Honeywell 16200 Clean Tabletop Air Purifier Owner’s Manual

HONEYWELL 16200
Owner’s Manual

16200 Clean Tabletop Air Purifier

This Owner’s Manual is provided and hosted by Appliance Factory Parts.

Appliance Factory Parts
Experts in BBQ, Humidifier, & Appliance Parts
 1-800-955-7075

Repair Your Grill: Shop Replacement Parts for 24,880 Models (appliancefactoryparts.com)

Shop genuine replacement parts for HONEYWELL 16200

Find Your HONEYWELL Air Cleaner Parts – Select From 215 Models
——– Manual continues below ——–

PLATINUM AIR™
AIR PURIFIER
Model 16200

IMPORTANT SAFETY INSTRUCTIONS

READ AND SAVE THESE SAFETY INSTRUCTIONS BEFORE USING THIS PRODUCT.
When using electrical appliances, basic precautions should always be followed to reduce the risk of fire, electric shock, and injury to persons, including the following:

1. Read all instructions before operating the air cleaner.
2. Place air cleaner where it is not easily knocked over by persons in the household.
3. Always turn the air cleaner controls to the OFF position and unplug from the wall outlet when not in use.
4. To disconnect the air cleaner, first turn controls to the OFF position, grip the plug and pull it from the wall outlet. Never pull by the cord.
5. Do not use any product with a damaged cord or plug or if product malfunctions, is dropped or damaged in any manner. Keep the cord away from heated surfaces.
6. Do not use air cleaner outdoors.
7. Never use air cleaner unless it is fully assembled.
8. Do not run power cord under carpets, and do not cover with throw rugs. Arrange cord such that it will not be tripped over.
9. Do not use air cleaner where combustible gases or vapors are present.
10. Do not expose the air cleaner to rain, or use near water, in a bathroom, laundry area or other damp location.
11. The air cleaner must be used in its upright position or horizontal position only.
12. Do not allow foreign objects to enter ventilation or exhaust opening as this may cause electric shock or damage to the air cleaner. Do not block air outlets or intakes.
13. Locate air cleaner near the outlet and avoid using an extension cord.
14. This appliance has a polarized plug (one blade is wider than the other). To reduce the risk of shock, this plug is intended to fit only one way in a polarized outlet. If the plug does not fit fully in the outlet, reverse the plug. If it still does not fit, contact a qualified electrician. DO NOT attempt to defeat this safety feature.
15. A loose fit between the AC outlet (receptacle) and plug may cause overheating and a distortion of the plug. Contact a qualified electrician to replace loose or worn outlet.
16. Do not sit, stand or place heavy objects on the air cleaner.
17. Disconnect power supply before servicing.
18. SAVE THESE INSTRUCTIONS

WARNING: TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK, DO NOT USE THIS AIR CLEANER WITH ANY SOLID-STATE SPEED CONTROL DEVICE.

The Honeywell trademark is used by Kaz, Inc. under license from Honeywell Intellectual Properties, Inc.

HOW YOUR AIR PURIFIER WORKS:

This model air purifier incorporates a 4-stage cleaning system to help clean the air that passes through the filter in the unit (Fig. 1).
Stage 1: Washable Particle Pre-Filter
Stage 2: Odor-Lock™ Carbon Filter
Stage 3: 99% HEPA Filter with ProTec™ antimicrobial treatment
Stage 4: Electronic Ionizer

SET-UP:

• Select a firm, level and flat location. For proper airflow, locate the unit at least 3 feet (1 M) from any wall or furniture.
• When operating, large volumes of air are drawn toward the air purifier. Surrounding areas should be cleaned and/or vacuumed frequently to prevent build-up of dust and other contaminates. This may also help prolong the life of the filter. If the unit is placed on a light colored carpet, a small mat or rug should be used underneath to prevent permanent staining. This is especially important in homes with contamination from smoking or fireplaces.

INSTALL MAIN FILTER:

The Filter is supplied within the air purifier. It is wrapped to ensure purity.

• Turn-off and unplug the air purifier. While pressing on the two notches along the front grille, pull the grille towards you and remove it (See Fig. 2). Gently push down on the top filter frame and pull forward.
• Remove the protective wrap from the Filter.
• Place back into the air purifier housing and snap filter grille into place.

OPERATION:

• Ensure the air purifier is plugged into a working electrical outlet and the Power Knob and Ionizer Knob are OFF.
• Start and run the air purifier on High for several minutes and then rotate the Power Knob to the desired cleaning level.

It is recommended you run your air purifier 24 hours a day to ensure continuous cleaning.
Portable air purifiers are more effective in rooms where all doors and windows are closed.

IONIZER FEATURE:

The Ionizer helps boost the performance of the air purifier and helps freshen the air.

• Turn the Ionizer Control Knob (See Fig. 3) to the ON position. This will power the Ionizer on. To turn the Ionizer feature off, simply turn knob to the OFF position.

ELECTRONIC FILTER CHANGE REMINDER:

This model air purifier has an electronic filter check to remind you when to check or replace the Main filter based on the air cleaner’s hours of use.
Once a filter has reached the end of its expected life, its light will remain on until it is RESET. You may unplug the air cleaner without interrupting the filter check.
A red LED light will illuminate when it is time to change the filter. Please replace with Honeywell® Main replacement filter number 16216.
You should periodically check the filter.
Depending on operating conditions, the Filter should be replaced every 6 months.

To RESET the Electronic Filter Check:

When the filter monitor light remains on, it is time to check/replace the Main filter and reset the filter monitor, if needed. With the unit powered on, insert the tip of a ball-point pen or paperclip next to the LED filter check light and hold for approximately 5 seconds until the light turns off (Fig 4). Depending upon your individual usage (environment and hours used), you may need to check and replace the filter more or less frequently. If the Main filter is replaced before the filter monitor light turns on, the filter monitor should be reset at the same time.

MAINTAINING YOUR STAGE 1 WASHABLE
PARTICLE PRE-FILTER:

The stage 1 particle pre-filter helps pick up large airborne particles that enter the front grille. This pre-filter can be periodically removed and shaken to clean it. Alternatively, it can be rinsed by hand under warm water.
Let the pre-filter air dry completely before inserting back into the unit. If you need to replace this item, please see Consumer Relations section on the next page.

WHEN TO REPLACE THE MAIN FILTER?
These replacement intervals are intended as guidelines only. Useful life expectancy of any filter media is dependent upon the concentration of contaminates going through the system. High concentrations of contaminates such as dust, pet dander and smoking will reduce the useful life of the filter.
NOTE: The Main filter is not washable.

CLEANING AND STORAGE:

We recommend that you clean the air purifier at least once a month and before extended storage.
Use only a dry cloth to wipe the external surfaces of the air purifier. DO NOT USE WATER, WAX POLISH, OR ANY CHEMICAL SOLUTION.
If your Air Purifier will not be used for more than 30 days, we recommend:

• Remove the Main Filter from the unit.
• Wrap the Main Filter in an air tight plastic bag.

FREQUENTLY ASKED QUESTIONS:

My Air Purifier is starting to make noise and the air output is less. What’s wrong?

The filters may be dirty. High amounts of contaminates can block the pores in the filter and stop the air from moving through it. Replace the Filter.

How long should I run my Air Purifier?

For best results, you should operate your Air Purifier 24 hours a day. This unit will be more effective when doors and windows are closed.

Can I wash my Main filter?

No. Washing the Main filter will destroy it.

For more troubleshooting tips, visit our website at: www.kaz.com

CONSUMER RELATIONS:

NOTE: IF YOU CONTINUE TO EXPERIENCE A PROBLEM, PLEASE RETURN THE AIR PURIFIER TO THE PLACE OF ORIGINAL PURCHASE OR SEE YOUR WARRANTY. DO NOT ATTEMPT TO OPEN THE AIR PURIFIER YOURSELF. DOING SO MAY VOID YOUR WARRANTY AND CAUSE DAMAGE TO THE PRODUCT OR PERSONAL INJURY. IF YOU HAVE ANY QUESTIONS REGARDING THE AIR PURIFIER, PLEASE CALL OR WRITE:

Kaz Home Environment
Consumer Relations Department
250 Turnpike Road
Southborough, MA 01772
Toll Free: 1-800-332-1110
E-mail: consumerrelations@kaz.com

ACCESSORIES, REPLACEMENT FILTERS:

To order replacement Filter (16216), visit our
website at: www.kaz.com or call us at 1-800-3321110.
Washable Pre-Filter 16266: $5.25
Main Filter 16216: $29.99

3 YEAR LIMITED WARRANTY

You should first read all instructions before attempting to use this product.
Register your product on-line at www.kaz.com or complete and return the Customer Response Card within 7 days.

A. This 3 year limited warranty applies to repair or replacement of product found to be defective in material or workmanship. This warranty does not apply to damage resulting from commercial, abusive, unreasonable use or supplemental damage. Defects that are the result of normal wear and tear will not be considered manufacturing defects under this warranty.
KAZ IS NOT LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES OF ANY NATURE. ANY IMPLIED WARRANTY OF

MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE ON THIS PRODUCT IS LIMITED IN DURATION TO THE DURATION OF THIS WARRANTY.

Some jurisdictions do not allow the exclusion or limitation of incidental or consequential damages or limitations on how long an implied warranty lasts, so the above limitations or exclusions may not apply to you. This warranty gives you specific legal rights, and you also may have other rights which vary from jurisdiction to jurisdiction. This warranty applies only to the original purchaser of this product from the original date of purchase.

B. At its option, Kaz will repair or replace this product if it is found to be defective in material or workmanship. Defective product should be returned to the place of purchase in accordance with store policy. Thereafter, while within the warranty period defective product may be returned to Kaz.
C. This warranty does not cover damage resulting from any unauthorized attempts to repair or from any use not in accordance with the instruction manual.
D. Return defective product to Kaz Home Environment with a brief description of the problem. Include proof of purchase and a $10 US / $15.50 CAN check or money order for handling, return packing and shipping charges. Please include your name, address and daytime phone number. You must prepay shipping charges. Send to:

In US:
Kaz Home Environment
Attn: Returns Department
4755 Southpoint Drive
Memphis, TN 38118
USA

In Canada:
Kaz Home Environment
Attn: Returns Department
510 Bronte Street South
Milton, ON L9T 2X6
Canada

Patent Pending

© 2003 Kaz, Inc. All Rights Reserved.
P/N: 035-04007-000, Rev 1
Artwork: 043-01271-000

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>