EAC BC18V2 BATTERY SET User Manual

: June 5, 2024
: EAC

Table of Contents

General notes
Safety instructions
Intended use
Environmental protection
Warranty
Operation
Care and service
Troubleshooting guide
Technical data
References
Read User Manual Online (PDF format)
Download This Manual (PDF format)

BC 18 V 2,5 A, BC 36 V 2,5 A
User Manual 5.968-646.0 (03/21)
Register your product www.kaercher.com/welcome EAC BC18V2
BATTERY SET -

EAC BC18V2 BATTERY SET - 2

General notes

**** Read these original instructions and the original instructions and safety instructions supplied with the battery pack and device before using the device for the first time.

Hazard levels

DANGER

Indication of an imminent threat of danger that will lead to severe injuries or even death.

WARNING

Indication of a potentially dangerous situation that may lead to severe injuries or even death.

CAUTION

Indication of a potentially dangerous situation that may lead to minor injuries.

ATTENTION

Indication of a potentially dangerous situation that may lead to damage to property.

Safety instructions

DANGER

The danger of explosion. Do not charge non-rechargeable batteries.
Only use the charger for charging approved battery packs.
Inspect the charger and battery mount for damage every time before use. Do not use any damaged devices. Replace any damaged devices.
Check the power cable for damage each time before operating the device. Do not use a damaged power cable. If the power cable is damaged, replace it with an approved replacement. You can obtain a suitable replacement from KÄRCHER or one of our service partners.
Do not charge battery packs that are damaged or not completely functional. Dispose of damaged or non-functional battery packs immediately, following the applicable regulations on transport and disposal.
Do not use the charger in an explosive environment or near flammable objects.
Do not immerse the device in water or hold it under a water stream.
Do not charge the battery pack in explosive environments. Check the condition of the battery pack and charger regularly during the charging process.
If you notice a fault, unusual smells, or the development of heat during charging, disconnect the charger from the mains and the battery pack from the charger. Dispose of the battery pack and charger immediately and follow the applicable regulations on transport and disposal.

WARNING

Check that the mains voltage corresponds with the voltage stated on the type plate of the charger.
Protect the power cable from heat, sharp edges, oil, and moving parts.
Do not open the charger. Repairs are only to be carried out by qualified personnel.
Pull the plug out of the main socket before cleaning the charger or performing cleaning work.
Persons with reduced physical, sensory or mental capabilities and persons lacking experience and knowledge may only use the appliance if they are properly supervised, have been instructed on the use of the appliance safely by a person responsible for their safety, and understand the resultant hazards involved.
Children must not play with the appliance.
Children must be supervised to prevent them from playing with the device.
Children from the minimum age of 8 may use the appliance if they are properly supervised or have been instructed in its use by a person responsible for their safety, and if they have understood the resultant hazards involved.
Children may only perform cleaning work and user maintenance under supervision.

**CAUTION**

Do not operate the device together with other devices on an extension cable with multiple power sockets.
Do not pull the mains plug out of the socket using the power supply cable.
Do not use the battery pack when dirty or wet.
Do not put the battery pack into the battery mount of the charger if it is dirty or wet.
Do not use the charger in a dusty environment.

ATTENTION

Short circuit hazard. Protect the contacts of the battery mount from metal parts.
Never cover the charger during use.
Do not carry the charger by the power cable.
Use the charger only in dry interior spaces with low humidity.

Intended use

CAUTION
Risk of explosion!
Risk of injury and damage due to exploding battery pack.
Do not charge defective or not fully functional battery packs.
Modifications and changes not authorized by the manufacturer are prohibited.
Any other use is prohibited. The user shall be liable for hazards arising as a result of improper use.
Charge only battery packs from the KÄRCHER Battery Power / Battery Power+ system.

ATTENTION
The charger can only be used with battery packs of the same voltage type (18 V / 36 V). Do not charge any other voltage type of battery pack.
Before use, check that the voltage type (18 V / 36 V) of the battery pack and the device match.
The voltage information can be found on the device, on the battery pack, and on its nameplate.

Environmental protection

The packing materials can be recycled. Please dispose of the packaging in accordance with the environmental regulations.
Electrical and electronic appliances contain valuable, recyclable materials and often components such as batteries, rechargeable batteries, or oil, which – if handled or disposed of incorrectly – can pose a potential threat to human health and the environment. However, these components are required for the correct operation of the appliance. Appliances marked by this symbol are not allowed to be disposed of together with the household rubbish.

Notes on the content materials (REACH)
Current information on content materials can be found at: www.kaercher.com/REACH

Accessories and spare parts
Only use original accessories and original spare parts.
They ensure that the appliance will run fault-free and safely.
Information on accessories and spare parts can be found at www.kaercher.com.

Warranty

The warranty conditions issued by our relevant sales company apply in all countries. We shall remedy possible malfunctions on your appliance within the warranty period free of cost, provided that a material or manufacturing defect is the cause. In a warranty case, please contact your dealer (with the purchase receipt) or the next authorized customer service site. (See overleaf for the address)

Symbols on the device
Symbols on the charger

| Protect the device from moisture.
Store the device in a dry place. Do not subject the device to rain. The device is only suitable for indoor use.
---|---
| The battery pack is being charged, the indicator lamp is flashing.
| The battery pack is fully charged, and the indicator lamp lights up continuously.
| The device meets the requirements of protection class II.

Device description

Illustration A

Battery terminals
Battery mount
Indicator lamp
Wall attachment
Mains cable socket

Operation

Charging process
Note
The operating state of the battery pack can be read off the battery pack display.
The display symbols are described in the battery pack operating instructions. If the display does not show anything at the start of the charging process, the battery capacity is fully depleted or very low. The display shows the remaining charging time once the battery pack is sufficiently charged.
If the display does not show anything 2 minutes after the start of the charging process, the battery is defective and must not be further charged or used and must be disposed of immediately in accordance with applicable regulations.

Plug the main cable in the main cable socket.
Illustration B
Plug the mains plug into the socket.
Push the battery pack into the mounting on the charger.
Illustration C
The charging process begins automatically. The indicator light flashes green. The battery pack display shows the remaining charging time. The display shows 100% and the indicator lamp lights up green continuously when the battery pack is fully charged.
Remove the battery pack from the charger after charging.
Pull the mains plug out of the socket.

Note The charged battery pack can remain in the charger until it is used. There is no danger of overcharging. Avoid unnecessary energy consumption and unplug the charger when the battery pack is fully charged.

Wall attachment
The device is suitable for wall attachment. Information on the weight of the device is provided in the “Technical data” chapter.

CAUTION
Do not mount the device near or on flammable wall coverings such as wallpaper or wooden panels.

Check the load capacity of the wall before installation.
Keep the mains plug freely accessible. Hole distance = 66 mm.

Transport and storage

**CAUTION
Failure to observe the weight**
Risk of injury and damage
Be aware of the weight of the device during transport and storage.
Store the device only in dry indoor rooms.

Care and service

The device is maintenance-free.

Regularly check the battery terminals for soiling.
Clean dirty battery terminals.
Check the ventilation slits for soiling, and clean if necessary.
Occasionally recharge battery packs stored for a longer period.

Troubleshooting guide

Malfunctions often have simple causes that you can remedy yourself using the following overview. When in doubt, or in the case of malfunctions not mentioned here, please contact your authorized Customer Service.

Faults during charging
The battery pack not charging, and the display is on
Defective charger.

Replace the charger.

The battery pack not charging, the indicator lamp is on the quick charger is off, display off
The quick charger is defective.

Replace the quick charger.

The battery pack not charging, and the display is off
The battery pack is completely discharged or defective.

Wait and see if the display shows the remaining charging time after 2 minutes. If the display shows the remaining charging time after the waiting time, the battery pack can be used normally.
If the display does not appear, the battery pack is defective and may no longer be used. Immediately disconnect the battery pack from the charger and dispose of it according to regulations.

The battery pack not charging, and the display shows the temperature symbol
The battery pack temperature is too low/high. 1. Put the battery pack in a moderate temperature environment and wait until the battery pack temperature returns to the normal range, see the “Technical data” chapter.
The charging process begins automatically.

Technical data

BC 18 V BC 36 V

Electrical connection

Battery pack nominal voltage| V| 18| 36
Charging power max.| A| 2,5| 2,5
Battery pack type| | Li-ION| Li-ION
Battery platform| | Battery
Power| Battery
Power
Compatible with battery
platform| | Battery
Power +| Battery
Power +
Mains voltage| V| 100
240| 100
240
Frequency| Hz| 50 – 60| 50 – 60
Current consumption| A| 1,5| 1,5
Protection class| **| II| II
Dimensions and weights**
Weight (without battery pack)| kg| 0,6| 0,7
Permissible temperature range during the charging process| °C| Apr-40| Apr-40
Length x width x height| mm| 184 x
133 x 87| 184 x
133 x 87

Subject to technical modifications.

THANK YOU!
MERCI! DANKE! GRACIAS!
Register your product and benefit from many advantages.
www.kaercher.com/welcome
Rate your product and tell us your opinion.
www.kaercher.com/dealersearch

Alfred Kärcher SE & Co. KG
Alfred-Kärcher-Str. 28-40
71364 Winnenden (Germany)
Tel.: +49 7195 14-0
Fax: +49 7195 14-2212 EAC BC18V2 BATTERY SET - QR http://kaer.ch/er/?l=TwSoJtl9IUOwZyAe1rHDyw