SOLAIR J30HB-A Wall Mounted Packaged Heat Pump User Manual
- June 7, 2024
- SOLAIR
Table of Contents
REPLACEMENT PARTS MANUAL
Wall Mounted
Packaged Heat Pump
Manual: 2110-1555C
Supersedes: 2110-1555B
Date: 4-19-21
Models:
| J30HB-A | J36HB-A |
|---|---|
| J30HB-B | J36HB-B |
| J30HB-C | J36HB-C |
General Notes
- Revised and/or additional pages may be issued from time to time.
- A complete and current manual consists of pages shown in the following contents section.
Important
Contact the installing and/or local distributor for all parts requirements.
Make sure you have the complete model and serial number available from the
unit rating plates.
CABINET COMPONENTS
| Dwg No. | Part Number | Description | J30HB-A, B | J30HB-C | J36HB-A, B | J36HB-C |
|---|---|---|---|---|---|---|
| 1 | S127-471 | Lower Base | X | X | X | X |
| 2 | 125-081 | Fan Shroud | X | X | X | X |
| 3 | S501-933-X | Right Side | X | X | X | X |
| 4 | S501-934-X | Left Side | X | X | X | X |
| 5 | S533-228-X | Control Panel Cover (Outer) | X | X | X | X |
| 6 | S521X527 | Condenser Partition | X | X | X | X |
| 8 | 121X467 | Blower Partition | X | X | X | X |
| 9 | S507-308-X | Top | X | X | X | X |
| 10 | S111X030 | Outlet Air Frame Assembly | X | X | X | X |
| 11 | S509-451 | Upper Back | X | X | X | X |
| 12 | 113X480 | Filter Bracket | 2 | 2 | 2 | 2 |
| 13 | S132-104 | Control Panel Cover (Inner) | X | X | X | X |
| 13 | S132-172 | Control Panel Cover (Inner) | 2 | 2 | 2 | 2 |
| 14 | 118-124-X | Side Grille | X | X | X | X |
| 15 | 118-103-X | Condenser Grille | X | X | X | X |
| 16 | BFAD-3 | Fresh Air Damper Assembly | X | X | X | X |
| 17 | S553-523-X | Vent Option Door | X | X | X | X |
| 18 | S514-241-X | Upper Front | X | X | X | X |
| 19 | 105X850 | Side Support | X | X | X | X |
| 20 | S543-175-X | Right Side Cover Plate (Outer) | X | X | X | X |
| 21 | S123-127 | Drain Pan | X | X | X | X |
| 22 | 147-044 | Evaporator Support | X | X | X | X |
| 24 | Control Panel Assembly | See Control Panel Assy. Drawing & Parts List | ||||
| Assy. | X | X | X | X | ||
| 25 | 113-140 | Bottom Mounting Bracket | X | X | X | X |
| 26 | 135X123 | Heat Shield | X | X | X | X |
| 27 | S153-218-X | Disconnect Access Door | X | X | X | X |
| 28 | 137-259 | Fill Plate | X | X | X | X |
| 29 | 113-149-X | Top Rain Flashing | X | X | X | X |
| 30 | S553-524-X | Filter Door | X | X | X | X |
| 31 | S536-498 | Cond. Partition Block Off Plate | X | X | X | X |
| 32 | 105-1302 | Grommet Retainer | X | X | X | X |
| 33 | 135-329 | Air Baffle | X | X | X | X |
| 35 | 109-450 | Lower Back | X | X | X | X |
FUNCTIONAL COMPONENTS
Dwg No.+GA1:H33| Part Number| Description| J30HB-A| J30HB-B| J30HB-C| J36HB-A|
J36HB-B
---|---|---|---|---|---|---|---
1| 8000-277| Compressor| X| X| X| X| X
1| 8000-365| Compressor| X| X| X| X| X
1| 8000-366| Compressor| X| X| X| X| X
1| 8000-278| Compressor| X| X| X| X| X
1| 8000-283| Compressor| X| X| X| X| X
1| 8000-342| Compressor| X| X| X| X| X
NS| 3000-1224| Molded Compressor Wire Harness (1-PH)| X| X| X| X| X
NS| 3000-1231| Molded Compressor Wire Harness (3-PH)| X| X| X| X| X
2| 900-360-003| Blower Assembly| X| X| X| X| X
2| 900-361-003| Blower Assembly| X| X| X| X| X
2| 900-360-004| Blower Assembly| X| X| X| X| X
2| 900-361-004| Blower Assembly| X| X| X| X| X
3| 8200-001| Fan Motor Mount| X| X| X| X| X
4| 5151-045| Fan Blade| X| X| X| X| X
5| 8103-029| Outdoor Fan Motor| X| X| X| X| X
5| 8103-030| Outdoor Fan Motor| X| X| X| X| X
6| 917-0320BX| Outdoor Coil (Includes Distributor)| X| X| X| X| X
6| 917-0387BX| Outdoor Coil (Includes Distributor)| X| X| X| X| X
7| 800-0486| Cooling Distributor Assembly| X| X| X| X| X
7| 800-0426| Cooling Distributor Assembly| X| X| X| X| X
8| 917-0389BX| Indoor Coil (Includes Cooling Distributor)| X| X| X| X| X
8| 917-0401BX| Indoor Coil (Includes Cooling Distributor)| X| X| X| X| X
9| 7004-026| Air Filter 2″ Pleated Disposable| 2| 2| X| X| X
10| 1171-022| urn Fastener| X| X| X| X| X
11| 1171-024| urn Retainer| X| X| X| X| X
12| 1171-023| urn Receptacle| X| X| X| X| X
13| 5650-039| Reversing Valve w/24V Solenoid Coil| X| X| X| X| X
14| 5650-046| Reversing Valve 24V Solenoid| X| X| X| X| X
15| 5650-044| Molded Plug 53″ Lead| X| X| X| X| X
16| 5201-019| Filter Drier, Bi-Directional, 3/8″ Connections| X| X| X| X| X
17| 8620-224| Defrost Sensor Kit| X| X| X| X| X
18| 5651-200| Heating Expansion Valve| X| X| X| X| X
18| 5651-231| Heating Expansion Valve| X| X| X| X| X
19| 8406-142| High-Pressure Switch (650#) Screw On| X| X| X| X| X
20| 5625-023| Heating Distributor| X| X| X| X| X
20| 5625-127| Heating Distributor| X| X| X| X| X
NS| 8406-135| Low-Pressure Switch (14#) Screw On| X| X| X| X| X
NS| 6031-009| Carmax Valve Core (Service Port)| 2| X| X| X| X
NS| S8406-105| Low Ambient Fan Cycling Control (350#/225#)| X| X| X| X| X
NS| 1171-028| Filter Door Clip| X| X| X| X| X
NS| 1171-057| Filter Door Screw| X| X| X| X| X
NS| 1171-027| Filter Door Screw Retainer| X| X| X| X| X
CONTROL PANEL – 230 VOLT 1 PHASE UNITS
| Dwg No. | Part Number | Description | J30HB-A | J36HB-A |
|---|---|---|---|---|
| 1 | 117X137 | Control Panel Top – RH (Sheet Metal Only) | X | X |
| 2 | 117X374 | Control Panel – RH (Sheet Metal Only) | X | X |
| 3 | 117X375 | Low Voltage Box – RH (Sheet Metal Only) | X | X |
| 4 | 117X385 | Low Voltage Partition – RH (Sheet Metal Only) | X | X |
| NS | 3000-1494 | Low Voltage Wire Harness (behind LVTS) | X | X |
| NS | S910-2047 | Complete Low Voltage Box Assembly | X | X |
| 5 | 141-188 | (Sheet Metal, LVTS & Wire Harness) | X | X |
| 6 | 135-122 | Plug Support Bracket (Sheet Metal) | X | X |
| 7 | 8401-033 | Wire Shield (Sheet Metal) | X | X |
| 8 | 8407-068 | Contactor 2-Pole | X | X |
| 9 | 8201-130 | Transformer 208/240-24, 50VA | X | X |
| 10 | 8620-223 | Relay, SPDT | X | X |
| 11 | 8607-044 | Defrost Board Replacement Kit w/Sensor | X | X |
| 12 | 8607-042 | Blower Speed Strip | X | X |
| 13 | 8611-006 | Blower Speed Terminal | X | X |
| 25 | 8611-140-1400 | Ground Lug | X | X |
| 26 | 8611-140-0500 | 14″ Cable Duct | X | X |
| 27 | 8552-052 | 5″ Cable Duct | X | X |
| 28 | 8550-008 | Capacitor 45+5/370V, 2-1/2″ Round | X | X |
| NS | 3003-058 | Capacitor Strap, 2-1/2″ Round | X | X |
| NS | 8201-086 | Main Control Panel Wire Harness | X | X |
| NS | 3000-1598 | LAC Relay | X | X |
| NS | 3000-1599 | Blower Power Plug | X | X |
| NS | 4096-168 | Blower Speed Plug | X | X |
| NS | 4096-168 | Wiring Diagram | X | X |
CONTROL PANEL – 230 VOLT 3 PHASE UNITS
| Dwg No. | Part Number | Description | J30HB-B | J36HB-B |
|---|---|---|---|---|
| 1 | 117X137 | Control Panel Top – RH (Sheet Metal Only) | X | X |
| 2 | 117X374 | Control Panel – RH (Sheet Metal Only) | X | X |
| 3 | 117X375 | Low Voltage Box – RH (Sheet Metal Only) | X | X |
| 4 | 117X385 | Low Voltage Partition – RH (Sheet Metal Only) | X | X |
| NS | 3000-1494 | Low Voltage Wire Harness (behind LVTS) | X | X |
| NS | S910-2047 | Complete Low Voltage Box Assembly | X | X |
| 5 | 141-188 | (Sheet Metal, LVTS & Wire Harness) | X | X |
| 6 | 135-122 | Plug Support Bracket (Sheet Metal) | X | X |
| 7 | 8401-035 | Wire Shield (Sheet Metal) | X | X |
| 8 | 8407-068 | Contactor 3-Pole | X | X |
| 9 | 8201-130 | Transformer 208/240-24, 50VA | X | X |
| 10 | 8620-223 | Relay, SPDT | X | X |
| 11 | 8607-044 | Defrost Board Replacement Kit w/Sensor | X | X |
| 12 | 8607-042 | Terminal Strip | X | X |
| 13 | 8611-006 | Blower Speed Terminal | X | X |
| 25 | 8611-140-1400 | Ground Lug | X | X |
| 26 | 8611-140-0500 | 14″ Cable Duct | X | X |
| 27 | 8552-002 | 5″ Cable Duct | X | X |
| 28 | 8550-003 | Capacitor 5/370V, 1-1/4″ Oval | X | X |
| 29 | 8201-126 | Capacitor Strap, 1-1/4″ Oval | X | X |
| NS | 3003-059 | 3 Phase Line Monitor | X | X |
| NS | 8201-086 | Main Control Panel Wire Harness | X | X |
| NS | 3000-1598 | LAC Relay | X | X |
| NS | 3000-1599 | Blower Power Plug | X | X |
| NS | 4096-270 | Blower Speed Plug | X | X |
| NS | 4096-271 | Wiring Diagram | X | X |
CONTROL PANEL – 460 VOLT 3 PHASE UNITS
| Dwg No. | Part Number | Description | J30HB-C | J36HB-C |
|---|---|---|---|---|
| 1 | 117X137 | Control Panel Top – RH (Sheet Metal Only) | X | X |
| 2 | 117X374 | Control Panel – RH (Sheet Metal Only) | X | X |
| 3 | 117X375 | Low Voltage Box – RH (Sheet Metal Only) | X | X |
| 4 | 117X385 | Low Voltage Partition – RH (Sheet Metal Only) | X | X |
| NS | 3000-1494 | Low Voltage Wire Harness (behind L | X | X |
| NS | S910-2047 | Complete Low Voltage Box Assembly | X | X |
| 5 | 141-188 | (Sheet Metal, LVTS & Wire Harness) | X | X |
| 6 | 135-122 | Plug Support Bracket (Sheet Metal) | X | X |
| 7 | 8401-035 | Wire Shield (Sheet Metal) | X | X |
| 8 | 8407-069 | Contactor 3-Pole | X | X |
| 9 | 8201-032 | transformer 460-24, 50VA | X | X |
| 10 | 8620-223 | Relay, SPDT, 3 FLA@480V | X | X |
| 11 | 8607-044 | Defrost Board Replacement Kit w/Sensor | X | X |
| 12 | 8607-042 | erminal Strip | X | X |
| 13 | 8611-006 | Blower Speed Terminal | X | X |
| 25 | 8611-140-1400 | Ground Lug | X | X |
| 26 | 8611-140-0500 | 14″ Cable Duct | X | X |
| 27 | 8552-002 | 5″ Cable Duct | X | X |
| 28 | 8550-003 | Capacitor 5/370V, 1-1/4″ Oval | X | X |
| 29 | 8201-126 | Capacitor Strap, 1-1/4″ Oval | X | X |
| NS | 3003-060 | 3 Phase Line Monitor | X | X |
| NS | 8201-086 | Main Control Panel Wire Harness | X | X |
| NS | 3000-1598 | LAC Relay | X | X |
| NS | 3000-1599 | Blower Power Plug | X | X |
| NS | 4096-368 | Blower Speed Plug | X | X |
BLOWER ASSEMBLY
Dwg No.| Part Number| Description| | |
---|---|---|---|---|---
1| S8106-068-0171| Blower Motor & Control (230/208V)| X| X| X
1| S8106-069-0172| Blower Motor & Control (460V)| O| O| O
1| S8106-068-0173| Blower Motor & Control (230/208V)| 2| 2| 2
1| S8106-069-0174| Blower Motor & Control (460V)| X| X| X
1| C8106-068-0171| Programmed Control Only (230/208V)| X| X| X
1| C8106-069-0172| Programmed Control Only (460V)| X| X| X
1| C8106-068-0173| Programmed Control Only (230/208V)| X| X| X
1| C8106-069-0174| Programmed Control Only (460V)| 6| 6| 6
2| 151-111| Housing| X| X| X
3| 144-174| Diffuser| X| X| X
4| 5152-090| Wheel CW| X| X| X
5| 5152-091| Wheel CCW| X| X| X
6| 105-870| Back Brace| X| X| X
7| 5451-011| Grommets| 6| 6| 6
8| 8200-031| Motor Mount| X| X| X
9| 103-401| Front Brace| X| X| X
10| 113-721| Motor Control Bracket| X| X| X
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>