Arctic King AC05ESWCR1RCM Chest Freezer Instruction Manual

Arctic King AC05ESWCR1RCM Chest Freezer Instruction Manual

INSTALLATION INSTRUCTIONS

Before Using Your Freezer

• Remove the exterior and interior packing.
• Check to be sure you have all of the following parts:
  • 1 Storage Basket
  • 1 Instruction Manual
  • 1 plastic scraper
• Before connecting the freezer to the power source, let it stand upright for approximately 2 hours. This will reduce the possibility of a malfunction in the cooling system from handling during transportation.
• Clean the interior surface with lukewarm water using a soft cloth.

Installing Your Freezer

• This appliance is designed to be free standing only, and should not be recessed or built-in.
• Place your freezer on a floor that is strong enough to support the freezer when it is fully loaded.
• Allow 15 cm of space between the back and sides of the freezer, which allows the proper air circulation.
• Locate the freezer away from direct sunlight and sources of heat (stove, heater, radiator, etc.). Direct sunlight may affect the acrylic coating and heat sources may increase electrical consumption. Extreme cold ambient temperatures may also cause the freezer not to perform properly.
• Avoid locating the freezer in moist areas.
• Plug the freezer into an exclusive, properly installed-grounded wall outlet. Do not under any circumstances cut or remove the third (ground) prong from the power cord. Any questions concerning power and/or grounding should be directed toward a certified electrician or an authorized service center.
• After plugging the appliance into a wall outlet, allow the unit to cool down for 2-3 hours before placing food in the freezer compartment.

Electrical Connection
For your safety please read the following information

OPERATING YOUR FREEZER

Temperature Control

• Your freezer has one control for regulating the temperature. The temperature control is located on the lower right hand corner.
• The range of the temperature control is from position “MIN, MAX and OFF”. Adjust the temperature control to the setting that best suits your needs.

NOTE:

• If the unit is unplugged, lost power, or turned off; you must wait 3 to 5 minutes before
• Restarting the unit. If you attempt to restart before this time delay, the freezer will not start.
• Large amounts of food will lower the cooling efficiency of the appliance.
• If you choose to change the thermostat setting, adjust thermostat control by one numerical increment at a time. Allow several hours for temperature to stabilise between adjustments.

Defrosting Your Freezer

• For the most efficient operation and minimum energy consumption, defrost the freezer when the frost on the freezer walls is excessive or 5 to 10 mm thick.
• Choose a time when the stock of frozen food is low.

CAUTION
Do not use boiling water because it may damage the plastic parts. In addition, never use a sharp or metallic instrument to remove frost as it may damage the cooling coils and will void the warranty. We recommend using the plastic scraper provided with your unit.

• Remove the frozen food from the freezer and place it in a cooler to protect the food.
• Unplug the freezer. The Power Supply light should be off (green light out).
• During defrosting, the ice melts into the cabinet.
• Remove the drain plug on the inside floor of the freezer by pulling straight out.
• Place a shallow pan outside drain outlet. The defrost water will drain out.
• Check the pan occasionally so the water does not overflow.
• Clean the interior of the freezer.
• Replace the plug on the inside floor.
• Reset the thermostat to desired setting.
• Allow the cabinet to cool for one hour.
• Return food to the freezer.

HELPFUL HINT:

Defrosting usually takes a few hours. Leaving the door open will help speed the process. Also, pouring warm water (not boiling) on the ice/frost will help speed melting. If you must use a scraper- please use caution – it is very easy to damage the freezer compartment and void your warranty.

The Freezer Compartment

• This compartment is designed for the long-term storage of frozen food. Storage time is up to three months.
• The storage life of frozen foods varies and the recommended storage time should not be exceeded. The instructions regarding the care of frozen foods should be followed when defrosting the freezer.
• Pre-packed commercially frozen food should be stored in accordance with the frozen foods manufacturer’s instructions for a three star frozen food storage compartment or home freezer.
• Place frozen food into the freezer as quickly as possible after purchase. If there are instructions on the packet, carefully follow these instructions regarding storage times.
• The freezer door is susceptible to breaking due to excessive ice build up. Be sure to defrost when the ice reaches 5 to 10 mm thick.
• A storage basket is provided for the organisation of odd-shaped items. To reach other packages in the freezer, just slide the basket to one side, or lift it out.

CARE AND MAINTENANCE

Cleaning Your Freezer

• Upon installation of your new appliance, it is recommended that it be cleaned thoroughly.

• Turn the temperature control to “MIN”, unplug the freezer, remove the food and storage basket.

• Wash the inside with a damp warm cloth containing a water and baking soda solution.
  The solution should be about 2 tablespoons of baking soda to a quart of water.

• Wash the storage basket with a mild detergent solution.

• Be sure to keep the door gasket (seal) clean to keep the unit running efficiently.

• The outside of the freezer should be cleaned with mild detergent and warm water.

• Dry the interior and exterior with a soft cloth.

• The condenser coils should be vacuumed when they are dusty or dirty.

• It is recommended that the unit be cleaned each time it is defrosted to help keep the unit door free and running efficiently.

Vacation Time

• Remove all the food.
• Unplug the freezer.
• Clean the freezer.
• Leave the door open slightly to avoid possible formation of condensation, mild, or doors.
• Use extreme caution in the case of children. The unit should not be accessible to child’s play.
• Short vacations: Leave the freezer operating during vacations of less than three weeks.
• Long vacations : If the appliance will not be used for several months, remove all food and unplug the power cord. Clean and dry the interior thoroughly. To prevent door and mild growth, leave the door open slightly: blocking it open if necessary or have the door removed.

Moving Your Freezer

• Remove all the food.
• Securely tape down all loose items inside your freezer.
• Remove the rollers to prevent damage.
• Tape the doors shut.
• Be sure the freezer stays in the upright position during transportation.

Energy Saving Tips

• The freezer should be located in the coolest area of the room, away from heat producing appliances or heating ducts, and out of the direct sunlight.
• Let hot foods cool to room temperature before placing in the freezer. Overloading the freezer forces the compressor to run longer. Foods that freeze too slowly may lose quality, or spoil.
• Be sure to wrap foods properly, and wipe containers dry before placing them in the freezer. This cuts down on frost build-up inside the freezer.
• Freezer storage bin should not be lined with aluminium foil, wax paper, or paper towelling. Liners interfere with cold air circulation, making the freezer less efficient.
• Organise and label food to reduce door openings and extended searches. Remove as many items as needed at one time, and close the door as soon as possible.

PROBLEMS WITH YOUR FREEZER

You can solve many common freezer problems easily, saving you the cost of a possible service call. Try the suggestions below to see if you can solve the problem before calling the service.
If the unit continues to operate improperly,call an authorised service depot or this Toll Free Number for assistance. Tel: (866) 646 4332

TROUBLESHOOTING GUIDE

blown fuse.
Compressor turns on and off frequently.| The room temperature is hotter than normal. A large amount of food has been added to the freezer.The door is open too often.The door is not closed completely.The temperature control is not set correctly. The door gasket does not seal properly.The freezer does not have the correctclearances.The freezer has recently been disconnected for a period of time. Four hours are required for the freezer to cool down completely.
Temperature inside the freezer is too warm.| Temperature control is set too warm. Turn the control to a cooler setting and allow several hours for the temperature to stabilize.Door is kept open too long or is opened too frequently. Warm air enters the freezer every time the door is opened. Open the door less often.The door is not closed completely.The door gasket does not seal properly.A large amount of warm or hot food might have been stored recently. Wait until the freezer has had a chance to reach its selected temperature. The freezer has recently been disconnected for a period of time. Four hours are required for thefreezer to cool down completely.
Temperature inside the freezer is too cold.| Temperature control is set too cold.   Turn thecontrol to a warmer setting and allow several hours for the temperature to stabilize.
Popping or cracking sound when compressor comes on.| Metal parts undergo expansion and contraction, as in hot water pipes. This is normal. Sound will level off or disappear as freezer continues to run.
Bubbling or gurgling sound, like water boiling.| Refrigerant (used to cool freezer) is circulating throughout the system. This is normal.
Vibrations.| Check to assure that the freezer is level.Floor is uneven or weak. Freezer rocks on the floor when it is moved slightly. Be sure floor can adequately support freezer. Level the freezer by putting wood or metal shims under part of the freezer.The freezer is touching the wall. Re-level the freezer and move it from the wall.See “Installation Instructions”.
Moisture forms on inside freezer walls.| Weather is hot and humid, which increases internal rate of frost build-up. This is normal.
| Door is slightly open.
Door is kept open too long, or is opened too frequently. Open the door less often.
The door is not sealed properly.
---|---
Moisture forms on outside of freezer.| Door is slightly open, causing cold air from inside the freezer to meet warm moist air from outside.
The door will not close properly.| **** The freezer is not level. The gasket is dirty. The storage basket is out of position.

DANGER or WARNING:

DANGER
DANGER-Risk of Fire or Explosion. Flammable Refrigerant Used.Do Not Use Mechanical Devices To Defrost Refrigerator. Do Not Puncture Refrigerant Tubing.

CAUTION
DANGER― Risk of Fire or Explosion.Flammable Refrigerant Used.To Be Repaired Only By Trained Service Personnel.Do Not Use Mechanical Devices.
Do Not Puncture Refrigerant Tubing.”
CAUTION― Risk of Fire or Explosion.Flammable Refrigerant Used.Consult Repair Manual/Owner’s Guide Before Attempting To Service This Product.All safety Precautions Must be Followed.”
CAUTION― Risk of Fire or Explosion.Dispose of Properly In Accordance With Federal Or Local Regulations.Flammable Refrigerant Used.”
CAUTION― Risk of Fire or Explosion Due To Puncture Of Refrigerant Tubing; Follow Handling Instructions Carefully. Flammable Refrigerant Used.

1. Risk of child entrapment. Before you throw away your old refrigerator of freezer:
   • Take off doors.
   • Leave the shelves in place so that children may not easily climb inside.
2. Do not use extension cords.

Gentle Reminder:
When the environment temperature and relative humidity is high,there may be frost or water dew phenomenon on the mouth box and door bar of the freezer,wipe it with dry rag.

Arc Ticking Chest Freezer Warranty

Your product is protected by this warranty:
Warranty service must be obtained from Classic Consumer Services or an authorised Media service.

Warranty

• One year full warranty from original purchase date.

Arctic king, through its authorised services will:

• Pay all costs for repairing or replacing parts of this appliance which prove to be defective in materials or workmanship.

Consumer will be responsible for:

• Diagnostics, removal, transportation and re installation cost required because of service.
• Costs of service calls that are a result of items listed under NORMAL RESPONSIBILITIES OF THE CONSUMER**

Arctic King replacement parts shall be used and will be warranted only for the period remaining on the original warranty.

NORMAL RESPONSIBILITIES OF THE CONSUMER**

This warranty applies only to products in ordinary household use, and the consumer is responsible for the items listed below:

1. Proper use of the appliance in accordance with instructions provided with the product.
2. Routine maintenance and cleaning necessary to keep the good working condition.
3. Proper installation by an authorized service professional in accordance with instructions provided with the appliance and in accordance with all local plumbing, electrical and/or gas codes.
4. Proper connection to a grounded power supply of sufficient voltage, replacement of blown fuses, repair of loosened connections or defects in house wiring
5. Expenses for making the appliance accessible for servicing.
6. Damages to finish after installation.

EXCLUSIONS

This warranty does not cover the following:

1. Failure caused by damage to the unit while in your possession (other than damage caused by defect or malfunction), by its improper installation, or by unreasonable use of the product, including without limitation, failure to provide reasonable and necessary maintenance or to follow the written Installation and Operating Instructions.
2. Products purchased “as is” or refurbished are not covered by this warranty.
3. Food loss caused by refrigerator or freezer failure.
4. Service calls to repair or replace consumables such as water filters, light bulbs air filters etc., or handles, knobs and other cosmetic parts.
5. Product that has been transferred from its original owner.
6. Interior or exterior rust on the unit.
7. Damages caused by services performed by persons other than authorised Media services; use of parts other than Media replacement parts, obtained from persons other than such Media customer service; or external causes such as abuse, misuse, inadequate power supply or acts of God.
8. Service calls resulting from improper installation of your product.
9. Service calls to instruct you on the use of your product.
10. Surcharges including, but not limited to, any after hour, weekend, or holiday service calls, tolls, ferry trip charges, or mileage expense for service calls to remote areas, including the state of Alaska.
11. If the unit is put to commercial, business, rental, or other use or application other than for consumer use, we make no warranties, express or implied, including but not limited to, any implied warranty of merchant ability or fitness for particular use or purpose.
12. Product that has been removed outside the USA or Canada
13. Products without original serial numbers or products that have serial numbers which have been altered or cannot be readily determined.

Note: Some states do not allow the exclusion or limitation of incidental or consequential damages. So this limitation or exclusion may not apply to you.

IF YOU NEED SERVICE

Keep your bill of sale, delivery slip, or some other appropriate payment record. The date on the bill established the warranty period should service be required. If service is performed, it is in your best interest to obtain and keep all receipts. This written warranty gives you specific legal rights. You may also have other rights that vary from state to state Service under this warranty must be obtained by following these steps, in order:

1. Contact Classic Consumer Services or an authorised Arctic king service at 1-866-646 4332.
2. If there is a question as to where to obtain service, contact our consumer relations Department.
   

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>