BOSCH PCP6A5B90V Gas Hob Instruction Manual

Gas Hob
PCP6A5B90V PCQ7A5B90V, PCQ7A5M90V,
PCS7A5M90V, PCR9A5M90V
Instruction Manual

Register your new device on MyBosch now and get free benefits:
bosch-home.com/welcome

PCP6A5B90V Gas Hob

1. Pan supports
2. Control knobs
3. Economy burner with an output of up to 1 kW
4. Standard-output burner with an output of up to 1.75 kW| 5. High-output burner with an output of up to 3 kW
6. Wok burner with an output of up to 4 kW
7. Dual-wok burner with an output of up to 5 kW
8. Main Switch
---|---

Additional information on products, accessories, replacement parts and services can be found at www.bosch-home.com and in the online shop www.bosch-eshop.com

Intended use

Read these instructions carefully. You will only be able to use your appliance safely and effectively when you have read them. These operating and installation instructions should
be retained, and passed onto the buyer if the appliance is sold.

The manufacturer is exempt from all responsibility if the requirements of this manual are not complied with.
The images shown in these instructions are for guidance only. Do not remove the appliance from its protective packaging until it is installed in the unit. Do not switch on the appliance if it is damaged in any way. Contact our Technical Assistance Service. This appliance is class 3 type, according to the EN 30-1-1 regulation for gas appliances: built-in appliance. Before installing your new hob, ensure that it is being installed according to the installation instructions. This appliance cannot be installed on yachts or in caravans. This appliance must only be used in well-ventilated places. This appliance is not intended for operation with an external clock timer or remote control. All operations relating to installation, connection, regulation, and conversion to other gas types must be performed by an authorized technician, respecting all applicable regulations, standards, and specifications of the local gas and electricity suppliers. Special attention shall be paid to ventilation regulations.

This appliance leaves the factory set to the gas type that is indicated on the specifications plate. If this needs to be changed, please consult the assembly instructions. It is recommended you contact the Technical Assistance Service to change to another gas type.
This appliance has been designed for home use only, not for commercial or professional use. This appliance is only intended for cooking purposes, not as a heating system. The warranty will only be valid if the appliance is used for the purpose for which it was designed.
This appliance is intended for use up to a maximum height of 2000 meters above sea level.
Do not use lids or hob guards for children which are not recommended by the hob manufacturer. They may cause accidents such as those due to the overheating, ignition or detachment of fragments of materials. This appliance may be used by children over the age of 8 years old and by persons with reduced physical, sensory or mental capabilities or by persons with a lack of experience or knowledge if they are supervised or instructed by a person responsible for their safety how to use the appliance safely and have understood the associated hazards. Children must not play with, on, or around the appliance. Children must not clean the appliance or carry out general maintenance unless they are at least 15 years old and are being supervised.
Keep children below the age of 8 years old at a safe distance from the appliance and power cable.

Important safety information

Warning – Risk of deflagration!
Accumulation of unburned gas in an enclosed area carries a risk of deflagration. Do not subject the appliance to draughts. These might blow out the burners. Carefully read the
instructions and warnings on the operation of gas burners.

Warning – Risk of poisoning!
The kitchen will become hot and humid and combustion products produced when this gas appliance is used. Make sure the kitchen is well-ventilated, particularly when the hob is in operation: either keep the natural ventilation apertures open or install a ventilation system (extractor hood). Intense prolonged use of the appliance may require additional or more effective ventilation: open a window or increase the power of the ventilation system.

Warning – Risk of burns!

• The burners and their immediate vicinity get very hot. Never touch hot surfaces. Keep children under 8 years old well away from this appliance.
• If the liquefied gas bottle is not upright, liquefied propane/butane can enter the appliance. Intense darting flames may therefore escape from the burners. Components may become damaged and start to leak over time so that gas escapes uncontrollably. Both can cause burns. Always use liquefied gas bottles in an upright position.

Warning – Risk of fire!

• The cooking process must be supervised. A short cooking process must be supervised without interruption.
• The burners get very hot. Do not rest inflammable objects on the hob. Do not store objects on the hob.
• Do not store or use corrosive chemicals, products that produce fumes, inflammable materials, or non-food products below or near this domestic appliance.
• Fat or oil that is overheated can catch fire easily. Never leave fat or oil to heat up unattended. If oil or fats do catch fire, never use water to put the fire out. Put the fire out by covering the pan with a lid and switching off the hotplate.

Warning – Risk of injuries!

• Pans that are damaged, are not the right size, hang over the edge of the hob or are not positioned correctly can cause serious injuries. Follow the advice and warnings provided relating to the cooking pans.
• Incorrect repairs are dangerous. Repairs may only be carried out, and damaged power and gas lines replaced, by an aftersales engineer trained by us. If the appliance is faulty, unplug the mains plug or switch off the fuse in the fuse box. Shut off the gas supply. Contact the after-sales service.
• If a control knob is too stiff to turn or it is loose, it must not be used. Contact our after-sales service immediately to have the control knob repaired or replaced.

Warning – Risk of electric shock!
Do not clean the appliance using steam cleaners.

General information

Technical information

| | Economy burner  | Standard-output       burner| High-output burner| Wok burner| Dual wok burner
---|---|---|---|---|---|---
Thermal capacity| NATURAL GAS| 1,00 kW| 1,75 kW| 3,00 kW| 4,00 kW| 5,00 kW
LP GAS| 4,60 kW
Model PCP6A5B90V| | 1| 2| 1| –| –
Model PCQ7A5B90V| | 1| 2| 1| 1| –
Model PCQ7A5M90V| | 1| 2| 1| 1| –
Model PCS7A5M90V| | 1| 2| 1| –| 1
Model PCR9A5M90V| | 1| 2| 1| –| 1
Regulation options| NATURAL GAS G20/17,6 – 19,6 mbar; 1,76 – 1,96 kPa
LP GAS G30/27,5 mbar; 2,75 kPa
Electrical characteristics| 110 – 240 V∼ 50/60 Hz

NOTE: This product functions using LP gas. If you wish to operate the product using natural gas, call our service center.

IMPORTANT

• Place the pan supports and burners as shown in the diagrams that describe the model.
• Maintain the area surrounding the appliance free of flammable materials, gasoline, and other flammable vapors or liquids.
• Do not use as a space heater as this may be dangerous.

FOR YOUR SAFETY IF YOU SMELL GAS:

• OPEN THE WINDOWS
• DO NOT TOUCH POWER SWITCHES
• TURN OFF ALL FLAMES BY CLOSING THE MAIN VALVE
• CALL THE GAS LEAK HOTLINE OR YOUR GAS PROVIDER

FOR YOUR SAFETY

• DO NOT STORE GASOLINE OR OTHER FLAMMABLE LIQUIDS NEAR THE APPLIANCE
• INSTALL YOUR PRODUCT IN ACCORDANCE WITH THE INSTALLATION GUIDE TO AVOID HEAT DAMAGE TO YOUR CABINETS

Getting to know your appliance

You can find your appliance and the burner powers in the model overview. → Page 2

Controls and burners
Each control knob is marked with the burner it controls. You can use the control knobs to set the output required in each case to various positions between the maximum and the minimum settings. Never try to switch directly from position 0 to position 1 or from position 1 to position 0.

Indicators

| Burner controlled by control knob

Ο

| Switched-off burner
| Highest power setting and electric ignition
| Lowest power setting

For dual double-flame burners, the inner and outer flames can be controlled separately. The available power levels are as follows:

Inner and outer flame on full power.

Outer flame on low power, inner flame on full power.
Inner flame on full power.

Inner flame on low power.

It is essential to ensure that all the burner parts and pan supports are correctly installed for the appliance to work correctly. Do not swap the burner caps around.
Always remove the pan supports carefully. When moving pan support, the pan supports next to it may also move.

Burner parts

1| Ignition plug
2| Thermocouple
3| Burner cup
4| Burner cap

Accessories
Depending on the model, the hob may include the following accessories. These can also be acquired from the Technical Assistance Service.

Additional wok grid
Only suitable for use on wok burners. Use cookware with a rounded base.
To extend the service life of the appliance, we recommend using the additional wok grid.

Additional espresso maker grid
Only suitable for use on the smallest burner. Use cookware with a diameter of less than 12 cm.

Simmer plate
This accessory part is only suitable for simmering. It can be used with the economy burner or the standard-output burner. If your hob has several standard output burners, we recommend placing the simmer plate on the rear or front- right standard-output burner.
Place the accessory component with the projections facing upwards on the holder; never place it directly on the burner.

Simmer cap
Only use the cap for cooking with minimal power. Place the simmer cap on the cover of the economy burner. Always place cookware on the pan support, never directly on the simmer cap.

Code
HEZ298107 Additional wok grid: Cast iron (4-5 kW)
HEZ298110 Additional wok grid: Enamelled steel
HEZ298115 Additional espresso maker grid
HEZ298105 Simmer Plate
HEZ211310 Simmer cap
The manufacturer accepts no liability if these accessories are not used or are used incorrectly.

Gas burners

Switching on manually

1. Press the control knob for the selected burner and turn it anticlockwise to the highest power setting.
2. Hold an igniter or a naked flame (such as a lighter or a match) against the burner.

Automatic ignition
If the hob has automatic ignition (ignition plugs):

1. Press the control knob for the selected burner and turn it anticlockwise to the highest power level.
   While the control knob is held down, all the burners will generate sparks. The flame ignites. Wait a few seconds.

2. Release the control knob.

3. Turn the control knob to the required position.

If the burner does not ignite, switch it off and repeat the steps described above. This time, hold the control knob down for longer (up to 10 seconds).

Warning – Risk of deflagration!
If the flame does not ignite after 15 seconds, switch off the burner and open a window or the door to the room. Wait at least one minute before switching the burner on again.

Note: It is important to keep the appliance clean. If the ignition plugs are dirty, this may cause ignition problems. Clean the ignition plugs regularly with a small, non-metallic brush. Take care to prevent the ignition plugs from suffering any heavy knocks.

Safety system
Your hob is equipped with a safety system (thermocouple) that cuts off the gas when the burners are accidentally switched off.
To ensure that this device is active:

1. Switch on the burner as usual.
2. Without releasing the control knob, press and hold it down firmly for 4 seconds after lighting the flame.

Switching off a burner
Turn the corresponding control knob clockwise to the 0 settings.
A few seconds after the burner is switched off, a sound (thud) will be produced. This is not a fault – this means that the safety device is no longer operating.

Main switch/Hob lock (Main Switch)
The hob may have the main switch to cut off the mains gas supply and switch off all the burners at the same time. This switch is very practical if there are children in the house or if for any reason, all the burners must be switched off quickly.

To lock the hob:
Press the main switch.
This switches off all the burners which are on. The hob is locked.

To unlock the hob:

1. Turn all the control knobs to the “off” position.
2. Press the main switch and turn it fully clockwise.

The mains gas supply is turned on. You can now use your hob normally.

Warnings
It is normal to hear a soft whistling noise while the burner is operating.
When first used, it is normal for the burner to give off odors. This does not pose any risk and does not indicate a malfunction. They will disappear in time.
An orange-colored flame is normal. This is caused by the presence of dust in the atmosphere, spilled liquids, etc.
If the burner flames are accidentally blown out, switch off the burner operating control knob and do not try to relight it for at least 1 minute.

Settings table and tips

Suitable pans

Burner| Minimum diameter of the
cookware base| Maximum diameter of the cookware
base
---|---|---
Wok burner| 22 cm| 30 cm
High-output burner| 20 cm| 26 cm
Standard-output burner| 14 cm| 22 cm
Economy burner| 12 cm| 16 cm

The cookware must not overhang the edge of the hob.

Instructions for use
Note: When using certain pots or pans, a slight and temporary deformation of the steel cooking surface may occur. This is normal and does not affect the functionality of the appliance.
The following recommendations can help you save energy and avoid damaging your cookware:

Use pans that are the right size for each burner. Do not use small pans on large burners. The flame must not touch the sides of the pan.
Do not use damaged pans, which do not sit evenly on the hob. Pans may tip over. Only use pans with a thick, flat base.

Do not cook without using a lid and make sure the lid is properly fitted. This wastes energy.

Always center the pan over the burner, not to one side. Otherwise, it could tip over. Do not place large pans on the burners near the control knobs. These may be damaged by the very high temperatures. Place the pans on the pan supports, never directly on the burner. Make sure that the pan supports and burner caps are correctly positioned before using the appliance. Pans should be placed on the hob carefully. Do not strike the hob and do not place excessive weight on it.

Table of cooking times
The table below lists the optimal heat settings and cooking times for various types of food. The information given applies when cooking four portions.
The cooking times and heat settings may vary depending on the type of food, its weight, and quality, the type of gas used, and the material from which the cookware is made. To prepare this dish, stainless steel cookware was mainly used.
Always use cookware that is the right size and place it in the center of the burner. You can find information about the diameter of the cookware under → “Suitable pans”

Information on the table
Each type of food can be prepared in one or two steps.
Each step contains information about the following:
Cooking method
Heat setting
Cooking time in minutes

Soups, creamy soups

Cream of pumpkin, borscht

Minestrone (vegetable soup)

Pasta and rice
Spaghetti

Rice

High-output burner
Standard-out- put the burner| 17-22
18-23| | 9
9| 5-7
7-9| | 2
6| 12-15
11-14
---|---|---|---|---|---|---|---
Wok burner| 15-20| | 8| 4-6| | 2| 11-14

Ravioli

Vegetables and pulses
Boiled potatoes (mashed, potato salad)

| Standard-out- put burner| 25-30| | 9| 10-12| | 6| 15-18
| Wok burner| 25-30| | 7| 11-13| | 5| 14-17

Hummus (puréed chickpeas)

Lentils

Deep-fried vegetables

Sautéed fresh vegetables**

Wok burner| 6-8| | 9| 6-8| | |
---|---|---|---|---|---|---|---
High-output burner| 6-8| | 9| 6-8| | |

Chips

Wok burner| 15-20| | 7| 15-20| | |
---|---|---|---|---|---|---|---
High-output burner| 15-20| | 9| 15-20| | |
Standard-out- put burner| 25-30| | 9| 25-30| | |

Eggs
Shakshuka

Omelette (1 port.)

Standard-out- put burner| 3-5| | 8| 3-5| | |
---|---|---|---|---|---|---|---
High-output burner| 2-4| | 9| 2-4| | |
Wok burner| 2-4| | 5| 2-4| | |

Spanish tortilla

High-output burner| 25-30| | 9| 25-30| | |
---|---|---|---|---|---|---|---
Wok burner| 18-23| | 9| 18-23| | |

Dual wok burner| 25-30| | 7| 25-30| | |

Sauces
Béchamel sauce**

Blue cheese sauce**

Economy burner| 4-6| | 7| 4-6| | |
---|---|---|---|---|---|---|---
Standard-out- put the burner| 3-5| | 7| 3-5| | |
High-output burner| 3-5| | 5| 3-5| | |

Neapolitan sauce

Carbonara sauce

Fish
Roman-style hake

High-output burner| 5-10| | 8| 5-10| | |
---|---|---|---|---|---|---|---
Standard-out- put burner| 8-13| | 9| 8-13| | |
Wok burner| 4-9| | 6| 4-9| | |

Baked salmon

Mussels

High-output burner| 5-7| | 9| 5-7| | |
---|---|---|---|---|---|---|---
Wok burner| 4-6| | 9| 4-6| | |
Standard-out- put the burner| 10-12| | 9| 10-12| | |

Meat
Duck breast (x 1)

Standard-out- put the burner| 6-8| | 7| 6-8| | |
---|---|---|---|---|---|---|---
High-output burner| 9-11| | 7| 9-11| | |
Wok burner| 6-8| | 5| 6-8| | |

Beef tenderloin stroganoff

High-output burner| 8-13| | 9| 8-13| | |
---|---|---|---|---|---|---|---
Wok burner| 5-10| | 8| 5-10| | |
Standard-out- put the burner| 12-17| | 9| 12-17| | |

Chicken schnitzels (8 chicken breast fillets)

Minced meat (meat pies, pasties, and other pastry-covered meat, meatballs, bolognese sauce)

High-output burner| 15-20| | 8| 15-20| | |
---|---|---|---|---|---|---|---
Standard-out- put burner| 20-25| | 9| 20-25| | |
Wok burner| 15-20| | 6| 15-20| | |

Convenience products
Frozen croquettes (x 16)
Frozen fish fingers (x 12)

High-output burner| 6-10| | 8| 6-10| | |
---|---|---|---|---|---|---|---
Wok burner| 5-9| | 8| 5-9| | |
Standard-out- put burner| 8-12| | 8| 8-12| | |

Fried sausages (x 12)

Boiled sausages (x 12)

Standard-out- put the burner| 8-13| | 9| 8-13| | |
---|---|---|---|---|---|---|---
Wok burner| 9-14| | 4| 9-14| | |
High-output burner| 7-12| | 7| 7-12| | |

Hamburgers (x 4)

Standard-output
burner| 5-10| | 9| 1-3| | 8| 4-7
---|---|---|---|---|---|---|---

Frozen vegetables**

High-output burner| 7-12| | 9| 7-12| | |
---|---|---|---|---|---|---|---
Wok burner| 5-10| | 9| 5-10| | |
Standard-out- put the burner| 12-17| | 9| 12-17| | |

Pizza (8 inch)

Wok burner| 4-8| | 1| 4-8| | |
---|---|---|---|---|---|---|---
High-output burner| 16-20| | 1| 16-20| | |
Standard-out- put the burner| 20-25| | 1| 20-25| | |

Desserts
Rice pudding**

Milk chocolate

Economy burner| 10-14| | 1| 10-14| | |
---|---|---|---|---|---|---|---
Standard-out- put the burner| 16-20| | 1| 16-20| | |

Crêpes (x 4)

Bread pudding

Spanish pudding**

High-output burner| 3-8| | 5| 3-8| | |
---|---|---|---|---|---|---|---
Standard-out- put the burner| 8-13| | 5| 8-13| | |
Wok burner| 3-8| | 2| 3-8| | |

Sponge cake (in bain Marie)

High-output burner| 35-40| | 9| 35-40| | |
---|---|---|---|---|---|---|---
Wok burner| 40-45| | 9| 40-45| | |
Standard-out- put the burner| 45-50| | 9| 45-50| | |

Cooking tips

• Use a pressure cooker to cook creamy soups and pulses. This significantly reduces the cooking time. If you are using a pressure cooker, follow the manufacturer’s instructions. Add all of the ingredients at the start.
• Always use a lid when cooking potatoes and rice. This significantly reduces the cooking time. The water must be boiling before you add pasta, rice or potatoes. Then adjust the heat setting to continue boiling.
• For pan-cooked dishes, heat the oil up first. As soon as you have started the frying, keep the pan at a constant temperature by adjusting the heating setting as required. When preparing several portions, wait until the relevant temperature has been reached again. Turn the food regularly.
• When cooking soups, cream, lentils or chickpeas, add all of the ingredients to the cookware at the same time.

Cleaning and maintenance

Cleaning
Once the appliance is cool, use a sponge to clean it with soap and water.
After each use, clean the surface of the respective burner parts once they have cooled down. If any residue is left (baked-on food, drops of grease, etc.), however little, it will become stuck to the surface and more difficult to remove later. The holes and grooves must be clean for the flame to ignite properly. The movement of some pans may leave metal residue on the pan supports.
Clean the burners and pan supports using soapy water and scrub with a non-wire brush.
If the pan supports are fitted with rubber rests, ensure that these are also cleaned. The rests may come loose and the pan support may scratch the hob. Always dry the burners and pan supports completely. Water droplets or damp patches on the hob at the start of cooking may damage the enamel. After cleaning and drying the burners, make sure the
burner caps are correctly positioned on the diffuser.

Caution!

• Do not remove the control knobs when cleaning the appliance. The appliance may be damaged if moisture finds its way inside.
• Do not use steam cleaners. This could damage the hob.
• If your hob is fitted with a glass or aluminum panel, never use a knife, scraper, or similar implement to clean the point where it joins the metal.

Maintenance
Always clean off any liquid as soon as it is spilled. This will prevent food remains from sticking to the hob surface and you will save yourself any unnecessary effort. Due to the high temperatures endured, the wok burner and the stainless steel zones (grease drip tray, burner outline, etc.) can change color. This is normal. After each use, clean these areas with a product that is suitable for stainless steel.
It is recommended that the cleaning product available from our Technical Assistance Service (code 311499) is used regularly.

Caution!
The stainless steel cleaner must not be used in the area around the controls. The (printed) symbols may be wiped off.
Do not leave acidic liquids (e.g. lemon juice, vinegar, etc.) on the hob.

Troubleshooting

Sometimes certain faults detected can be easily resolved. Before calling the Technical Assistance Service, bear in mind the following advice:

fuse in the main fuse box and change it if it is damaged.
The automatic safety switch or circuit breaker has tripped.| Check the main control panel to see if the automatic safety switch or circuit breaker has tripped.
The automatic switching-on function does not work.| There may be food or cleaning products stuck between the ignition sparkers and the burners.| The space between the ignition sparker and the burner must be clean.
The burners are wet.| Dry the burner caps carefully.
The burner caps are not correctly positioned.| Check that the burner caps are correctly positioned.
The appliance is not earthed, is poorly connected or the earthing is faulty.| Contact the installation technician.
The burner flame is not uniform.| The burner components are not correctly positioned.| Correctly place the parts on the appropriate burner.
The grooves on the burner are dirty.| Clean the grooves on the burner.
The gas flow is not normal or there is no gas.| The gas supply is blocked by gas taps.| Open all gas taps.
If the gas is supplied from a gas cylinder, check that it is not empty.| Change the gas cylinder.
The kitchen smells of gas.| A gas tap has been left on.| Turn off the taps.
Incorrect coupling of gas cylinder.| Check that the coupling is sound.
Possible gas leak.| Shut off the gas supply, ventilate the premises, and immediately notify an authorized installation technician to check and certify the installation. Do not use the appliance until ensure that there is no gas leak in the installation or appliance itself.
The burner immediately switches off after releasing the control knob.| The control knob was not held down for long enough.| Once the burner is on, hold the control knob down a few seconds longer.
The grooves on the burner are dirty.| Clean the grooves on the burner.

Customer service

When contacting our customer service, please provide the product number (E-Nr.) and production number (FD) of the appliance. This information is given on the specifications plate located on the lower section of the hob and on the label in the user manual.
After-sales contact details for all countries can be found in the attached after-sales service directory.

Warranty conditions
In the unlikely event that the appliance is damaged or does not meet your expectations in terms of quality, please inform us as soon as possible. For the warranty to be valid, the appliance must not have been tampered with or used inappropriately. The applicable warranty conditions are those set out by the company’s representative office in the country of purchase. Detailed information is available from retail outlets. Proof of purchase must be presented to obtain the benefits of the warranty. We reserve the right to introduce changes.

Environmental protection

If the symbol is shown on the specifications plate, bear in mind the following instructions:

Environmentally-friendly disposal
Dispose of packaging in an environmentally-friendly manner.
This appliance is labeled in accordance with European Directive 2012/19/EU concerning used electrical and electronic appliances (waste electrical and electronic equipment – WEEK). The guideline determines the framework for the return and recycling of used appliances as applicable throughout the EU.

The packaging of your appliance has been manufactured using only the materials which are strictly necessary to guarantee efficient protection during transport. These materials are 100% recyclable, thus reducing the environmental impact. You can also contribute to caring for the environment by following the advice below:

• Dispose of the packaging in the appropriate recycling bin.
• Before you get rid of an old appliance, make sure you disable it. Contact your local authority to find out the address of your nearest recycling center to dispose of your appliance.
• Do not pour used oil down the sink. Collect it in a sealed container and take it to an appropriate collection point or, failing that, place it in the rubbish bin (it will end up in a controlled dump; this is probably not the best option, but it will avoid contaminating groundwater).

Thank you for buying a Bosch Home Appliance!
Register your new device on MyBosch now and profit directly from:

• Expert tips & tricks for your appliance
• Warranty extension options
• Discounts for accessories & spare parts
• Digital manual and all appliance data at hand
• Easy access to Bosch Home Appliances Service
  Free and easy registration – also on mobile phones: www.bosch- home.com/welcome

Looking for help? You’ll find it here.
Expert advice for your Bosch home appliances need help with problems or a repair from Bosch experts. Find out everything about the many ways Bosch can support you: www.bosch-home.com/service Contact data of all countries are listed in the attached service directory.

BSH Hausgerate GmbH
Carl-Wery-StraBe 34
81739 MOnchen, GERMANY
www.bosch-home.com
A Bosch Company

References

• Home Appliances Global Website | Bosch
• Home Appliances Global Website | Bosch

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>