Steba DF 150 Deep Fryer Instruction Manual

DF 150 Deep Fryer
Instruction Manual

220-240 V~; 50/60 Hz; 1.200 W
Fritters DF 150
Fritters met Fondue-Set DF 150F

DF 150 Deep Fryer

Generally

This appliance is for private and indoor use only and must not be used commercially. Please read the instruction manual carefully and keep it at a safe place. When the appliance is given to another person the instruction manual should be passed to that person, too. Only use the appliance as described in the instruction manual and pay attention to the safety information. No liability for damages or accidents will be accepted, which are caused by not paying attention to the instruction manual. Remove all packaging and sticker. Wash up all parts carefully (see cleaning).

Safety information

• Hot surface! There is danger of burning when touching the surface during operation. Set the back of the device with a distance of 10cm to the kitchen wall.

• Connect and operate the appliance in accordance with the specifications shown on the rating label.

• Do not use if the plug cord is damaged. Verify before every use.

• Do not plug with wet hands.

• Connect the power plug to a properly installed and easily accessible socket only.

• To unplug the power plug, always pull the plug – not the cable.

• Plug off the appliance after each use or in case of failure.

• Do not pull at the cord. Don’t pull it over edges and don’t bend it too much.

• Keep the cord away from hot parts.

• The appliance can be used by children aged 8 and above and persons with limited physical, sensory or mental capabilities or lack of experience/knowledge, provided that are supervised or have been provided with instruction in the safe use of the appliance and have understood the resulting dangers. Children must not use the packaging as a toy. Cleaning and user maintenance must not be carried out by children unless they are 8 years or older and are supervised.

• Children under the age of 8 must be kept away from the appliance and the connecting cable.

• Children should be supervised to ensure that they do not play with the appliance or packaging material (e.g. Plastic Bags).

• The appliance must not be operated using a timer or a separate remote system!

• Never leave the appliance unattended when in use.

• Do not leave the appliance outdoors or in a damp area.

• Never place anything on top of the device and do not cover the ventilation slots.

• Never immerse the unit in water.

• Leave a space of about 10cm around the device.

• Never use the device after a malfunction, e.g. if it felt down or has been damaged in any other manner.

• The manufacturer is not liable for damage which is occurring due to the usage of the appliance in a different way as described or a mistake in the handling has been made.

• To prevent injury, repairs such as replacing a damaged cord, should only be carried out by a customer service. Only original spare parts have to be used.

• The device gets hot, only transport after it cooled down.

• Only use the device as described in this manual.

• You must not put any materials such as paper, cardboard, plastic etc. into the appliance.

• This appliance is intended to be used in household and similar applications such as:
  o staff kitchen areas in shops, offices and others working environments
  o by clients in hotels, motels and other residential type environments
  o bed and breakfast type environments.

• Before initial use: clean all parts carefully and leave to dry.

• Attention! Device gets hot. Danger of burns! Do not place the appliance on a sensitive surface (e.g. painted furniture) and keep a distance of at least 70cm to burnable materials.

• During operation steam emerge. Keep hands and face away. Take appropriate distance to wall cupboards to avoid damage of the veneer.

• If an extension cable is used, it has to have a cross-section of 1,5mm². A cable drum must always be unwound. ∙ If a GS-tested 16 A multi-pin extension is used, it may not be charged with more than 3680 watts due to fire hazard.

• Make sure that children do not tease the cable or that a trip hazard occurs.

• The device must always be disconnected from the power supply if it is not supervised and before assembling, disassembling or cleaning.

• Hot steam may leave the louvers. Never place any wet food into the device, thaw frozen food slightly.

• Hygiene: Please always clean the device to avoid bacteria and mold formation.

Danger of splashes!

• To avoid splashes or foaming of the fat only use food which is not too wet (dry the food with cloth, remove ice from the food etc.). Insert the food slowly into the fryer.

• Condensation can form on the lid during frying.

• Be sure to wipe off the water before using the deep fryer again or closing the lid again.

• Do not put water in the hot fat. Risk of burns!
  Cleaning

• Attention! Pull the plug before cleaning and allow the device to cool down.

• Never immerse the unit into water. ∙ The device should be cleaned thoroughly each time the fat is changed.

• Pull the opened lid straight up from the device.

• There is a permanent filter in the lid; open the cover to remove it. Clean the filter with warm soapy water, let it dry and then put it back in place.

• Remove the basket.

• Carefully pour the cold fat into a saucepan. (See cleaning frying fat)

• Lid, basket and device can be cleaned with warm water with the addition of commercially available washing-up liquid.

• Then dry the parts well and make sure that there is no water in the lid.

• Do not use any harsh or abrasive cleaning agents.

• Reassemble the device after cleaning.

Workplace

Important : Never place this device on or next to hot surfaces (e.g. hot stoves). Only use it on a even, stable and a heat resisting surface. It is important that no inflammable items are near to the device. Do not place the device on the edge of the table so that it cannot be touched by children or fall down when touched.

Fat and oil:
Important: Deep frying fat must be hearable to a high temperature. The smoking point must be at about 220°C.
The food must be put in at a temperature of between 170°C and 190°C.
Deep frying oil is suitable. Never switch deep fat fryer on when empty.
Pour oil into the unheated container.
Cold-pressed and non-hardened oil or fat such as olive oil, wheat oil, linseed oil, pork fat and butter are unsuitable.
Important: Never mix oil and fat because the deep fat fryer may foam over.
It is also dangerous to mix different kinds of oil or fat!
The filling level indicator is inside the container. The MAX filling level may not be exceeded, and the minimum filling level must not be undershot.

Risk of scalding!
Be extremely careful with hot fat, and keep children away.

Assembly of the handle on the frying basket  DF 300

Deep fat frying
Place the prepared food into the frying basket and distribute over the entire surface. Do not place too much food in the fryer. Then slowly immerse the food in the fat. Close the filter lid again. The filter lid provides protection from fat splashes and reduces the smell of fat.
Observe the procedure through the lid window. If the fat foams up excessively, open lid and raise and lower the basket several times by raising and lowering the handle until the foaming subsides.
Caution! Used or contaminated fat or oil can self-ignite if overheated, which is why the oil should be replaced in good time. In the event of a fire, disconnect the plug form the power supply and extinguish burning fat by covering with the lid. Never extinguish using water!

A) Filter intake
B) Detachable lid
C) Lid window
D) Frying basket
E) Detachable handle
F) Housing
G) Panel

Operation

• Never operate the device without oil and check the MIN / MAX filling quantity.
• Connect the cable. The device beeps.
• Press the button “000” lights up in the display.
• Press the menu button, the basic temperature 140 °C flashes in the display.
• The temperature can be set between 100 and 190 °C within 6 seconds by using the +/- buttons. If the temperature is set, it lights up constantly.
• The device starts to heat up. The heating-up time is approx. 10 minutes.
• As soon as the appliance has heated up, the food can be put in the basket.
• Press the menu button again to set the timer. The time can be set between 20 and 120 minutes with the +/- buttons.
• The program is running, the temperature and time are shown alternately in the display.
• After the selected time has elapsed, the device switches off and a signal can be heard.
• Attention: if no timer is set, the device will be turned off for safety reasons after 2 hours.

Monitoring the deep fat frying procedure
The frying procedure can be monitored through the inspection window in the lid.
Lifting the basket a little may give you a better view.
When the food is cooked

• Open lid.
• Caution – lid may be hot!
• Lift frying basket and hook onto edge of pan.
• Once the fat has drained, remove frying basket and empty. Do not season the food over the fryer – this will protect the fat and the fryer.
• If no more frying is being carried out, turn down the temperature and disconnect plug from power supply.

Deep fat frying table:

Potato crisps
Shellfish
Poultry
Potato dishes
French fries
Beef
Schnitzels
Fish| 2-4
2-4
2-4
5-10
3-5
5-8
5-10
5-10
5-7
Approx. 180°C – 190°C| Steaks
Kebabs
Deep frozen food| 1-3
2-3
in accordance with the information on the packing

• This information is approximate and depends on the size, the weight and the temperature of the food.

Important Tips:
According the latest knowledge of researchers, following max. temperatures should be obeyed and all foods should be fried max to a gold color:
– 170°C for all potatoes, breaded food and all other starch containing products
– 190°C for meat and poultry with no breading
In opposite to the tips on the packaging of frozen food we advise to defrost the food short before frying to avoid any ice inside the fryer.

After deep fat frying:

Clean the fat:
Residue from the breadcrumb coating or the food should be removed from the frying fat or oil at regular intervals.

• First allow the fat to cool after frying, then carefully pour the fat into a metal pan with handles.
• Coating residue and water in the oil must be removed.
• Clean the frying basket and the pan (see paragraph “Cleaning and care”).
• Hook frying basket into the fryer (draining position, place kitchen paper in basket as a filter).
• Slowly pour the fat back into the fryer through the filter paper.
• Only use the paper fat filter once.

Replace the frying fat if:

• It has turned brown
• It has an unpleasant smell
• Starts to smoke sooner than expected Pour the liquid oil that has not yet fully cooled down into a container with a closure. Used fat and oil should not be poured onto compost or down the drain. If large quantities are being produced, ask your local authority for the location of a collection point.

Practical tips for frying
Dry the food carefully before putting it into the fat, tap superfluous flour, press the breading firmly. Food containing much protein such as fish, poultry, meat and seafood can be fried in the raw if they are well dried. Food containing little protein such as vegetables and fruit should be coated with breadcrumbs or with batter,  hereby the pores close quickly. The crust is also ideal for frying meat, poultry, fish and seafood.

Fondue (only for Aretino. 26-36-00)
When the device is used as a Fondue, remove the lid by pulling the lid upwards.
Put the Fondue ring on the appliance for the Fondue forks.
Leave the frying basket inside the appliance, as the bottom will be not damaged or food which has fallen off can be removed easier from the fat.
You can purchase the fondue ring including forks as an accessory with item number 99-75-00 from Stena Service.

Correct Disposal of this product
This marking indicates that this product should not be disposed with other household wastes throughout the EU. To prevent possible harm to the environment or human health from uncontrolled waste disposal, recycle it responsibly to promote the sustainable reuse of material resources. To return your used device, please use the return  and collection systems or contact the retailer where the product was purchased. They can take this product for environmental safe recycling.
Packaging disposal: Do not throw away the package materials. Please put it in the recycling bin.

Gift box: Paper, should be put to the old paper collection point.
Plastic packaging material and foils should be collected in the special collection containers.

Service and Repair:
If the appliance must be repaired, please get in touch with your trader or with the manufacturer:

STEBA Elektrogeräte GmbH & Co KG
Pointset. 2, 96129 Strullendorf / Germany
Distribution-Tel.: 09543 / 449-17 / -18,
Service-Tel.: 09543 / 449-44, Fax: 09543 / 449-19
e-Mail: elektro@steba.com
Internet: http://www.steba.com
www.steba.com

References

• art.no
• Steba Elektrogeräte | Qualität. Verlässlichkeit. Kompetenz.

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>