OMNIVISION OH02A1S Medical RGB-IR Image Sensor Reduces Endoscope Size Cost Power and Heat User Guide
- June 12, 2024
- OMNIVISION
Table of Contents
OH02A1S
1080p product brief
Medical RGB-IR Image Sensor Reduces Endoscope
Size, Cost, Power and Heat by Half
User Guide
OH02A1S Medical RGB-IR Image Sensor Reduces Endoscope Size Cost Power
and Heat
OMNIVISION’s OH02A1S is the world’s first RGB-IR medical image sensor,
providing simultaneous white-light RGB captures and infrared monochrome
captures in a single CMOS sensor for cancer diagnosis and treatment. While
endoscopic precancer and cancer detection procedures are performed using IR
light, surgeons also need RGB light to confirm any abnormalities detected
using infrared.
Previously, this could only be accomplished by integrating two independent
imager sensors, which resulted in endoscopes with a larger size, higher cost
and higher power consumption, thereby excessively heating the tip of the
endoscope.
Built on OMNIVISION’s PureCel® pixel architecture, the OH02A1S offers 4×4
binning for the highest image quality, high quantum efficiency for excellent
low-light performance, and a high dynamic range for clarity in scenes with
widely contrasting bright and dark areas. The sensor can provide 1080p (1920 x
1080) resolution at 60 frames per second (fps) or 720p (1280 x 720) at 90 fps,
via a 2-lane MIPI serial output. The OH02A1S also integrates 2 kilobits of
one-time programmable memory on-chip. It consumes just 90 milliwatts at full
power, generating less heat for greater patient comfort.
With the OH02A1S, both IR and RGB images can now be captured using a single
chip, allowing the surgeon to switch between high quality RGB and IR in real
time, or to display both images simultaneously on one (overlay) or two (side-
by-side) monitors. Additionally, the smaller size and reduced heat allow the
endoscope to reach much farther into the body than was previously possible
with larger-outer- diameter, two-imager designs. Alternatively, designers can
use the extra space to add more or larger illumination (fiber or LED), or a
larger working channel for endoscopic tools.
The OH02A1S image sensor is available today in an RW package and the chip-
scale package will be available based on project demand.
Find out more at www.ovt.com.
Ordering Information
- OH02A1S-GA5A (RGB-Ir, chip probing, 150 µm backgrinding, reconstructed wafer with good die)
Applications
- medical endoscopes
- veterinarian endoscopes
- dental equipment
- industrial endoscopes
Product Features
-
1.4 µm x 1.4 µm pixel
-
optical size of 1/6″
-
programmable controls for:
– frame rate
– mirror and flip
– cropping
– windowing -
supports output formats: 10-bit RGB-Ir RAW
-
supports images sizes:
– 1080p (1920 x 1080)
– 720p (1280 x 720) -
standard serial SCCB interface
-
up to 2-lane MIPI serial output interface (supports maximum speed up to 1000 Mbps/lane)
-
embedded 2 kilobits of one-time programmable (OTP) memory for customer use
-
add staggered HDR raw data output
-
interleave row high dynamic range (iHDR) output
-
programmable I/O drive capability
Technical Specifications
-
active array size: 1920 x 1080
-
maximum image transfer rate:
– 1080p: 60 fps
– 720p: 90 fps -
power supply:
– core: 1.2V
– analog: 2.8V
– I/O: 1.8V -
power requirements:
– active: 90 mW
– standby: 210 µA
– XSHUTDN: 0.6 µA -
output format: 10-bit RGB-Ir RAW
-
lens size: 1/6″
-
temperature range:
– operating: -30°C to +85°C junction temperature
– stable image: 0°C to +60°C junction temperature -
lens size: 1/6″
-
lens chief ray angle: 33° non-linear
-
scan mode: progressive
-
pixel size: 1.4 µm x 1.4 µm
-
image area: 2728.8 µm x 1549.8 µm
-
die dimensions:
– COB: 3825 µm x 2889 µm
– RW: 3875 µm x 2939 µm
Functional Block Diagram
Version 1.4, June 2023
4275 Burton Drive
Santa Clara, CA 95054
USA
Tel: + 1 408 567 3000
Fax: + 1 408 567 3001
www.ovt.com
OMNIVISION reserves the right to make changes to their products or to discontinue any product or service without further notice. OMNIVISION, the OMNIVISION logo, and PureCel are registered trademarks of OmniVision Technologies, Inc. All other trademarks are the property of their respective owners.
https://www.ovt.com/products/oh02a1s/