ASTRAL POOL POOL RC1 TC Auto Doser Liquid Pool Blanket Instruction Manual

ASTRAL POOL POOL RC1 TC Auto Doser Liquid Pool Blanket

INTRODUCTION

Congratulations on your purchase of an Astral Pool RolaChem Liquid Pool Blanket Auto Dosing System. The Auto Dosing System is designed to accurately meter and dose your liquid pool blanket at as close as possible to the correct level each day and maintain your liquid pool blanket level in your pool to minimise evaporation. By minimising your evaporation, you pool will use substantially less water, save chemical costs and reduce heating costs. The RC 1 TC is designed for swimming pool with a surface area up to 105 square metres and the RC 5 TC is designed for commercial swimming pools with a surface area of up to 1250 Square Metres. Special models can be designed and manufactured for swimming pools outside of these dimensions. Note: The RolaChem dosing unit is not intended for use by young children or infirm persons without supervision. Please ensure that young children are supervised to ensure that they do not play with the Chlorinator.

SURFACE AREA CALCULATION

To calculate the surface area use the following formulas: Square or Rectangular Pools

Pool size is calculated by multiplying the length by width. 9 x 4.5 = 40.5 m2.

Free Form Pools

Pool size calculated by multiplying the length by the average width. If the narrow end was 3 meters wide and the large end was 5 meters assume an average width of 4 meters. Assuming a length of 8 meters the equation would be 8 x 4 = 32m2.INST 233 Rola Chem Liquid Pool Blanket Auto Doser V10.21

Round Pools

The surface of round pools is calculated using formula PiR2. Pi equals 3.14 and the radius is half the diameter of the pool. Therefore, a round pool with a diameter of 6 meters would have the following equation 3m (radius) x 3m x 3.14 = 28.26m2.

 INSTALLATION

The Rola Chem Dosing Control Box must be mounted on a fixed wall out of direct sunshine or rain. Mount 1.0 m above ground level to prevent splash back from rain and sprinkler systems Mount a minimum of 3.5 metres from pool water’s edge If installed outdoors, ensure control box is mounted under eaves or suitable enclosure protecting it from rain, water, or direct sunshine If installed outdoors ensure unit is plugged into a weather proof 240 Volt 10 amp power point. The dosing unit and the bottle of liquid blanket must be installed a minimum of 1500mm from any source of ignition or gas appliance

Before installing the unit in position on the wall or post, the length of dosing tube provided should be measured and taken into consideration. To avoid loss of water from the system, close all stop valves before cutting any lines.

OPERATION

The Rola Chem Liquid Pool Blanket Dosing system is simple to operate. Starting for the first time

1.  Turn power supply on.
2.  Set Time Clock to current time.
3.  ENSURE Rola Chem Time clock and Filter Pump Time clock are exactly synchronised.
4.  Put time clock on manual until Liquid Pool Blanket is pumped through the clear dosing tube to the injection “T”.
5. Switch time clock back through to OFF POSITION (Pump should now be off) now switch to Auto Position.

Failing to cycle the time clock through to the OFF POSITION before switching to AUTO will leave the PUMP RUNNING and will empty the ACID Drum in a very short period of time.

Setting Operating times

In order to gain the most benefit from your Liquid Pool Blanket it is important to dose into the pool at the end of the last filtration cycle each day This allows the maintenance dose to be fed into the pool and then settle on top of the pool water without ongoing disturbance by pumps or other activities. INST 233 Rola Chem Liquid Pool Blanket Auto Doser V10.21The following tables indicates how many minutes each day the Rola Chem Dosing system should operate for your size pool.

Domestic Pools

Setting timer on period:

1.  Establish when your filter pump turns off at the end of each day. Most domestic swimming pools are set to have two filtration periods each day eg: (8am to 12 midday and 4pm to 8pm)
2.  Establish the number of minutes your Rola Chem needs to operate each day from the above tables. (Eg: A 40.5 Square Metre pool requires the RC 1 TC to operate for nine minutes each day.
3.  Set the timer on the Rola Chem to come on 9 minutes before the filter pump turns off at the end of the day (eg: 7.51pm)
4.  Set the timer on the Rola Chem to turn off the same time as the filter pump turns off (eg: 8pm)
5.  Once you have finished programming the timers, it is essential that you cycle the time-clock through to the OFF POSITION (ensure pump is OFF) before going to the Auto position. The dosing motor should now be off. (unless unit is in a timer cycle)

Failing to cycle the time clock through to the OFF POSITION before switching to AUTO will leave the PUMP RUNNING and will empty the ACID Drum in a very short period of time. Your Rola Chem will now automatically dose the correct level of Liquid Pool Blanket each day at the most effective time.

MAINTENANCE

On going maintenance will ensure the best performance and a high degree of reliability from your Rola Chem Liquid Pool Blanket Dosing System.

1.  Keep Rola Chem control box free of debris, leaves and insects. It is a good idea to spray surface insect repellent around the wall, box and box of the Rola Chem every three months to reduce the chance of ingress by insects.
2.  Check your Liquid Pool Blanket container level each week to ensure there is sufficient liquid to last another week.
3.  Once every 12 months, grease the Rollers and Tubes in the Rola Chem pump with Silcone based grease to reduce wear on the dosing tube.
4.  A greased and well-maintained tube should last 3 to 5 years but will then need to be replaced. Periodically, check dosing tube for cracks or leaks.
5.  The appliance is not intended for use by young children or infirm person without supervision. Please ensure that young children are supervised to ensure that they do not play with the appliance.
6.  If the supply cord is damaged, it must be replaced by the manufacturer or its service agent or a similarly qualified person in order to avoid a hazard.

GENERAL CONDITIONS

Astral Pool covers your Rola Chem Liquid Pool Blanket Doser with a limited 1 year warranty against defective materials and workmanship from the date of purchase (plus 30 days to allow for installation). Proof of purchase date must be provided in order to substantiate warranty claim. The warranty includes 12 months in field labour costs where the Rola Chem is installed in a capital city metropolitan area. Labour charges apply to units installed outside of these areas. Any costs for transport of faulty or replacement parts, removal or reinstallation are the owner’s responsibility.
Astral Pool assumes no liability for consequential damages of any kind. Like your motor vehicle, your new Rola Chem requires periodic service and maintenance to keep it operating in top condition and at maximum efficiency. An annual service by one of our qualified service technicians is highly recommended. Replacement of maintenance items are not covered by this warranty.

LIMITATIONS
All warranties only apply if the Rola Chem is installed and operated in complete compliance with the installation and operating instructions. The warranty shall not apply to any Rola Chem unit or parts that have been subject to accident, negligence, alteration, abuse or misuse. No person is authorised to make any warranties on Hurlcon’s behalf. To place a service call, contact your nearest Astral Pool office.

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>