TAGWOOD BBQ BBQ03SI Argentine Santa Maria Wood Fire & Charcoal Grill Instruction Manual
- June 9, 2024
- TAGWOOD BBQ
Table of Contents
BBQ BBQ03SI Argentine Santa Maria
Wood Fire & Charcoal Grill **Instruction Manual**
AN EXCELLENT CHOICE
Thank you for choosing TAGWOOD BBQ charcoal grill, a product made of high-
quality materials and with high attention to details. We prepared this manual
thinking about you and your family. Here are some very simple instructions so
that you and your family can enjoy all the advantages that our product offers,
in addition to its safety.
Please read all instructions and safety warnings on this manual thoroughly as
you will find useful product information, warnings, and cautions, IMPORTANT:
We have done our best to give you detailed and accurate instructions on how
to assemble this product. If in doubt, consult qualified personnel to assemble
this product or contact us directly.
The company is not responsible for any difficulty and / or problem arising
from the interpretation of the instructions contained in this manual, The
grill and all its parts must be used only for the purposes in this manual,
Both the Company and distributors and / or representatives are hot responsible
for any type of damage, either to people and/or property, directly or
indirectly, due to the inability to use this product safely and for which it
was designed and manufactured.
If you have any questions that are not indicated in these instructions, or for
service, assembly or operation information, you can contact us at: +1 (786)
999 – 2568, or via e-mail by writing to:
[email protected].
Before doing so, remember to locate the serial number on the interior part of
the side table.
Before returning your purchased product, please contact us for assistance.
PLEASE carefully read all safety instructions and warnings in detail BEFORE
assembling and operating your grill and check if it is property assembled and
maintained, Failure to follow these instructions may result in serious body
injury and/or property damage.
IMPORTANT SAFETY WARNINGS
IN CASE OF AN EMERGENCY, ALWAYS CALL 911 FIRST. Please keep in mind that major
causes of grill fires are a result of poor maintenance and failure to maintain
a required distance from the grill and combustible and non-combustible
materials and products. If uncontrolled fire occurs, always call 911 or Fire
Department first.
HOT SURFACES.
HEAT RESISTANT SAFETY GLOVES REQUIRED.
WARNING: This grill is for outdoor use ONLY. Do not use on unventilated
areas.
WARNIMG: While all care has been taken to remove sharp edges, care must
be taken when cleaning, assembling, or handling the grill to prevent risk of
injury from exposed metal edges.
Use caution when moving the grill to prevent injuries, Ensure the grill is
completely cool to the touch before moving.
Do not place anything flammable on the under shelf or products that can melt.
This product is not recommended for people with reduced physical, sensory, or
mental capabilities, or lack of experience and knowledge, unless they are
under direct supervision or instruction by a person responsible for their
safety.
To ease assembling and avoid injury, use 3 people when assembling when it is
in its original box.
If missing any parts or damaged, do not attempt to assemble.
Do not store children’s items of interest in the grill.
Combustion by-products produced when using this product contain chemicals
known to the State of California to cause cancer, birth defects or other
reproductive harm. For more information please visit
www.p65Warnings.ca.gov
These warnings apply to all our products and accessories sold under our brand.
GRILL LOCATION WARNINGS
Do not place the grill on any surface that is unable to safely support the
weight of the grill or it may cause it to be unstable, This grill should be
used and placed on a non- combustible surface. Keep the grill at least 18ft
from any combustible and non-com- bustible material (decks, buildings, fences,
trees, bushes, etc) from all sides and above. Keep in mind the wind
conditions to add clearance/distance accordingly.
Do not place the grill near flammable liquids, gases, or where flammable
vapors may be present.
Place this grill on an area protected from the wind.
OPERATION WARNINGS
Do not use gasoline, kerosene, or alcohol for lighting charcoal.
Use of any of these or similar products could cause an explosion possibly
leading to severe body injury.
Do not leave a grill lit unattended. It must be supervised by a responsible
adult at any time. Keep children and pets away from the grill as many parts
can be hot and can cause severe burns.
When adding charcoal and/or wood, use extreme caution, Never add charcoal
lighting fluid to hot or even warm coals as flashback and explosion may occur.
Never move the grill when it is in use or when it contains hot coals or ashes,
Be cautious as flames and sparks may flare-up.
Keep hands, face, and body safe from hot steam and flame flare ups.
To avoid injuries and protect hands use heat resistant globes or oven mitts
while cooking or touching any part of the grill.
Always open or close the front door holding from its handle as the door can
get extremely hot. Never leave coals and ashes unattended. Before leaving the
grill, coals and ashes must be removed or not burning any longer. Handle
secondary grate, griddle, meat hooks. shovel. and coal rake with extreme
caution and with heat resistant gloves or oven mitts since they can get hot
and cause injuries. You should clean and maintain your grill after and before
every use.
Do not place the coal rake and shovel on the grill while using the grill, as
they heat up, and could cause severe burns.
Always place them on another surface that does not heat up to be able to use
on grill. Always place charcoal on top of the refractory bricks.
Do not place charcoal directly on the bottom of the grill. Do not place coals
on the front door. Always put them on the firebricks.
Do not grill in high winds.
Do not wear clothing with loose flowing sleeves or allow hair to hang freely
while lighting or using the grill. Never allow children to operate the grill.
Do not burn manufactured logs, driftwood, trash, leaves, paper, cardboard,
plywood, painted or stained or pressure treated wood. Avoid using softwoods
such as pine or cedar that can throw sparks.
Be cautious because winds can cause unexpected flare-ups and blow hot embers
from the fire resulting in body injury or property damage. When using. never
lean on any part of the grill. The use of alcohol, prescription drugs, non-
prescription drugs, or illegal drugs, may impair the consumer’s ability to
properly and safely assemble, move. store. or operate the grill.
Dump ashes or charcoal only when they are completely extin-guished and out.
Do not store the grill before ashes and coals are completely out Do not heat
unopened food containers on any part of the grill. The buildup of pressure
resulting from the heat may cause the container to burst. Always wear closed
shoes as hot coals or sparks may fall from the grill and cause burns or
injuries.
LIST OF PARTS:
Assembly: Before you begin to assemble, caretully remove all protective films while avoiding any scratches to the surface or any parts and whilst protecting the working/assembly area.
Step 1
Screw the two casters with brake (20) into lower end of leg set (3,4). Make
sure you do it on the front view as marked. Screw the two casters without
break (19) into lower end of leg sets (3,4). Make sure you do it on the rear
view as marked.
Step 2
Assemble the two sets of legs with the bottom shelf (2) using eight M612
hexagon screws (A) and washers (F).
Step 3
Assemble front and back support rail (5) with top of leg sets using eight
M612mm hexagon screws (A) inside and using eight M6“50mm hexagon screws (H)
outside.
Step 4
Carefully place the main body (1) on the lower structure.
Assemble them together using four M6*60mm hexagon screws (I) and nut (E).
Step 5
Assemble the handle (21) in the front door using M8*16 screws (B), spring
washers (0) and washers (C). Slide the water drain (23) under the drain hole.
Step 6
Place the firebricks (22) into the body.
Step 7
Insert the height adjustment system rod (18) into the left (6) and right (7)
support rail Assemble the top support rail (8) using four M650 hexagon screws
(H) and D6 washers (F).
Step 8
Insert the height adjustment system into the main body and fix the right
support rail using two MG12 hexagon screws (A) and D6 washers (F) at the top
right side of the main body.
Step 9
Fix the end of left and right support rails (6,7) at the bottom of the main
body using four M612mm hexagon screws (A) and washers (F).
Step 10
Insert the gear (9) and hand wheel (10), and fix them with M612 hexagon serew
(A) and D6*20 washer(G).
Step 11
Put the firebox (15) into the side of the main body, and then put the
support (17) upon the left side edge of the firebox, fix them together using
four M6″12mm hexagon screw (A) and DG washer (F), and fix one in middle.
Step 12
Insert the secondary grate (16) into the assembled upright column Support (17)
and fix it by ring screw (J).
Step 13
Put the main frame grate (11) between the left and right-side Support rail by
45 degree of inclination, hang it with two sides of steel wire.
Step 14
Place the main grates (12) or griddle (13) on top of main frame grate (11).
Hang the meat hooks (24, 25) on the height adjustment system rod, and hang the
coal rake and shovel (26) at the right side of the grill.
Step 15
Assemble the side table (14) with left leg set using M8* 16 srew (B).
Congratulations! We hope you enjoy your purchase. We worked hard so you can
have a great and safe experience. We are always available if you have any
questions or concerns about our products.
BEFORE USING FOR THE FIRST TIME
All stickers and films must be removed from the grill before use. We recommend
to clean the table, small grate, main grate, meat hooks and griddle thoroughly
with a suitable cleaning agent. Remove all cleaning residues and dry.
HOW TO CLEAN THE GRILL GRATES
Two hours after cooking: First, make sure all surfaces are cool. While
still on the grill, scrub grate with a stainless-steel brush to remove all
excess of food.
When grates are completely cool: Remove each section of grates from grill and
place them on the side. Add 1 gallon of warm water in a container big enough
to fit one piece at a time. Add a couple of drops of degreaser or detergent
in the water.
Insert one piece at a time in the container, soak it and scrub excess food
with a nylon cleaning brush. Remove each grate from bucket and rinse with
fresh water. Ory it with microfiber cloth. Repeat the process for each piece
of grate.
You can follow the same procedure for other parts in contact with food like
secondary grate, griddle and meat hooks.
HOW TO CLEAN THE OUTSIDE OF THE GRILL
First make sure all surfaces are completely cool. Use a microfiber cleaning
cloth mix with a soapy solution. Rub it over the exterior of the grill. If
there is persistent dirt or grease, you can use a soft sponge to scrub them
out. Rinse with fresh water but avoid any excess of water from getting inside
the grill as this can cause damage to the interior. Dry it with microfiber
cloth. Never use any sharp items that could scratch the surface of the grill.
Never use an acidic, chlorine based or abrasive cleanser on stainless steel.
They will damage the finish.
WARNING: Some discoloration will occur on some parts of the grill due to the
extreme heat. The company consider this a normal wear and tear and will not be
responsible for its cleaning.
LIMITED WARRANTY CERTIFICATE
Tagwood bbg warrants this product for a period of (5) years against
deficiencies in material and/or manufacture defect, from the date of issuance
of the purchase invoice.
This LIMITED WARRANTY does not cover products that are improperly used,
abused, altered or repaired. This warranty excludes all incidental or
consequential damages and any condition resulting from other than ordinary
residential wear or any use for which the product was not intended, such as
use in rental or contract trade or commercial. This warranty does not include
also normal wear and tear or dissatisfaction due to buyer’s remorse. The
LIMITED WARRANTY covers manufacturing, material and parts defects after proper
verification by authorized technicians. The warranty will be void if the
product suffers damages resulting from accidents, improper assembly, improper
use, carelessness, action of corrosive agents, excessive load, ignorance of
the instructions contained in the instruction manual or for presenting signs
of having been repaired by non-authorized personnel. Deficient products or
parts that are covered by this policy will be replaced or repaired. This
warranty is non-transferable and valid only with the presentation of the
purchase invoice, This product may undergo technical design modifications
without prior notice from manufacturer. The importer assumes fo
responsibility for personal or property damage that could be caused by
improper installation or use of the product, including lack of maintenance in
the latter. Tagwood bbq reserves the right to inspect and assess the product
before honoring the warranty and to invalidate the warranty if it is concluded
that the claim was not valid. If you believe that your product meets the
criteria for warranty replacement, please follow this procedure:
Take a picture of the damaged part
Take a picture of the invoice
Locate the serial number under the table
Send both pictures (damaged part & invoice) and serial number to
[email protected] with the subject warranty
Please include a phone number we can contact you
We will contact you 48 hrs after receiving the email to explain how to proceed
OPERATING INSTRUCTIONS
WARNING: We recommend moving food aside from the grill if flare-ups
occur, to avoid getting the food too burned, or not at the desired cooking
level. The best way to manage this is to create two zones of fire, and always
leave some portion of the grilling surface without coals under, so that when
the flare-up occurs, you can move the food to the other side and then move
back when the flames reduce.
WARNING: We recommend cooking on the secondary grate or griddle without
direct flame. Always do it only with the heat of the coals. Use extreme care
while cooking on the secondary grill or griddle or when adding any type of
liquid such as oil as it may generate a flame or hot drops causing serious
injury.
Step 1:
We recommend not to use lighter fluid because it may transmit a chemical taste
to your food. Instead you can use a natural Firestarter.
Step 2:
When coals start falling under the firebox it means they are ready. Use the
coal rake to start spreading out the fallen coals to create an even layer
under the main grate.
Step 3:
Place the food on the grill only when the charcoals have reached the desired
temperature for cooking.
GET TO KNOW YOUR GRILL BETTER
- Height adjustment system. This feature gives you the possibility to adjust the height of the grates to regulate cooking temperature. Use the wheel to move the main grates up or down depending on what you need (closer to the coals = more heat to sear | away from coal = less heat for slow cooking).
- The firebox allows you to light up the charcoal quicker and with less effort It maintains fire lit and away from food. You can use wood charcoal, briquettes or wood based on your preference. We recommend using lump charcoal and firewood.
- Firebricks help transmit less heat to the outside panels but also spreads the heat evenly under the grates, Last, but not least, it extends the life of the grill.
- 4 different cooking areas to inspire your imagination. A main grate, one secondary grate and griddle and 8 $ shape meat hooks for roasting or smoking your favorite food.
|
---|---
| https://qr.shopify.com/W5c73jfg
CUSTOMER SERVICE | SERVICIO AL CLIENTE
+1 (786) 999 – 2568-Argentina: 0230-444-0734
Questions / Consultas
www.tagwoodbbo.com
email: [email protected]