TAGWOOD BBQ BBQ25SS Built in Charcoal Grill Instruction Manual
- June 9, 2024
- TAGWOOD BBQ
Table of Contents
BBQ BBQ25SS Built in Charcoal Grill Instruction Manual
AN EXCELLENT CHOICE
Thank you for choosing TAGW000 BBQ charcoal grill, a product made of high-
quality materials and with high attention to details. We pre-pared this manual
thinking about you and your family. Here are some very simple instructions so
that you and your family can enjoy all the advantages that our product offers.
in addilion to its safety. Please read all instructions and safety warnings on
this manual thoroughly as you will find useful product information, warnings.
and cautions.
IMPORTANT: We have done our best to give you detailed and accurate
instructions on how to assemble this product. If in doubt consult qualified
personnel to assemble this product or contact us directly. The company is not
responsible for any difficulty and I or problem arising from the
interpretation of the instructions contained in this manual. The grill and all
its parts must be used only for the purposes in this manual. Both the Company
and distributors and / or representatives are not responsible for any type of
damage. either to people and/or property, directly or indirectly. due to the
inability to use this product safely and for which it was designed and
manufactured.
If you have any questions that are not indicated in these instructions. or for
service. assembly or operation information. you can contact us at: +1
786-376-7000 . or via e-mail by writing
to: info@tagwoodbbrt.com. Before doing so,
remember to locate the serial number on the interior part of the side table.
Before returning your purchased product please contact us for assistance.
PLEASE carefully read all safety instructions and warnings in detail BEFORE
assembling and operating your grill and check if it is properly assembled and
maintained. Failure to follow these instructions may result in serious body
injury and/or property damage.
IMPORTANT SAFETY WARNINGS IN CASE OF AN EMERGENCY, ALWAYS CALL 911 FIRST.
Please keep in mind that major causes of grill fires are a result of poor
maintenance and failure to maintain a required distance from the grill and
combustible and non-combustible materials and products. If uncontrolled fire
occurs, always call 911 or Fire Department first
HOT SURFACES. HEAT RESISTANT SAFETY GLOVES REQUIRED.
WARNING: This grill is for outdoor use ONLY. Do not use on unventilated
areas.
WARNING: While all care has been taken to remove sharp edges. care must
be taken when cleaning, assembling, or handling the grill to prevent risk of
injury from exposed metal edges.
- This product is not recommended for people with reduced phys-
- To ease assembling and avoid injury. use 3 people when assent-ice,. sensory, or mental capabilities, or lack of experience and bling when it is in its original box. knowledge, unless they are under direct supervision or instruction If missing any parts or damaged. do not attempt to assemble. by a person responsible for their safety Do not store children’s items of interest in the grill.
- Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. For more information please visit www.p65Warnings.com.gov
- We recommend, in case you need to move or relocate the product, hire suitable personnel for the transfer. Avoid disassembling the product, and once relocated, it is necessary to readjust all the parts and screws again.
- These warnings apply to all our products and accessories sold under our brand.
GRILL LOCATION WARNINGS
- Do not place the grill on any surface that is unable to safely support the weight of the grill or it may cause it to be unstable.
- This grill should be used and placed on a non-combustible surface.
- Keep the grill at least 18ft from any combustible and non-combustible material (decks, buildings, fences, trees, bushes, etc) from all sides and above. Keep in mind the wind conditions to add clearance/distance accordingly.
- Do not place the grill near flammable liquids, gases, or where flammable vapors may be present.
- The grill should be put in a well ventilated area.
- Remember to leave the necessary drain holes on the unit, where the grill is being installed, so that the water drains outside of the unit and does not damage it.
OPERATION WARNINGS
-
Do not use gasoline, kerosene, or alcohol for lighting charcoal.
Use of any of these or similar products could cause an explosion possibly leading to severe body injury. -
Do not leave a grill lit unattended. It must be supervised by a responsible adult at any time. Keep children and pets away from the grill as many parts can be hot and can cause severe burns.
-
When adding charcoal and/or wood, use extreme caution. Never add charcoal lighting fluid to hot or even warm coals as flashback and explosion may occur.
-
Never move the grill when it is in use or when it contains hot coals or ashes.
-
Be cautious as flames and sparks may flare-up.
-
Keep hands, face, and body safe from hot steam and flame flare ups.
https://www.youtube.com/channel/UCUfmrL7IAoRTLQ2JNQ-
UAPQ/videos
LIST OF PARTS:
Accesory kit:
Assembly:
Before you begin to assemble, carefully remove all protective films while
avoiding any scratches to the surface or any parts and while protecting the
working/assembly area.
Step 1
Assemble the handle (6) with the front of door using two M8*16mm screws (A),
spring washer( C) and D8 washer (B). Slide the drain system (4) under the
drain hole.
Step 2
Place the firebricks into the body. The firebricks with the chipped corner
goes first around the square tube.
Step 3
Insert the square tube (11) into the main body next to the front door.
Step 4
Put the main grates (8) into the main grate frame. Put the food griddle (7) on
the main grates. the square tube. Hang the S shapes meat hooks (5) on the
height adjustable system rod.
Step 5
On the wall, FIx the bracket (9) by three anchors (D), washers (F) and bolts
(E). Hang the poker (3) and shovel (2) on the bracket =
Note: Please lift the main grill by anti-clockwise rotation, and decline
the main grill by clockwise rotation.
Congratulations! We hope you enjoy your purchase. We worked hard so you can
have a great and safe experience. We are always available if you have any
questions or concerns about our products.
BEFORE USING FOR THE FIRST TIME
All stickers and films must be removed from the grill before use. We recommend
to clean the table, small grate, main grate, meat hooks and griddle thoroughly
with a suitable cleaning agent. Remove all cleaning residues and dry.
HOW TO CLEAN THE GRILL GRATES
Two hours after cooking: First, make sure all surfaces are cool. While still
on the grill, scrub grate with a stainless-steel brush to remove all excess of
food.
When grates are completely cool: Remove each section of grates from grill and
place them on the side. Add 1 gallon of warm water in a container big enough
to fit one piece at a time. Add a couple of drops of degreaser or detergent in
the water.
Insert one piece at a time in the container, soak it and scrub excess food
with a nylon cleaning brush. Remove each grate from bucket and rinse with
fresh water. Dry it with microfiber cloth. Repeat the process for each piece
of grate.
You can follow the same procedure for other parts in contact with food like
secondary grate, griddle and meat hooks.
HOW TO CLEAN THE OUTSIDE OF THE GRILL
First make sure all surfaces are completely cool. Use a microfiber cleaning
cloth mix with a soapy solution. Rub it over the exterior of the grill. If
there is persistent dirt or grease, you can use a soft sponge to scrub them
out. Rinse with fresh water but avoid any excess of water from getting inside
the grill as this can cause damage to the interior. Dry it with microfiber
cloth. Never use any sharp items that could scratch the surface of the grill.
Never use an acidic, chlorine based or abrasive cleanser on stainless steel.
They will damage the finish.
WARNING: Some discoloration will occur on some parts of the grill due to
the extreme heat. The company consider this a normal wear and tear and will
not be responsible for its cleaning.
LIMITED WARRANTY CERTIFICATE
Tagwood bbq warrants this product for a period of (5) years against
deficiencies in material and/or manufacture defect, from the date of issuance
of the purchase invoice.
This LIMITED WARRANTY does not cover products that are improperly used,
abused, altered or repaired. This warranty excludes all incidental or
consequential damages and any condition resulting from other than ordinary
residential wear or any use for which the product was not intended, such as
use in rental or contract trade or commercial. This warranty does not include
also normal wear and tear or dissatisfaction due to buyer’s remorse. The
LIMITED WARRANTY covers manufacturing, material
and parts defects after proper verification by authorized technicians. The
warranty will be void if the product suffers damages resulting from accidents,
improper assembly, improper use, carelessness, action of corrosive agents,
excessive load, ignorance of the instructions contained in the instruction
manual or for presenting signs of having been repaired by non-authorized
personnel. Deficient products or parts that are covered by this policy will be
replaced or repaired. This warranty is non-transferable and valid only with
the presentation of the purchase invoice. This product may undergo technical
design modifications without prior notice from manufacturer. The importer
assumes no responsibility for personal or property damage that could be caused
by improper installation or use of the product, including lack of maintenance
in the latter. Tagwood bbq reserves the right to inspect and assess the
product before honoring the warranty and to invalidate the warranty if it is
concluded that the claim was not valid.
If you believe that your product meets the criteria for warranty replacement,
please follow this procedure:
-
Take a picture of the damaged part
-
Take a picture of the invoice
-
Locate the serial number inside the front door on the right up corner.
-
Send both pictures (damaged part & invoice) and serial number to
info@tagwoodbbq.com with the subject warranty -
Please include a phone number we can contact you
-
We will contact you 48 hrs after receiving the email to explain how to proceed
OPERATING INSTRUCTIONS
WARNING: We recommend moving food aside from the grill if flare-ups
occur, to avoid getting the food too burned, or not at the desired cooking
level. The best way to manage this is to create two zones of fire, and always
leave some portion of the grilling surface without coals under, so that when
the flare-up occurs, you can move the food to the other side and then move
back when the flames reduce.
WARNING: We recommend cooking on the secondary grill or griddle without
direct flame. Always do it only with the heat of the coals. Use extreme care
while cooking on the secondary grill or griddle or when adding any type of
liquid such as oil as it may generate a flame or hot drops causing serious
injury.
Step 1:
We recommend not to use lighter fluid because it may transmit a chemical taste
to your food. Instead you can use a natural Firestarter.
Step 2:
When coals start falling under the firebox it means they are ready. Use the
coal rake to start spreading out the fallen coals to create an even layer
under the main grate.
Step 3:
Place the food on the grill only when the charcoals have reached the desired
temperature for cooking.
GET TO KNOW YOUR GRILL BETTER
- Height adjustment system. This feature gives you the possibility to adjust the height of the grates to regulate cooking temperature. Use the wheel to move the main grates up or down depending on what you need (closer to the coals = more heat to sear | away from
- The firebox allows you to light up the charcoal quicker and with less effort. It maintains fire lit and away from food. You can use wood charcoal, briquettes or wood based on your preference. We recommend using lump charcoal and firewood. coal = less heat for slow cooking).
- Firebricks help transmit less heat to the outside panels but also spreads the heat evenly under the grates. Last, but not least, it
- 3 different cooking areas to inspire your imagination. A main grate, one interchangeable griddle and 8 S shape meat hooks for extends the life of the grill. roasting or smoking your favorite food.
https://www.youtube.com/channel/UCUfmrL7IAoRTLQ2JNQ-UAPQ/videos
https://qr.shopify.com/K92z-b1N
CUSTOMER SERVICE 1 SERVICIO AL CLIENTE
+1 786-376-7000 – Argentina:
0230-444-0734
Questions / Consultas
www.tagwoodbbqicom
email:info@tagwoodbbq.com
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>