SPORTSMAN GEN4000 500-Watt Portable Gas Generator User Guide
- June 4, 2024
- SPORTSMAN
Table of Contents
GEN4000 500-Watt Portable Gas Generator
Step-By-Step Quick Start
Guide To Using Your Generator
- Remove Generator From Package
- Add Oil
- Add Fuel
- Start The Generator
Oil Type: SAE10W-30 Oil (Must add BEFORE first use)
Oil Capacity: 18.5 fluid oz
Because this generator includes Low Oil Shut Off, the
generator will not start with low oil. Start out with 18.5 oz,
then FILL UNTIL ALMOST OVERFLOWING.)
Unleaded gasoline only octane rating of 87 or higher
Maximum Capacity: 3.6 Gallon fuel tank
- Use the generator OUTDOORS in a WELL VENTILATED AREA.
- DO NOT CONNECT electrical devices until AFTER the generator is started.
- Turn Engine Switch to ON
- Turn FUEL PETCOCK to ON (Figure A)
- Adjust the CHOKE to CLOSED/CHOKE position (Figure B)
- Start the generator manually with the Recoil (Pull) Start.
- Once the engine has started, GRADUALLY move the choke lever to the “RUN/OPEN” position until the engine levels off. Then let the engine run approximately 5 minutes BEFORE adding appliances or tools.
- You can now connect electrical devices.
GEN4000
4,000 Surge / 3,500 Running Watts
UNLEADED GASOLINE FUEL
GENERATOR SPECIFICATIONS:
• 7.0 HP Engine, 4 Stroke OHV
• Recoil Start
• 3.6 Gallon Fuel Tank
• Low Oil Shut Off
• AVR Automatic Voltage Regulation
• UL Listed Electrical Components
• Engine Shut Off Switch
• Circuit Breaker & Power Outlets
• 1 – 12V D/C Outlet
• 4 – 120V A/C Outlets
• 1 – 120V RV Outlet
• Complies with EPA emissions
• Run time = 10 hours @ 50% load
• Decibel Rating < 69 db @ 0% load
• Warranty: 2 YEAR Limited Emissions
• Warranty: 1 YEAR Limited
• DO NOT use E85, gas/oil mix, or modify the
engine to run on alternate fuels.
• If you are using a generator 3,000 ft. above
sea level, the generator may not function
properly because of air flow getting through the
carburetor.
• High Altitude Use: This generator is not
recommended for high altitude use 3,000 ft.
above sea level.
OIL IS NOT INCLUDED WITH THIS
GENERATOR. IT IS SOLD SEPARATELY.
Read and understand instruction manual before using generator.
GEN4000
4,000 Surge / 3,500 Running Watts
UNLEADED GASOLINE FUEL
DO NOT CONNECT electrical devices until AFTER the generator is started.
WARNING
IF THERE IS ANY QUESTION ABOUT A
CONDITION BEING SAFE OR UNSAFE,
DO NOT OPERATE THIS PRODUCT!
Always follow Warning labels placed on the
generator, and read and follow all Warning
labels included inside the Product Manual.
WARNING: NEVER use a generator inside
a home or a garage, EVEN IF the doors
and windows are open.
ONLY USE OUTSIDE and far away from
windows, doors and vents leading into an
enclosed area.
Using a generator indoors can kill you in
minutes. The generator produces an
exhaust that contains carbon monoxide.
This is a poison you cannot see or smell.
Do not attach a chain or rope to secure the
generator to a post as this can be difficult to
remove in the event of an emergency.
ATTENTION
WARNING
ALERT!
This generator includes
a built-in Carbon Monoxide
Warning Alert! The generator
will automatically shut-off if
dangerous levels of Carbon
Monoxide is detected.
WARNING Carbon monoxide (also known as CO) can be dangerous for humans and pets. Carbon monoxide poisoning can lead to death in a very short time. It is called “the silent killer” because it is odorless, tasteless and invisible: you may be exposed without knowing it.
NOTE: The indicator will light RED and the engine will shutdown if dangerous Carbon Monoxide levels are detected. The engine will not restart for 5 minutes. If an error in the carbon monoxide system is detected, the indicator will blink YELLOW and the engine will shutdown for five minutes.
MOVE TO FRESH AIR AND GET MEDICAL HELP IF SICK, DIZZY OR WEAK. MOVE GENERATOR TO AN OPEN, OUTDOOR AREA. POINT EXHAUST AWAY. DON’T RUN GENERATOR IN ENCLOSED AREA (E.G. NOT IN HOUSE OR GARAGE).
TOLL-FREE NATIONWIDE HELP LINE!
866-460-9436
Need Help? Call Customer Service!
Monday-Friday 8:00 AM – 4:00 PM Central Time