NORDIC PLAY 805-410 Canoe Swing Instructions

NORDIC PLAY 805-410 Canoe Swing

Product Information

The product is a Canoe swing manufactured by NSH NORDIC A/S. It is designed for outdoor use and is suitable for children aged 3-10 years. The swing has a maximum user weight capacity of 100 kg and can accommodate a maximum of 2 users at a time. The swing is made in PRC and comes with an art number of 805-410.

Product Usage Instructions

Assembling:

1. Place the main body and the 2 Triangle Corners at the right position. The opening in both ends must turn down.
2. Put the metal tube through the fabric sleeves one by one.
3. Connect the tubes in the middle on both sides.
4. Tighten it by screw with washer.
5. The main frame must now look as shown on the picture.
6. Make the 2 fabric sleeves smoothly after the metal tube assemble as shown on the picture.
7. Pull the hanging rope ends to the metal tube.
8. Repeat step 7 for all 4 corners.
9. After the 4 rope ends are pulled, make the swing body smooth again before the Triangle ends assembly.
10. Assemble the 2 Triangle ends one by one and repeat the same step on the other Triangle end.
11. Tighten and lock the screws as shown in the picture.
12. Put the 2 ends fabric cover over the Triangle ends.
13. The assembly is finished. Keep the wrench and the manual for future reference.

Installation:

1. Install the swing to the swing clamp of the swing set.
2. Adjust the rope.
3. The distance between the swing and the ground should be at least 35 cm.
4. The distance between an accessory and the frame should be at least 30 cm.
5. The distance between the swing clamps should be 45 cm.
6. The distance between swinging accessories should be 45 cm.
7. Check that the swing has been installed correctly by hanging on the rope for a few seconds.
8. Follow the manual for inspection and maintenance.

Warnings:

• Only for domestic use.
• Only for outdoor use.
• Maximum user weight is 100 kg.
• Suitable for children from 3-10 years.
• Maximum number of users is 2.
• To be assembled by an adult.
• The cross beam must not be higher than 250 cm.

General Safety Instructions:

• The safe play area should extend 200 cm beyond the play set on all sides.
• The safe play zone in front of and behind a swinging accessory is 200 cm.
• The safe play area must be free of all structures, fences, overhanging branches, electrical wires, and other obstacles.
• Do not situate the play set in the directions of walks or gangways.
• The ground surface must be level.
• Do not install the play set over concrete, gravel, asphalt, packed earth, or any other hard surface.
  Save these instructions for future reference.

Content

Assembling

WARNING! Adult assembling required!

1. Place the main body and the 2 triangle corners at the right position. The opening in both ends must turn down.
2. Put the metal tube through the fabric sleeves one by one.
3. Connect the tubes in the middle on both sides.
4. Tight it by screw with washer.

5. Main frame must now look as shown on picture.
6. Make the 2 fabric sleeves smoothly after the metal tube assemble  as shown on picture.
7. Pull thehanging rope ends to the metal tube.
8. Repeat step 7 for alle 4 corners.

9. After the 4 rope ends are pulled, make the swing body smooth again before the triangle ends assembly.
10. Assemble the 2 triangle ends as shown on the picture.
11. Lock and tight the screws one by one and repeat the same step on the other triangle end.
12. Tight and lock the screws.

13. Put the 2 ends fabric cover over the triangle ends.
14. 2 ends cover finished.
15. Fix the 4 velcros close to the hanging rope
16. Assembly is finished. Keep the wrench and the manual for future reference.

Installation

1. Install the swing to the swing clamp of the swing set.
2. Adjust the rope.
3. The distance between the swing and the ground should be at least 35 cm.
4. The distance between an accessory and the frame, should be at least 30 cm.
5. The distance between the swing clamps should be 45 cm.
6. The distance between swinging accessories, should be 45 cm.
7.  Check the swing has been installed correctly by hanging in the rope few seconds.
8. Follow the manual for inspection and maintenance.

Warnings!

• Only for domestic use.
• Only for outdoor use.
• Maximum user weight is 100 kg.
• Suitable for children from 3-10 years.
• Maximum number of users is 2.
• To be assembled by an adult.
• The cross beam must not be higher than 250 cm.
  Warning!
  The swing may only be used by children sitting or lying.

General safety instructions

• The safe play area refers to a zone extending 200 cm beyond the play set on all sides. The safe play zone in front of and behind a swinging accessory is 200 cm.
• The safe play area must be free of all structures, fences, garage, house, overhanging branches, laundry lines, electrical wires and other obstacles to ensure safe play.
• Do not situate your play set in the directions of walks or gangways.
• The ground surface must be level. Installing your play set on sloping ground can cause it to lean or “rack”. This leaning puts additional stress on all connections and joints and in time will cause those connections to loosen and fail.
• Do not install your play set over concrete, gravel asphalt, packed earth, or any other hard surface. A fall onto a hard surface can result in serious injury.
• The following is a list of recommended ground covers.
  • Double shredded bark mulch 50 cm
  • Uniform wood chips 50 cm
  • Fine gravel 50 cm
  • Fine sand 50 cm
• Save these instructions for future reference.

Safe play

• On site adult supervision must be provided for children of all ages and at all times.
• Teach the children to play safe.
• Dress children appropriately. Avoid accessories, clothing with drawstrings, loose fitting clothes and stringed items placed around the neck, which could become entangled or snagged on equipment. Also bike helmets should be taken off before playing on playground equipment.
• Last but not at least: use common sense to avoid any possible unsafe situations.
• Equipment should not be played upon in wet weather conditions because of potentially slippery surfaces and in periods of frost, even the softest pavement can change into a very hard surface.
• Accessories should be removed and taken indoors when temperatures drop below 0°C
• Using the playground or the accessories in any other manner than the way intended could lead to damage or injury. Do not twist or wrap swings, chains ropes or any other accessories. Twisting will reduce the strength of the accessories and may cause entrapment.
• Caution children no to:
  • Jump off swings while they are in motion.
  • Swing empty seats or other empty accessories.
  • Swing at an angle.
  • Hang upside down from any part of the gym set.
  • Grasp or stop another child on any moving equipment.
  • Walk close to, in front of, between, or behind moving accessories.
• Caution children to sit in centre of the swings with their full weight on the seats. Only one child per each planned occupant seat should be allowed.
• Climbing or hanging on the frame of the play set must not be permitted. Serious injuries can be result from fails.

Inspection and maintenance

• To ensure the safety of the users of the play set, the play set has to be subjected to the safety inspections mentioned below once at the beginning of each season and further twice monthly during the usage season.
• Check all hardware to be sure it is tight. Caution: overtightened hardware crushes the fibres of the wood resulting in split boards.
• Check the remaining hardware, brackets and swing clamps also for rust, which can have effect on the strength. Replace when necessary.
• Check the ground anchors to be sure that they are secured. If necessary, reposition or replace.
• Check all coverings for bolts and sharp edges and replace when required.
• Check swing seats and bars for integrity and check swing ropes for fraying or extreme creation of fibre. To examine the rope, open the strands of the rope there where the fraying occurred and securely check whether the filaments are broken. Check safety belt of baby swing, Replace when necessary.
• All accessories can be cleaned with warm water and a mild detergent.
• Check the play sets stability.
• Check the environment for direct danger like overhanging branches, laundry lines and loose materials.

Customer responsibilities

• It is the customer´s responsibility to perform regular inspections and maintenance to ensure that the product is not prematurely ageing. These inspections and maintenance are mentioned in this manual.
• The customer has to take all precautions to safeguard the safety of the children.

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>