DOMETIC CSG103 Gas Stove User Manual

DOMETIC CSG103 Gas Stove

Explanation of symbols

• WARNING!
  Safety instruction: Indicates a hazardous situation that, if not avoided, could result in death or serious injury.

• CAUTION!
  Safety instruction: Indicates a hazardous situation that, if not avoided, could result in minor or moderate injury.

• NOTICE!
  Indicates a situation that, if not avoided, can result in property damage.

• NOTE
  Supplementary information for operating the product.

Safety instructions

General safety

WARNING!

• This appliance shall only be used with gas cartridges compliant to EN 471.

• It may be hazardous to attempt to fit other types of gas containers.

• DO NOT MODIFY THIS APPLIANCE.

• ONLY USE IN WELL-VENTILATED AREAS.

• CARBON MONOXIDE HAZARD
  USING THIS APPLIANCE IN AN ENCLOSED SPACE MAY CAUSE DEATH. DO NOT USE IN CARAVANS, TENTS, MARINE CRAFT, CARS, MOBILE HOMES OR SIMILAR LOCATION.

• Use outdoors only.

Safety precautions when handling liquid gas

WARNING! Failure to obey these warnings could result in death or serious injury.

Explosion hazard

• After use always disconnect the liquid gas cylinder.
• Store liquid gas cylinders away from heating or cooking devices and other light or heat sources in a well-ventilated area out of the reach of children.
• Never store liquid gas cylinders in unventilated areas or below ground level (funnel-shaped holes in the ground).
• Never store liquid gas cylinders in buildings such as garages.
• Do not store liquid gas cylinders on their side.
• Keep liquid gas cylinders away from direct sunlight. The temperature should not exceed 50 °C.

Operating the device safely

WARNING!

• Beware of suffocation.
  While burning liquid gas, the device also consumes oxygen. When used indoors, there is a risk of suffocation due to insufficient oxygen. Only use the device outdoors. Under no circumstances use it indoors. Never use the device in a garage, porch or tent.

• If there is a leak on your device (smell of gas):

  • Immediately attempt to turn off the cylinder valve.
  • Remove the device to a well-ventilated location away from any ignition source.
  • Check for leaks using soapy water.
  • Do not try to detect leaks using a flame.
  • If the odor continues, keep away from the device and immediately call your gas supplier or your fire department.

• Do not use this device if it is leaking, damaged or does not operate properly.

• Check that seals between the device and the gas cylinder are in place and in good condition before connecting the gas cylinder.

• Do not use the device if it has damaged or worn seals.

• Only use the hose assembly as supplied with this device for connec-tion to the cylinder – DO NOT USE ADAPTERS.

• Avoid twisting or kinking the flexible hose.

• This device can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the device in a safe way and understand the hazards involved.

• Children must be supervised to ensure that they do not play with the device.

• Cleaning shall not be conducted by children without supervision.

• Only operate the device when you or another person can attend to it.

• Wear appropriate clothing when using the device.

• Do not wear loose-fitting clothing which could easily catch fire.

• Do not move the device during operation.

• Leave the device to cool down properly before you touch it with bare hands.

• Replace porous or damaged hoses immediately.

• This appliance must only be serviced by an authorized person.

• Never change the nozzles, injector or burners.

• Use the device for cooking only. Never use it for other purposes.

• Avoid using the device near combustible materials.

• Keep the area around the device free from fat, alcoholic substances, plastic and flammable materials (e.g. curtains, cloths or kitchen mate-rials).

• Only use pots and pans with an even base and a diameter not larger than the grids on the hob (approx. 205 mm). The pots and pans should be large enough to cover the flame. If the flame is not covered, items of clothing could catch fire.
  Pots and pans of the correct size also improve the efficiency of the hob.

• Ensure that pots and pans are stable when cooking.

• Never allow pot or pan handles to protrude over the edge of the hob. Turn the handles inwards, making sure that they are not positioned over other burners. This reduces the risk of spillage, the ignition of flammable materials and serious scalding.

• Avoid boil over and spillage. Pots which boil over can cause smoke and fires.

• Proceed with caution when heating oil or fat, as they can ignite under excessive heat.

• Only use dry pot holders to avoid steam build-up. Do not use towels or cloths as these can catch fire.

• Do not use the device as a space heater.

Intended use

The Dometic gas stoves CS102 and CSG103 are intended for portable outdoor use only. For use in enclosed spaces, requirements shown in fig. 2, page 3 must be met. In cases where there are 3 walls, 30 % of the total wall area must be open and unrestricted.

With CSG103, you can cook and grill at the same time.
The device may only be used when the lid is open.
Let the device cool down completely before putting it in a tent or awning.
This product is only suitable for the intended purpose and application in accordance with these instructions.
This manual provides information that is necessary for proper installation and/or operation of the product. Poor installation and/or improper operating or mainte-nance will result in unsatisfactory performance and a possible failure.
The manufacturer accepts no liability for any injury or damage to the product resulting from:

• Incorrect assembly or connection, including excess voltage
• Incorrect maintenance or use of spare parts other than original spare parts provided by the manufacturer
• Alterations to the product without express permission from the manufacturer
• Use for purposes other than those described in this manual
  Dometic reserves the right to change product appearance and product specifications.

Scope of delivery

See fig. 1

Before initial use

The permitted gas pressure can be found on the ratings label of the device.

• Always use the supplied gas hose and regulator. If this becomes damaged please contact the manufacturer‘s support (see back page) to organise a replace-ment.
• Before starting the product for the first time ensure all transit protection such as the plastic on the wind shields has been removed.

Using the device

Placing the device
When selecting the location for cooking, observe the following instructions:

• Set up the device outside in a well-ventilated place. Do not place it in a dip to pre-vent any gases from accumulating there.
• The ground must be firm, level and stable.
• Keep the device protected from the wind.
• Never place the device near flammable materials, even when cooling down. Keep a distance of at least 300 mm to the side and rear and at least 800 mm over-head.
• Never place the device near flammable liquids. Keep a distance of at least 8 m.
• Observe the safety instructions, see chapter “Safety precautions when handling liquid gas” on page 11.

Set up the device:

CS102: fig.3,
CSG103: fig.4,

Connecting the device to the gas cylinder

1. Proceed as follows:
   • CS102: fig.5, page 5 and fig. 7, page 6.
   • CSG103: fig.6, page 6 and fig. 7, page 6.

2. After connecting the device to the gas supply, check the gas pipe for leakage using a foaming agent, e. g. with soap. Never use a naked flame to test for gas leaks.

Igniting the device

WARNING! Beware of injury

• Only use the device when you or another person can attend to it.
• Ignite the burners as soon as you have turned on the gas supply. Otherwise gas can accumulate in the burner area and could cause an explosion.
• The complete ignition process must be visible from above and must not be hidden by pots placed on top of the hob.

NOTE

• While it is operating, you will be able to hear a slight noise caused by the gas flowing out. This is completely normal.
• Smoke can occur when using it for the first time. This is caused by deposits of machine oil burning and stops after approx. 10 minutes.

1. Proceed as follows:
   – Igniting the burners: fig. 8, page 7.
   – Igniting the grill burner (CSG103 only): fig. 9, page 8.

2. If the burner does not ignite after 3 attempts, turn off the gas and wait 10 seconds for the gas to clear.

3. Try again with the piezo igniter or light the device manually using a long match or long neck lighter (fig.10, page 8). Do not use a cigarette lighter.

4. After lighting, check that the burner has properly ignited. The flames must be burning along the whole length of the burner.

Using the pan
Proceed as follows (CSG103 only): fig. a, page 9.

Turning off the device
Proceed as follows: fig. 12, page 9.

Packing up the device

CAUTION! Beware of burns
The device is very hot when you use it. Leave the portable grill to cool down before you clean, dismantle or transport it.

1. Disconnect the device from the gas supply.
2. Clean the device (fig. 13, page 9).
3. Stow away the pan and rack (CSG103 only) and close the lid.

Replacing the gas cylinder

WARNING! Beware of injury
Change the gas cylinder in a well-ventilated location.
Ensure that there are no open flames in the vicinity.
Only replace the gas cylinder when the portable grill is switched off.

NOTE
To check whether the gas cylinder is empty gently rock it while upright from side to side. If you can hear or feel liquid this indicates the bottle still contains gas.

1. Completely close the valve on the gas cylinder.

2. Unscrew the regulator from the cylinder.

3. Check the condition of the gas hose.
   Replace the hose line if the material is brittle or porous.

4. Tightly screw the regulator by hand onto the new cylinder.

Cleaning and maintaining the device

• Proceed as follows: fig. 13, page 9.
• Have a suitable authorized and qualified person perform a thorough examination of the device at least every 5 years.

Troubleshooting

Due to unforeseen circumstances the appliance may not operate as designed.
Indications of this are burner flash-backs, large soft yellow flames, flames rising exten-sively away from the burner and the appliance not igniting or remaining alight.

In these cases, check your gas supply to ensure there is sufficient gas, no leaks and the valves are opened sufficiently for use. If this is the case and the problem/s still persist, you will need to contact a suitably qualified authorized person to ser-vice your appliance.

Repairs to the gas supply parts on the device may only be carried out by a qualified technician.

1. Shut off the gas supply immediately if a fault occurs.
2. Check again that the device has been assembled correctly and the parts are undamaged, especially the gas hose.
3. Replace the damaged parts.
4. Only use the device again once all the faults have been rectified.

Warranty

The statutory warranty period applies. If the product is defective, please contact your retailer or the manufacturer’s branch in your country (see dometic.com/dealer).
For repair and warranty processing, please include the following documents when you send in the product:

• A copy of the receipt with purchasing date
• A reason for the claim or description of the fault
  Note that self-repair or non-professional repair can have safety consequences and might void the warranty.

Disposal

Recycling packaging material

Place the packaging material in the appropriate recycling waste bins wher-ever possible.

Technical data

500 x 360 x 360 mm

470 x 330 x 90 mm

| ****

515 x 360 x 430 mm

490 x 315 x 170 mm

Weight| 4.1 kg| 5.6 kg

dometic.com

• YOUR LOCAL DEALER
  dometic.com/dealer

• YOUR LOCAL SUPPORT
  dometic.com/contact

• YOUR LOCAL SALES OFFICE
  dometic.com/sales-offices

A complete list of Dometic companies, which comprise the LDometic Group, can be found in the public filings of: DOMETIC GROUP AB Hemvärnsgatan 15 SE-17154 Solna Sweden

References

• Find a Dealer | Dometic USA
• Find a Dealer | Dometic USA

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>