the result of normal wear and tear will not be considered manufacturing defects under this warranty. KAZ IS NOT LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES OF ANY NATURE. ANY IMPLIED WARRANTY OF MERCHANTS BILITY OR FITNESS FOR A PARTICULAR PURPOSE ON THIS PRODUCT IS LIMITED IN DURATION TO THE DURATION OF THIS WARRANTY.
Some jurisdictions do not allow the exclusion or limitation of incidental or consequential damages or limitations on how long an implied warranty lasts, so the above limitations or exclusions may not apply to you. This warranty gives you specific legal rights, and you also may have other rights which vary from jurisdiction to jurisdiction. This warranty applies only to the original purchaser of this product from the original date of purchase.
B. At its option, Kaz will repair or replace this product if it is found to be defective in material or workmanship. Defective product should be returned to the place of purchase in accordance with store policy. Thereafter, while within the warranty period defective product may be retumned to Kaz.
C. This warranty does not cover damage resulting from any unauthorized attempts to repair or from any use not in accordance with the instruction manual.
D. Return defective product to Kaz, Inc. with a brief description of the problem.
Include proof of purchase and a $10 US/$15.50 CAN check or money order for handling, return packing and shipping charges. Please include your name, address and a daytime phone number.
You must prepay shipping charges. Send to:

InUS.A.
Kaz, Inc.
Attn: Returns Department
4755 Southpoint Drive
Memphis, TN 38118
USA
In Canada:
Kaz, Inc.
Attn: Returns Department
510 Bronte Street South
Milton, ON L9T 2X6
Canada

©2004 Kaz, Inc. All rights reserved.
P/N: 035-00456-000, Rev. 2
A/W: 043-01355-000

Appliance Factory Parts Experts in BBQ, Humidifier, & Appliance Parts
1-800-955-7075
Shop genuine replacement parts for HONEYWELL 60000
Find Your HONEYWELL Air Cleaner Parts – Select From 215 Models