BBQ grillware 41054 Outdoor Gas Grill Instruction Manual

41054 Outdoor Gas Grill

“`html

Specifications:

• Model: 720-0001
• Type: Outdoor Gas Grill
• Manufacturer: BBQ GrillwareTM
• Intended Use: Residential

Product Usage Instructions:

Safety Instructions:

READ THE FOLLOWING INSTRUCTIONS CAREFULLY AND BE SURE
YOUR GRILL IS PROPERLY INSTALLED, ASSEMBLED, AND MAINTAINED.
FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN SERIOUS BODILY
INJURY AND/OR PROPERTY DAMAGE.

If you have questions concerning assembly or operation, call our
service center at 1-800-913-8999, Monday through Friday 8:00 AM –
5:00 PM, Pacific Coast Time.

Installation:

The installation must conform with local codes or, in the
absence of local codes, with the National Fuel Gas Code, ANSI
Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases,
ANSI/NFPA 58 or CSA B149.1, Natural Gas and Propane Installation
Code.

Location for Your Grill:

Choose a safe location for your grill following the safety
instructions provided. Ensure adequate ventilation and keep
flammable materials away from the grill.

Assembly Instructions:

1. Refer to the illustrated parts breakdown to identify all
   components.

2. Follow the step-by-step assembly instructions provided in the
   manual.

3. Make sure all parts are securely attached before operating the
   grill.

Operating Instructions:

1. Before each use, inspect the grill for any signs of damage or
   wear.

2. Ensure the gas supply is connected properly and there are no
   leaks.

3. Follow the lighting instructions carefully to avoid
   accidents.

4. Adjust the heat settings as needed during cooking.

FAQ:

Q: How do I order replacement parts?

A: To order replacement parts, please call
1-800-913-8999 for assistance.

Q: What should I do if I smell gas while using the grill?

A: If you smell gas, shut off the gas supply,
extinguish any open flame, open the lid, and if the odor continues,
immediately call your gas supplier or fire department.

Q: Can this grill be used for commercial purposes?

A: No, this unit is not intended for commercial
use.

“`

This Owner’s Manual is provided and hosted by Appliance Factory Parts.
Nex – Old 720-0001 – Old Owner’s Manual
Shop genuine replacement parts for Nex – Old 720-0001 – Old
Find Your Nex – Old Grill Parts – Select From 32 Models ——– Manual continues below ——–

Item # 41054
ASSEMBLY & OPERATING INSTRUCTIONS FOR OUTDOOR GAS GRILL
®
PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE
FOR MODEL 720-0001 OUTDOOR GRILL

TABLE OF CONTENTS
Illustrated Parts Breakdown………………. 1 Parts List…………………………………….. 1 Safety Instructions……………………….. 2-5 Assembly Instruction……………………….. 6 Lighting Instruction……………………….. 7 Lighting Rod Assembly Instruction……… 8-9 Care and Maintenance…………………….. 10 Cooking Instruction……………………….. 11 Trouble Shooting………………………….. 12 Limited Warranty……………………………. 13

Read this Care and Use Manual carefully and completely before using your grill to reduce the risk of fire, burn hazard or other injury.

FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, immediately call your gas supplier or your fire department.
For Your Safety 1. Do not store or use gasoline or other flammable vapors and liquids
in the vicinity of this or any other appliance. 2. When cooking with oil/grease, do not allow the oil/grease to exceed
350F (176.5C). Do not store or use extra cooking oil in the vicinity of this or any other appliance. 3. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

WARNING 1. Do not store spare LP cylinder within 10 feet (3.05m) of this
appliance. 2. Do not store or use gasoline or other flammable liquids or vapors
within 25 feet (7.62m) of this appliance. 3. When cooking with oil/grease, do not allow the oil/grease to get
hotter than 350F (176.5C). 4. Do not leave oil/grease unattended.
This unit is not intended for commercial use.
Distributed by L G Sourcing Inc. P.O. Box 1535, North Wilkesboro, NC 28659 Model # 720-0001, BBQ GrillwareTM
Failure to follow these instructions could result in fire or explosion which could cause property damage, personal injury or death.

ILLUSTRATED PARTS BREAKDOWN
MODEL 720-0001 TABLE-TOP GRILL
4
2

MODEL 720-0001 -LP PARTS LIST

REF#

Description

QTY

1

Lid, Front

1 SET

2

Bowl Assembly Handle Assembly

1 SET

3

Handle Assembly

1 SET

4

Cooking Grid Flame tamer

1 PC

5

Flame tamer

1 PC

6

Grease Tray

1PC

7

Burner

1PC

8

Name Plate

1PC

9

Regulator LP

1 SET

10

Foldable Leg

4 SET

11

Gas Collector Box

1PC

12

Latch

1SET

13

Grease Tray Stopper

1PC

14

Logo

1PC

15

Heat insulation plant

1PC

How to order replacement parts? Please call 1-800-913-8999

1

Safety Instructions
READ THE FOLLOWING INSTRUCTIONS CAREFULLY AND BE SURE YOUR GRILL IS PROPERLY INSTALLED, ASSEMBLED AND MAINTAINED. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN SERIOUS BODILY INJURY AND/OR PROPERTY DAMAGE. IF YOU HAVE QUESTIONS CONCERNING ASSEMBLY OR OPERATION, CALL OUR SERVICE CENTER AT 1-800-913-8999, MONDAY THROUGH FRIDAY 8:OOAM-5:OOPM, PACIFIC COAST TIME.
NOTE TO INSTALLER:
LEAVE THESE INSTRUCTIONS WITH THE CONSUMER AFTER INSTALLATION. NOTE TO THE CONSUMER: RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE. THIS OUTDOOR COOKING GAS APPLIANCE IS NOT INTENDED TO BE INSTALLED IN OR ON RECREATIONAL VEHICLES AND/OR BOATS. a) The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance. b) When cooking with oil/grease, fire extinguishing materials should be readily accessible. In the event of an oil/grease fire do not attempt to extinguish with water. Use type BC dry chemical fire extinguisher or smother fire with dirt, sand or baking soda. c) In the event of rain while cooking with oil/grease, cover the cooking vessel immediately and turn off the appliance burners and gas supply. Do not attempt to move the appliance or cooking vessel. d) When cooking, the appliance must be on a level, stable surface in an area clear of combustible material. An asphalt surface (blacktop) may not be acceptable for this purpose. e) Do not leave the appliance unattended. Keep children and pets away from the appliance at all times. f) Do not place empty cooking vessel on the appliance while in operation. Use caution when placing anything in cooking vessel while the appliance is in operation. g) Do not move the appliance when in use. Allow the cooking vessel to cool before moving or storing. h) This appliance is not intended for and should never be used as a heater. Do not store a spare LP-gas cylinder under or near this appliance.
2

Safety Instructions
Read carefully before assembling and operating your gas grill.
INSTALLATION
The installation must conform with local codes or, in the absence of local codes, with the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58 or CSA B149.1, Natural Gas and Propane Installation Code.
THE LOCATION FOR YOUR GRILL
Do not use your gas grill in garages, porches, breezeways, sheds or other enclosed areas. Your gas grill is to be used outdoor only, at least 21 `from the back and side to any combustible surface. The grill should not be placed under any surface that will burn. Do not obstruct the flow of combustion and ventilation air around the grill housing. This outdoor cooking gas appliance is not intended to be installed in or on recreational vehicles and/or boats. The Fuel System Gas grills are used safely by millions of people when following simple safety precautions. The items in the fuel system are designed for operation with the BBQ Grillware grill. They must not be replaced with any other brand. (See parts list for replacement items.) GAS BURNER: The gas burner is constructed of tubular stainless steel and should not require maintenance other than inspection for insects/nests inside the air intake slots. BURNER VALVE/REGULATOR: The burner control is actually a regulator/valve assembly. The regulator attaches directly to the end of the burner, which extends out of the right end of the grill by, a 1-pound propane cylinder threads into the regulator. The burner control operates in the following positions indicated by the pointer at the top of the regulator as installed on the grill: Once the regulator is in as far as it will go, tighten it with a wrench. OFF – This stops the flow of gas to the burner. PUSH TO TURN ON – You must push “IN” on the knob to release the knob from the locked “OFF” position. HIGH – This position provides the highest gas flow and hottest cooking temperatures.
3

Safety Instructions
MED – This position provides cooking temperatures between HIGH and LOW. LOW – This position provides the lowest cooking temperatures. ONLY A FACTORY SUPPLIED GAS VALVE/REGULATOR SHOULD BE USED. See parts list for replacement items.
LP GAS REGULATOR CAUTION The gas pressure regulator provided with this appliance must be used. This regulator is equipped with the required orifice and is set for the required outlet pressure for this appliance. This combination of orifice size and pressure regulation specifications provides the cooking performance intended by BBQ Grillware Table Top Grill. Substitution of regulator by any other device or any other manufacturer is dangerous and could result in serious injury.
LP GAS REGULATOR The gas pressure regulator is shipped loose and must be installed prior to operating your grill. This is a” slip-fit~ requiring no tools. See assembly instructions for proper installation. The regulator may be removed from grill after use. Turn the regulator control knob to the “OFF” position; disconnect LP cylinder and allow the grill to cool for at least 30 minutes prior to removing regulator.
Care should be taken to store the regulator in a clean, secure location when the grill is not in use. The threaded cylinder connection area should be kept clean and free of dust, dirt, sand or any foreign materials. Clean both the regulator and LP cylinder threaded areas prior to connecting cylinder to regulator.
PROPANE FUEL: Warning – propane is a flammable gas. Improper handling may result in an explosion and/or fire and serious accident or injury. Your grill is designed to operate with propane (LP) gas only and is equipped with the proper orifice for propane gas. Caution: Do not connect this grill with any gas supply other than propane. Propane gas is heavier than air and settles in lower areas. Make certain adequate ventilation is available when using your grill. The gas cylinder may be stored outside in a well-ventilated area out of the reach of children when the grill is not in use.
LP GAS CYLINDER: This grill is designed and intended to be used with a disposable propane cylinder with a nominal fuel weight of 1 lb. Such a cylinder is approximately 4″ in diameter and 7″ long. The BBQ Grillware Table Top Grill does not include an LP gas cylinder. This must be purchased separately and be supplied at most hardware stores. The cylinder used must be constructed in accordance with the specifications for LP cylinders of the U.S. Department of Transportation (DOT) DOT-39 NRC232/290 MllIO.
The LP gas cylinder shall be used only outdoors in a well-ventilated space and not in a building, garage, or any other enclosed area. The BBQ Grillware Table Top Grill may be stored indoor if the LP gas cylinder is removed and stored outdoors. The LP gas cylinder (not included) is threaded for connection directly to the gas regulator supplied with this appliance. The LP gas cylinder is provided with a threaded connection for access directly to the gas regulator supplied with this appliance. Care should be taken when threading the cylinder to the regulator to engage threads correctly to achieve the proper and intended connection. When disconnecting or connecting the gas cylinder, be careful that the regulator does not strike the grill, the ground, or any other surfaces. Replace the protective cap over the threaded cylinder connection when removed from grill. If any difficulty at all occurs when connecting or disconnecting the cylinder to the regulator assembly, contact your local gas supplier for assistance.
When re-connecting the LP gas cylinder to the regulator, be sure to hand- tighten until snug. This connection should be inspected for damage and leak tested after re-connection.
The threaded cylinder connection should be kept clean and free of dust, dirt, sand or any foreign materials. Clean both regulator and LP cylinder threaded areas prior to connecting cylinder with regulator.
Keep any electrical supply cord or fuel supply hose away from any heated surfaces.
4

COOKING TEMPERATURE SETTINGS HIGH – Approximately 450 degrees F MED – Approximately 400 degrees F LOW – Approximately 350 degrees F NOTE: A disposable 1 lb. Cylinder “NEAR EMPTY” can significantly reduce or will significantly reduce internal pressure and may affect the regulator’s capability to accurately control gas flow. This may cause hotter-than-normal cooking temperatures during the final few minutes of cylinder use as it reaches empty. NOTE: A disposable 1 lb. cylinder will provide approximately 4-6 hours of cooking time with the BBQ Grillware Table Top Grill.
5

Assembly Instructions
PLEASE READ THE INSTRUCTION CAREFULLY AND FOLLOW STEP BY STEP. Your BBQ Grillware Table Top Grill is pre-assembled. The only part that you need to assemble is to connect gas regulator into your grill. The estimated time for one person to assemble to table top grill is 5 to 8 minutes. 1. Locate the gas regulator. Grasp the regulator with the knob facing directly up. Line up the collar on the regulator with the open end of the burner tube.
2. Screw the regulator into open end of burner with a provided wrench.
3. Once the regulator is in as far as it will go. Turn it so knob is facing to the front of the grill. Note: Always make sure the regulator is secured in the fully lock-in position before attaching propane cylinder.
4. Be sure gas control knob is in the off position. Refer to the figure below. Check to make sure threaded areas on cylinder and regulator are clean. Thread propane cylinder to engage threads correctly to achieve proper connection. Removing propane cylinder. Refer to the figure below. Unthread cylinder from regulator as shown.
6

Lighting Instructions
1. Make sure the regulator is properly secured into the burner end. 2. Make sure the propane cylinder is tightly threaded into the regulator-hand-tighten only. 3. Open lid. 4. Locate lighting access hole on right side of the panel. 5. Insert match or lighter through access hole next to the burner tube. Keep flame next to burner. 6. Push gas burner control knob “IN” and turn counter- clockwise to “Lighting Position” 7. If ignition does not occur in 3-5 seconds, turn burner off. Wait 5 minutes and repeat the lighting
procedure. Note: lf the burner should go out for any reason, turn control knob to “Off” position. Wait 5 minutes before attempting to re-light. If the grill fails to light after the second attempt, check with your local dealer for assistance. With the burner lit, gently close lid and allow grill to warm up for 20-30 minutes prior to use.
Flames should be blue and stable with no yellow tips, excessive noise or lifting. If any of these conditions exist, check to see if the air shutter or burner ports are blocked by dirt, debris, spider webs, etc. If you have any questions regarding flame stability, please call customer service.
Typical flame pattern and proper flame height.
TURNING GRILL OFF
I. Open lid. 2. Turn regulator control knob to “OFF”. 3. Caution: Do not attempt to re-light without following all lighting instructions. 4. Allow grill body to cool at least 30 minutes before attempting to move or transport.
To adjust for proper flame, use a Philips screw driver to loosen screw. Turn clockwise to close the air shutter, and counterclockwise to open. After adjusting, tighten screw to fix air shutter.
7

7

Lighting Rod Assembly Instructions
PLEASE READ THE INSTRUCTION CAREFULLY AND FOLLOW STEP BY STEP.
1. Please locate the lighting rod located on the right side of your table top grill. Please see the following figure.
Lighting Rod
8

2. Please attach the match to the front end of the lighting rod, and stick the lighting rod into the access to manual lighting hole to light the fire as indicated in below picture.
Access to manual lighting
9

Care & Maintenance
There is very little care and maintenance needed. The BBQ Grillware Table Top Grill is designed and made of materials that will last many years with normal use. Following these instructions will improve the longevity and quality of cooking. To ensure safe operation of your grill, the area of cooking should always be kept free of combustible materials of any type, such as gasoline or other flammable vapors or liquids.
1. Outside of body – This is stainless steel. It can be cleaned easily with warm soapy water or any stainless steel cleaner.
2. Grid and drip pan – The grid is made of high quality stainless steel. The grid should be brushed with a brass or stainless steel brush immediately after removing food, while grill is still warm. The drip pan is also stainless steel and can be cleaned with a flat scraper such as a putty knife. Caution: The drip pan must be kept clean and free of heavy buildup for grill to perform properly and to eliminate flare-ups. Drip pan should not be washed completely clean.
3. Inside grill – Use warm soapy water to clean this area. Do not allow grease to build up. 4. Drain pipe – Drain pipe must be kept clear of grease and food particles to allow grease to drain properly
from drip pan. This must be done to maintain proper operation of your grill. 5. General – This grill, like all equipment, will look better and last longer if kept out of weather when not in
use. Caution: Do not store propane cylinders in enclosed spaces. When using a cover or moving the grill; always wait until the grill has cooled for at least 30 minutes.
This unit should be kept in an area clear and free from combustible materials, gasoline and other flammable vapors and liquids.
Check to be sure all openings into grill body are free of blockages or debris. Make sure there are no objects or materials blocking the flow of combustion or ventilation. Make sure the stacks are in the up position when using the grill.
When grill is not use, turn regulator knob to “OFF,” remove propane cylinder from regulator and remove regulator from burner.
For outdoor use only, if stored indoors, detach cylinder and leave it outdoors. Cylinders must be stored out of reach of children.
Check burner air inlet openings (behind inlet guard on right end of body) for insect nests or blockages. Make sure the slots in burner tube are open
Important
First-time use. It is important that the grill be lit and allowed to operate at least 30 minutes before any food is placed on the grill grid. Some smoke may appear during the initial operation of the grill. This is normal. These are the preservatives used during manufacturing. After initial heating, grill is ready for use. After burning off the grill, spray the cooking grid, drip pan and inside of the lid, so food does not stick to the grid and the inside is easier to clean
THIS COOKING APPLIANCE IS FOR OUTDOOR USE ONLY AND SHALL NOT BE USED IN A BUILDING, GARAGE OR ANY OTHER ENCLOSED AREA.
MOVING INSTRUCTIONS Caution: Never move the grill with burner lit
Transporting grill: Make sure gas control is off. Disconnect propane cylinder from regulator. Remove regulator from grill. Be sure grill has completely cooled for at least 30 minutes. Close lid and secure latch. Place stacks in down position if necessary. Carry grill by handle between stacks. Note: It is best to leave the grease pan in place attached to the bottom of the grill-some grease may continue to
drip from drainpipe during transport.
Setting up for use: Find a flat surface. Grill must be on a level surface to operate properly.
10

Cooking Instructions
1. Allow grill to warm up with lid closed for 20-30 minutes prior to cooking. 2. This BBQ Grillware Table Top Grill model is equipped with an adjustable HIGH/MED/LOW burner
control. This allows for complete flexibility in cooking temperatures. HIGH setting has a cooking temperature of approximately 450 degrees F. MED is approximately 400 degrees F. LOW is approximately 350 degrees F. 3. The cooking times we suggest are only that-suggestions. You may want to vary the times as you become used to your grill. 4. You may cook on the grill in any weather. If the temperature is extremely cold or hot, it will slightly decrease or increase your cooking times. Keep grill out of reach of excessive winds when operating, as it may increase cooking times. GRILLING 1. Steak-T-bone, thick, medium: grill 10 minutes on each side at MED setting. 2. Chicken – Quarters, average size fryer: Cook skin side up for 30 minutes and skin side down for 30 minutes at MED setting. Check for doneness. If chicken is completely done, only then dip or brush on the sauce or your choice. Put back on grill for approximately 10 minutes longer. Note: You may want to repeat this process one or two more times. 3. Pork ribs and pork chops; grill 10-20 minutes on each side, MED setting. When done, drip or brush on sauce. Put back on grill for 5-10 minutes. Repeat if desired. GRILLING INSTRUCTIONS · Fish grilling: Allow grill to warm up for 15 minutes. Place fish on grill and season to taste. Allow 20-30 minutes total grilling time, turning at half the grilling time if desired (turning is not necessary). · Chicken halves or quarters: Place on grill for 60 minutes. Turn off at 30 minutes if desired. · Steak ~ -thick: Allow grill to warm for 15 minutes, and then place steaks on grill. Allow 6-10 minutes per side. The minutes on each side will produce medium-well to well-done steaks. · Hamburger: same as steak. · Ribs: Allow grill to warm up for 15 minutes, place ribs on grill. Allow 40-60 minutes grilling time. Turn at half the grilling time if desired not necessary). Baste or dip in sauce at any time. · Whole chicken: Allow grill to warm up. Season chicken with seasoning mix. Grill for 1-1/2 hours. · Turkey breast: Allow grill to warm up. Grill 10 minutes per pound or until internal temperature reaches 170° F.
11

TROUBLE SHOOTING

SPIDER AND INSECT WARNING!!! Spiders and insects can nest in the burners of the grill and cause the gas to flow from the front of the burner. This is a very dangerous condition, which can cause a fire to occur, thereby damaging the grill and making it unsafe to operate.
WHEN TO LOOK FOR SPIDERS You should inspect the burners twice a year or immediately after any of the following conditions occur:

1. The smell of gas in conjunction with the burner flames appearing yellow.
2. The grill does not reach temperature. 3. The grill heats unevenly. 4. The burners make popping noises.
BEFORE CALLING FOR SERVICE If the grill does not function properly, use the following checklist before contacting your dealer for service.

CHECK LIST

PROBLEMS Grill won’t light when the control knob is turned to on.

WHAT TO DO Check to see if the tank is empty. Check burner ports for any blockage. Use soft wire brush to clear plugged ports. Check the gas orifice on the malfunctioning burner for an obstruction. If orifice is blocked, Clean it with a needle or a thin wire. NEVER USE A WOODEN PICK.

Burner flame is yellow or orange, in conjunction with the odor of gas.
Low heat with knob in “HI” position.

Call our customer service line 1-800-913-8999.
Is the fuel hose bent or kinked?
Is the grill in a dusty area? Is there adequate gas supply available? If it is only one burner that appears low, does the orifice or burner need cleaning? Is the gas supply, or gas pressure low? Is the grill being preheated for 15 minutes?

12

LIMITED WARRANTY MODEL 720-0001 STAINLESS STEEL OUTDOOR GAS GRILL

Nexgrill Industries, Inc. warrants to the original consumer purchaser of each Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This warranty excludes grills used in rental or commercial applications.

Component

Warranty Period:

Burners: Stainless Steel Flame Tamer: Stainless Steel Cooking Grids: Regulator All Stainless Steel Parts

3 Years 2 Years 3 Years 1 Year 3 Years

Our obligation under this warranty is limited to repair or replacement, at our option, of the product during the warranty period. The extent of any liability of Nexgrill Industries, Inc under this warranty is limited to repair or replacement. This warranty does not cover normal wear of parts, discoloration of the stainless steel parts, or damage resulting from any of the following: negligent use or misuse of the product, use on improper fuel/gas supply, use contrary to operating instructions, or alteration by any person other than our factory service center. The warranty period is not extended by such repair or replacement.

Warranty claim procedure: If you require service or parts for your grill, please contact our Warranty Service Center for factory direct assistance. Our hours of operation are 7 AM to 6 PM PST Monday to Friday, 8 AM to 12 PM PST on Saturday. Our number is 1-800-913-8999 and our FAX number is 1-800-598-8829. Please direct all correspondence to: Nexgrill Industries, Inc. 145 Brea Canyon Road, Walnut, CA 91789 ATTN: Warranty Service Center.

Product repair as provided under this warranty is your exclusive remedy. Nexgrill Industries, Inc. shall not be liable for any incidental or consequential damages for breach of any express or implied warranty on its products. Except to the extent prohibited by applicable law, any implied warranty of merchantability or fitness for a particular purpose on this product is limited to the duration of the above warranty. Some states do not allow the exclusion or limitation of incidental or consequential damages, or allow limitations on how long an implied warranty lasts, so the above limitations or exclusions may not apply to you. This warranty gives you specific legal rights, and you may have other rights, which vary from state to state.

Printed In China 13

References

• Repair Your Grill: Shop Replacement Parts for 24,880 Models
• Nex - Old Grill Parts - Select From 32 Models

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>