GENERAC MOBILE CTF-10 Tower Light Instruction Manual
- June 15, 2024
- GENERAC MOBILE
Table of Contents
CTF-10
Light Tower Parts Manual
CTF-10 Tower Light
03007
MODEL NUMBER:
SERIAL NUMBER:
DATE PURCHASED:____
SAVE THIS MANUAL FOR FUTURE REFERENCE
WARNING
CANCER AND REPRODUCTIVE HARM
www.P65Warnings.ca.gov.(000393a)
WARNING
Breathing diesel engine exhaust exposes you to chemicals known to the State of
California to cause cancer and birth defects or other (000394) reproductive
harm.
- Always start and operate the engine in a well-ventilated area.
- If in an enclosed area, vent the exhaust to the outside.
- Do not modify or tamper with the exhaust system.
- Do not idle the engine except as necessary.
For more information go to www.P65Warnings.ca.gov/diesel.
Introduction
This parts manual was prepared based on the information available at the time
of publication and is subject to change without notice. Generac Mobile
Products reserves the right to change parts at any time. To check whether a
revised parts manual is available, contact Generac Mobile Products.
DO NOT MODIFY or use this equipment for any application other than which it
was designed for. To keep your equipment fully operational, it is suggested
you maintain a stock of commonly used maintenance or service parts.
A recommended spare parts list can be found in the back of this manual. To
order service parts, please go to
www.generacmobileproducts.com or call
Generac Mobile Products.
WARNING
Consult Manual. Read and understand manual completely before using product.
Failure to completely understand manual and product could result in death or
serious injury. (000100a)
WARNING
Environmental Hazard. Always recycle batteries at an official recycling center
in accordance with all local laws and regulations. Failure to do so could
result in environmental damage, death, or serious injury. (000228)
GENERAC MOBILE PRODUCTS LLC
215 Power Drive • Berlin, WI 54923 U.S.A.
Phone: 920-361-4442
FAX: 920-361-4416
Toll Free: 1-800-926-9768
www.generacmobileproducts.com
For technical or parts QUESTIONS, contact Generac Mobile Products Technical
Service at 1-800-926-9768.
Engine Make:__
Engine Serial Number:___
Engine Model Number: __
Parts Manual Instructions
Product illustrations are only representations. Products supplied may vary
from the illustrations in this parts manual.
Parts not shown in the illustration are indicated by a double dash (–) in the
item column.
Please be prepared to provide the following information when ordering
replacement parts: model number, serial number (on unit serial tag), part
number, purchase order number (if applicable), shipping address, shipping
method. Refer to the illustration below to locate the unit ID tag on the unit.
Important information, such as the unit serial number, model number, and tire
loading information are found on these tags. Record the information from these
tags so it is available if the tags are lost or damaged. When ordering parts
or requesting assistance, you may be asked to provide this information.
UNIT DECALS
| Item | Part No. | Qty | Description | Notes |
|---|---|---|---|---|
| 1 | – | 8 | Decal, Forklift pockets | Special order |
| 2 | – | 1 | Decal, Help tech | Special order |
| 3 | – | 4 | Decal, United Rental Llogo | Special order |
| 4 | – | 4 | Decal, Read the manual | Special order |
| 5 | – | 1 | Decal, made in Italy | Special order |
| 6 | – | 2 | Decal, Lifting point | Special order |
| 7 | – | 2 | Decal, Warning, pinch points | Special order |
| 8 | – | 1 | Decal, Bar code – UR | Special order |
| 9 | – | 1 | Decal, Renters responsibilities | Special order |
| 10 | – | 4 | Decal, Generac Mobile logo | Special order |
| 11 | – | 4 | Decal, Warning – Extracted stabilizers | Special order |
| 12 | – | 4 | Decal, UnitedRentals.com | Special order |
| 13 | – | 1 | Decal, Security pin | Special order |
| 14 | – | 4 | Decal, 800-UR-RENTS | Special order |
| 15 | – | 4 | Decal, Outrigger warning | Special order |
| 16 | – | 4 | Decal, Maximum wind stability | Special order |
| 17 | – | 1 | Decal, Mast rotation stopping point | Special order |
| 18 | – | 4 | Decal, No step | Special order |
| 19 | – | 4 | Decal, Tie down point | Special order |
| 20 | – | 1 | Unit ID tag | Special order |
Note : (1) Always specify the serial number of machine, logic must be set according to the configuration of the machine.
STANDARD COMMAND PANEL
| Item | Part No. | Qty | Description | Notes |
|---|---|---|---|---|
| 1 | A0000215338 | 1 | Fuse, 2A 250V 6.3X32 | |
| 2 | – | 1 | Holder, fuse 6.3 x 32 | Special order |
| 3 | – | 1 | Box support, left command – black | Special order |
| 4 | A0000507192 | 1 | Breaker, main 15A/20A | |
| 5 | 75016 | 4 | Switch, lights 5A rated breaker | |
| 6 | – | 1 | Connection, terminal board | Special order |
| 7 | 56507 | 1 | Terminal board, 2 connector | – |
| 8 | – | 1 | End plate, intermediate | Special order |
| 9 | – | 1 | Terminal board, stop | Special order |
| 10 | – | 1 | Support | Special order |
| 11 | – | |||
| 12 | – | 1 | Box, command – black | Special order |
| 13 | – | 1 | Clamp, 15/15 RSGU1 | Special order |
| 14 | – | 1 | Side closure, box | Special order |
| 15 | A0000507198 | 1 | Terminal board,10P female | |
| 16 | – | 1 | Box support, right command – black | Special order |
| 17 | – | 1 | Support, socket plug | Special order |
| 18 | – | 1 | Cover, weather receptacle | Special order |
| 19 | 14130 | 1 | Receptacle, 120V/20A GFI | |
| 20 | A0000507199 | 1 | Receptacle 120V/20A inlet | |
| 21 | 75014 | 1 | Receptacle, 120V/20A inlet w/cover | |
| 22 | A0000216436 | 1 | Capacitor, 4.7UF 100V | |
| 23 | – | 1 | Support | Special order |
| 24 | A0000507200 | 1 | Relay, light dependent w/sensor | |
| 25 | A0000507201 | 1 | Contactor, 25A 2NO 120V AC/DC | |
| 26 | A0000507202 | 1 | Timer, 240V | |
| 27 | – | 1 | Support, light sensor and timer | Special order |
| 28 | – | 1 | Plate, front – aluminum | Special order |
| 29 | – | 1 | Terminal, main ground | Special order |
| 30 | A0000507203 | 1 | Protection, Wimex 4P | |
| 31 | A0000507204 | 1 | Switch, rocker ON/ON | |
| 32 | A0000507206 | 1 | Switch, selector |
Note: (1) Always specify the serial number of machine, logic must be set according to the configuration of the machine.
BASE
| Item | Part No. | Qty | Description | Notes |
|---|---|---|---|---|
| 1 | – | 1 | Base | Special order |
| 2 | – | 1 | Base cover -black | Special order |
| 3 | 56516 | 1 | Pin, spring mount – M5 | |
| 4 | A0000764108 | 1 | Stabilizer guide | |
| 5 | A0000763366 | 1 | Stabilizer, jack | |
| 6 | A0000763365 | 1 | Stabilizer adapter | |
| 7 | – | 4 | Angular plate | Special order |
| 8 | – | 1 | Top cover – black | Special order |
| 9 | A0000507208 | 1 | Front closure – white | |
| 10 | A0000507209 | 1 | Door – white | |
| 11 | – | 1 | Angular hook | Special order |
| 12 | A0000216115 | 1 | Level, spirit | |
| 13 | – | 1 | Lock pin – closing | Special order |
| 14 | – | 1 | Mast guide flange | Special order |
| 15 | – | 1 | Mast guide flange without blocking | Special order |
| 16 | – | 1 | Mast guide flange with blocking | Special order |
| 17 | A0000507210 | 1 | Rear closure – white | |
| 18 | 56539 | 1 | Door handle – locking | |
| 19 | 56536 | 1 | Bumper – rubber | |
| 20 | 56538 | 1 | Hinge | |
| 21 | A0000507211 | 1 | Shock absorber, 20×17 M6x20 60° |
TELESCOPIC MAST
| Item | Part No. | Qty | Description | Notes |
|---|---|---|---|---|
| 1 | A0000507212 | 1 | Plate, support – mast | |
| 2 | A0000507213 | 1 | Weldment4P hub for mast – black | |
| 3 | A0000507214 | 1 | Weldment, mast 1 150×150 | |
| 4 | A0000507215 | 1 | Weldment mast 2 120×120 | |
| 5 | A0000507216 | 1 | Weldment, mast 3 100×100 | |
| 6 | A0000507217 | 1 | Weldment, mast 4 80×80 | |
| 7 | A0000507218 | 1 | Weldment, mast 5 60×60 | |
| 8 | A0000507219 | 1 | Weldment, mast 6 40×40 | |
| 9 | A0000300988(1) | 1 | Sheave | |
| 10 | – | 1 | Support, security pin | Special order |
| 11 | – | 1 | Inox screw M8 H=4mm | Special order |
| 12 | A0000507220 | 1 | Tube, cable guide | |
| 13 | – | 1 | 15/15 RSGU1 clamp | Special order |
| 14 | – | 1 | Angular for mast | Special order |
| 15 | – | 1 | Short nylon angular blocking plate | Special order |
| 16 | A0000507221 | 1 | Assembled security pin | |
| 17 | – | 1 | Raising hook | Special order |
| 18 | – | 1 | Mast guide flange | Special order |
| 19 | A0000507222 | 1 | Winch, dual handle – manual | |
| 20 | A0000507223 | 1 | Steel cable (l 1860 Ø 6) | |
| 21 | A0000507224 | 1 | Steel cable (l 5650 Ø 6) | |
| 22 | A0000763482 | 1 | Cover, winch |
FLOODLIGHT GROUP
| Item | Part No. | Qty | Description | Notes |
|---|---|---|---|---|
| 1 | – | 2 | Plate. reinforcement | Special Order |
| 2 | – | 2 | Cap, 60 x 60 | Special Order |
| 3 | – | 1 | Support, light sensor – black | Special Order |
| 4 | A0000216084 | 1 | Sensor, light | |
| 5 | 1 | Support, electrical box | Special Order | |
| 6 | A0000507225 | 3 | Strain relief, PG11 | |
| 7 | – | 1 | Screw | |
| 8 | – | 1 | Strain relief,M25 x 1.50 | Special Order |
| 9 | – | 1 | Cover, electric box – black | Special Order |
| 10 | – | 1 | Strain relief, PG13.5 | Special Order |
| 11 | A0000507227 | 1 | Box, junction | |
| 12 | – | 1 | Clamp, 15/15 RSGU1 | Special Order |
| 13 | A0000300803 | 1 | Cord, coil | |
| 14 | A0000507228 | 1 | Box, terminal 10-18P – male | |
| 15 | A0000507229 | 1 | Terminal board, 10P female | |
| 16 | A0000203129 | 4 | Assembly, 240W LED light | |
| 17 | A0000203130 | 4 | Trunnion, floodlight | |
| 18 | A0000507235 | 4 | Spacer, | |
| 19 | – | 1 | Tube, light mount – black | Special Order |
| 20 | – | 1 | Plate, floodlight – black | Special Order |
| — | 72178 | 4 | Driver. LED 30V, 10.7A-CC 320W |
Part No. A0000419061 Rev. E 11/09/2023
©2023 Generac Power Systems, Inc.
All rights reserved.
Specifications are subject to change without notice.
No reproduction allowed in any form without prior written consent from Generac
Power Systems, Inc.
Generac Power Systems, IncS45 W29290 Hwy. 59,
Waukesha WI 53189
GeneracMobileProducts.com
844-ASK-GNRC │844-275-4672
References
- Generac Mobile Products - Index
- Generac Mobile Products - Index
- P65Warnings.ca.gov
- P65Warnings.ca.gov/diesel
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>