Hurley Marine H3o & H3o+ Electric Winch Owner’s Manual
- June 3, 2024
- Hurley Marine
Table of Contents
Hurley Marine H3o & H3o+ Electric Winch
IMPORTANT SAFETY INSTRUCTIONS
SAVE THESE INSTRUCTIONS
This manual contains important safety and operating instructions for the
operation of this winch.
WARNING
- Do not exceed load capacity.
- Be aware of dynamic loading!
- Keep 5 full turns of line on reel at all times.
- System must be stowed when not in use.
- Do not maintain power to the winch if the motor stalls.
- Wear approved safety goggles during operation.
- Do not disengage clutch under load. Engage clutch before starting.
- Disconnect the winch from the battery when not in use. Failure to do so will shorten the battery life.
- Stay out of the direct line that the winch strap is pulling. If it slips or breaks, it will “whiplash” along this line.
- Do not use for lifting or moving people. Use as intended only. Do not lift items vertically or use for other purposes. Prevent entanglement. Do not wear loose clothing or jewelry, as they can be caught in moving parts. Non-skid footwear is recommended. Wear restrictive hair covering to contain long hair.
- Inspect before every use; do not use if damaged or loose parts. Examine the winch for structural cracks, bends, damage, frayed or cut strap, and any other conditions that may affect the safe operation of the winch. Do not use the winch even if minor damage appears.
- Keep children and bystanders away while operating. Distractions can cause you to lose control.
- Do not power the Carabiner all the way into the fairlead or winch drum.
- People with pacemakers should consult their physician(s) before use. Electromagnetic fields in close proximity to a heart pacemaker could cause pacemaker interference or pacemaker failure.
Winch
Winch Line. The winch line is a torque-free 12-strand single braid that yields the maximum in strength-toweight ratio and, size for size, is the same strength as steel-yet it floats. It outlasts wire 3:1, making it an excellent winch rope. It has extremely low stretch and superior flex fatigue, wear resistance and is UV stabilized. A proprietary coating enhances the abrasion and cut resistance.
- Ensure winch line is in overwind orientation, so that the winch line enters and exits the winch at the top of the drum.
- The winching line must be properly coiled under tension to be able to support a load without slipping or damage.
Clutch Operation.
The position of the pin in the shaft determines whether the clutch is
engaged or not.
To Change Clutch Positions
- Pull clutch knob out.
- Turn it 90° while it is pulled out, then release it.
Wireless Remote (fob) Control Operation.
Press {up arrow} or {down arrow} to operate winch.
Caution : There may be a delay between the remote button and winch during operation.
Control Box
When power is applied, the control box is activated. A duration timer is started for 5 minutes. If the duration timer elapses then the control box is turned off and the LED goes out. The control box is turned back on by touching the side of the box or by disconnecting and reconnecting the battery cable.
The LED indicates supply voltage as follows:
GREEN: > GOOD YELLOW: FAIR RED: LOW FLASHING RED: <EMPTY
Battery
READ AND UNDERSTAND ALL SAFETY INFORMATION BEFORE USING THIS PRODUCT. Failure
to follow these safety instructions may result in ELECTRICAL SHOCK, EXPLOSION,
FIRE, which may result in a SERIOUS INJURY, DEATH, or PROPERTY DAMAGE. Product
is an electrical device that can shock and cause serious injury. Do not cut
power cords. Do not
submerge in water or get wet.
Important Safety Warnings
Minors. If the product is intended by “Purchaser” to be used by a minor, purchasing adult agrees to provide detailed instructions and warnings to any minor prior to use. Failure to do so is the sole responsibility of the “Purchaser,” who agrees to indemnify Hurley Marine for any unintended use or misuse by a minor.
Handling. Handle product with care. The product can become damaged if impacted. Do not use a damaged battery, including, but not limited to, cracks to the casing or damaged cables. Do not use product with a damaged power cord. Humidity and liquids may damage product. Store and operate product in dry locations. Do not operate product if it becomes wet. If product is already operating and becomes wet, disconnect it from the battery and discontinue use immediately. Do not disconnect the product by pulling on the cables – pull only the connector.
Modifications. Do not attempt to alter, modify or repair any part of the product. Disassembling product may cause injury, death or damage to property. If product becomes damaged, malfunctions or comes in contact with any liquid, discontinue use.
Location. Do not operate the product in a closed-in area or an area with restricted ventilation. Do not operate if the battery becomes excessively warm.
Storage. Discharge battery to a 50% capacity (2 lights on scale) for storage. Store your product on a secure surface so it’s not prone to falling. Store in a dry location, never exceed 176℉ (80℃) under any condition.
The Battery. Do Not Use Other Batteries with this Product! The built-in lithium-ion battery in the product should be replaced only by Hurley Marine and must be recycled or disposed of separately from household waste. Do not handle a damaged or leaking lithium-ion battery. Never dispose of battery in household trash.Always take used batteries to your local battery recycling center. If the product battery is excessively hot, emitting an odor, deformed, cut, or is experiencing or demonstrating an abnormal occurrence, immediately stop all use and contact Hurley Marine.
Charging Battery Pack. Hurley Marine is not responsible for the user’s safety when using accessories or supplies that are not approved by Hurley Marine. Always allow adequate ventilation when charging. Over time, an unused battery will self-discharge and must be recharged before use. The charging indicator will stop blinking when full charged. Disconnect the winch from the battery when not in use.
Medical Devices. Product may emit electromagnetic fields. Product contains magnetic components which may interfere with pacemakers, defibrillators, or other medical devices. Consult with your physician prior to use if you have any medical device including pacemakers. If you suspect the product is interfering with a medical device, stop using the product immediately and consult your physician.
Medical Conditions. If you have any medical condition that you believe could be affected by product, including but not limited to; seizures, blackouts, eyestrain or headaches, consult your physician prior to use of product. The use of the integrated high-powered flashlight contains a light sensitivity hazard. Use of the light in Strobe Mode may cause seizures in persons with photosensitive epilepsy, which may result in serious injury or death.
Light. Staring directly into the light beam or shine of the flashlight may result in permanent eye injury. The product is equipped with a high output LED pre-focused lamp that emits a powerful beam at the highest setting.
Cleaning. Power off the product before attempting any maintenance or cleaning. Clean and dry product immediately if it comes in contact with liquid or any type of contaminant. Use a soft, lint-free (microfiber) cloth. Avoid getting moisture in openings.
Explosive Atmospheres. Obey all signs and instructions. Do not operate product in any area with a potentially explosive atmosphere, including fueling areas or areas which contain chemicals or particles.
High-Consequence Activities. This product is not intended for use where the failure of the product could lead to injury, death or severe environmental damage.
Radio Frequency Interference. Product is designed, tested, and manufactured to comply with regulations governing radio frequency emissions. Such emissions from the product can negatively affect the operation of other electronic equipment, causing them to malfunction.
Additional Features
LED Flashlight
Hold the power button for 3 seconds to turn on the flashlight and then change
the lighting modes in sequence with each press. There are 4 LED light modes
that appear in the following order: Strong lighting mode, strobe mode, SOS
mode, and red/blue mode. Hold the power button for 3 seconds to turn off the
light.
Charging Electronic Devices
Choose a suitable charging cable and insert the cable into the USB port of the
battery pack, then insert the other end of the cable into the input port of
the cell phone/tablet.
Cleaning, Maintenance, and Lubrication
- BEFORE EACH USE, inspect the general condition of the winch and connections. Check for loose hardware, misalignment or binding of moving parts, cracked or broken parts, damaged electrical wiring, corroded or loose terminals, and any other condition that may affect its safe operation.
- Examine the winch line. Do not use the winch if the line is frayed or damaged.
- AFTER USE, wipe external surfaces of the winch with clean cloth. Winch is susceptible to corrosion so proper care is very important to maintain the life of this unit.
- The winch’s internal mechanism is permanently lubricated. Do not open the housing.
- If the winch is submerged replace with a new one.
| Problem | Possible Causes | Likely Solutions |
|---|
Motor does not run, battery status indicator light on control box is off.
|
1. Control box in standby mode.
2. Battery pack damaged or faulty.
3. Control box damaged or faulty.
|
1. Touch outside face of control box or disconnect and reconnect battery pack.
2. Replace battery pack.
3. Contact Hurley Marine.
Motor does not run, battery status indicator light on control box is green.
|
1. Remote fob battery dead.
2. Remote fob damaged or faulty.
3. Motor damaged or faulty.
4. Control box damaged or faulty.
|
1. Replace key fob battery.
2. Contact Hurley Marine.
3. Contact Hurley Marine.
4. Contact Hurley Marine.
Battery Status indicator light on control box stays red or blinking red even after charging for 8 hours.
|
1. Battery pack charger/cable damaged or faulty.
2. Battery pack damaged or faulty.
3. Control box damaged or faulty.
|
1. Replace battery pack charger/cable.
2. Replace battery pack.
3. Contact Hurley Marine.
Motor runs but line drum does not turn.| 1. Clutch not engaged.| 1. Move the clutch knob to the engaged position. If problem persists, contact Hurley Marine.
Motor runs slowly or without normal power while battery status indicator light on control box is green.
|
1. Loose or corroded cable connections.
2. Control box damaged or faulty.
|
1. Clean and tighten where applicable. If problem persists, contact Hurley Marine.
2. Contact Hurley Marine.
Motor runs in one direction only.| 1. Remote fob damaged or faulty.
2. Control box damaged or faulty.
| 1. Contact Hurley Marine.
2. Contact Hurley Marine.
HURLEY ELECTRIC WINCH / BATTERY / ELECTRICAL COMPONENTS / LIMITED 90 DAY
WARRANTY
Hurley Marine makes every effort to assure that this products meet high
quality and durability standards, and warrants to the original purchaser that
this product is free from defects in materials and workmanship for the period
of 90 days from the date of purchase. This warranty does not apply to damage
due directly or indirectly, to corrosion, misuse, abuse, negligence or
accidents, repairs or alterations outside our facilities, criminal activity,
improper installation, normal wear and tear, or to lack of maintenance. We
shall in no event be liable for death, injuries to persons or property, or for
incidental, contingent, special or consequential damages arising from the use
of our product(s). THIS WARRANTY IS EXPRESSLY IN LIEU OF ALL OTHER WARRANTIES,
EXPRESSED OR IMPLIED, INCLUDING THE WARRANTIES OF MERCHANTABILITY AND FITNESS.
Assembly
H3O Winch Assembly
H3O+ (PLUS) Winch Assembly
LIMITED WARRANTY AND LIMITATION OF LIABILITY
All new products manufactured under Hurley Marine, Inc., are warranted to be
free from defects in material and workmanship under normal and proper use for
a period of (2) two years, electric & manual winches, and electrical
components 90 days, from date of shipment from Hurley Marine, Inc. No claim
for breach of warranty will be allowed unless the material or workmanship is
found defective within the warranty period, properly documented by buyer and
Hurley Marine, Inc. is notified in writing within 10 days from failure. This
warranty shall not apply to products that have been disassembled, altered, or
utilized in a manner not approved by Hurley Marine, Inc. or subjected to
normal wear and tear, abuse, misuse, improper maintenance, negligence or
accident. CUSTOMER AGREES THAT USE OF THE PRODUCT/SERVICE IS ENTIRELY AT
CUSTOMER’S OWN RISK. THE FOREGOING WARRANTIES ARE EXCLUSIVE AND ARE ACCEPTED
BY BUYER IN LIEU OF ANY AND ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED,
INCLUDING WITHOUT LIMITATION THE IMPLIED WARRANTIES OF MERCHANTABILITY OR
FITNESS FOR PARTICULAR PURPOSE. Buyer’s sole remedy in the event of a breach
of the forgoing warranties is the repair or replacement of the affected
product by Hurley Marine, Inc., upon the return of the product transportation
charges prepaid to Hurley Marine, Inc., and after a charge to buyer for the
use of the product prior to its return. BUYER AGREES THAT IN NO EVENT WILL
HURLEY MARINE, INC’S LIABILITY FOR ALL LOSSES FROM ANY CAUSE, WHETHER BASED ON
CONTRACT, NEGLIGENCE, STRICT LIABILITY, OTHER TORT OR OTHERWISE, EXCEED
BUYER’S NET PURCHASE PRICE, NOR WILL HURLEY MARINE, INC, BE LIABLE FOR ANY
SPECIAL, INCIDENTAL CONSEQUENTIAL OR EXEMPLARY DAMAGES. Under no circumstances
is Hurley Marine, Inc. responsible for reimbursement of expenses related to
vessel haul-outs, technician or yard personnel, travel expenses, yacht
storage, labor performed during removal and/or replacement of fixture(s), or
shipping costs for replacement parts and/or repairs. These are assumed
liabilities of the customer and part of the terms of sale between Hurley
Marine, Inc. and its customer. The foregoing warranties will continue in
effect for so long as the product is serviced and maintained in accordance
with Hurley Marine, Inc. instructions and with genuine Hurley Marine, Inc.
manufactured replacement parts. These warranties may not be altered or amended
except by a written instrument signed by buyer and a duly authorized officer
of Hurley Marine, Inc. For warranty or service assistance contact your Hurley
Marine, Inc. dealer.
TERMS OF SALE / SHIPPING
RETURN POLICY: If you are dissatisfied with your purchase, contact us within 30 days from the date of product purchase. Products returned within 30 days of their receipt, unopened in their original packaging and otherwise in new condition will automatically be exchanged or refunded. A minimum fee of 25% of the price of the product will be charged for inspection, repacking and restocking for items not returned in their original condition. Other fees may apply depending upon the condition of the item. Products are not returnable after 30 days.
EXCHANGE / REFUND PROCEDURE:
- All returns must have a copy of a paid invoice, contact information and a brief description of the reason accompanied with the return.
- Properly repack the product in the original packaging and place inside a box suitable for shipping with all the original enclosures, parts, and accessories.
- Return it with original receipt and postage pre-paid (we do not accept C.O.D.), add appropriate insurance.
- Shipping and packing fees are non-refundable.
- Non-Returnable items: Inflatable boats, installed/mounted items, damaged goods, clearance/discount items, used and/or display items, electrical goods, light bulbs and special ordered items are not returnable, unless defective, and then for repair/replacement only. If the product is defective you must call Hurley Marine, Inc. within 10 days of receipt of the product.
- DAMAGES GOODS: We thoroughly inspect all items prior to shipment. We suggest that you also thoroughly inspect the item(s) before accepting delivery. If damage is apparent, refuse delivery or if your parcel is left without a signature and damage is found contact the carrier immediately. Do not discard the box or any packaging materials. Most claims must be filed with the carrier within 10 days of receipt of delivery. Although we take special care to ensure the safe arrival of your merchandise, our responsibility for damage ends when the carrier accepts shipment.
NEED HELP
- Hurley Marine, Inc.
- 2717 N Lincoln Road
- Escanaba, MI 49829 USA
- 906. 553.6249
- info@hurleymarine.com
- hurleymarine.com
FCC Rules.
This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.
NOTE : This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference when the equipment is operated in a commercial environment. This equipment generates, uses, and can radiate radio frequency energy and, if not installed and used in accordance with the instruction manual, may cause harmful interference to radio communications. Operation of this equipment in a residential area is likely to cause harmful interference in which case the user will be required to correct the interference at his own expense
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>