HBM H130430 Strom Generator 720 Watt User Manual

HBM H130430 Strom Generator 720 Watt

BEFORE OPERATING THIS MACHINE

PLEASE READ THESE INSTRUCTIONS CAREFULLY

WARNING

1. Read the operator’s instruction manual.
2. Attention:  Exhaust gases are toxic. Do not operate the generator in a room without ventilation system!
3. Children should be protected by keeping.
4. Refilling of the generating sets are not allowed during the operation!
5. If the generator will be mounted in a closed room, relevant safety regulations against fire and explosion should be followed!
6. Do not connect to the household circuit.
7. Do not use in wet conditions! Do not place the machine in the blazing sun. Do not expose the machine to temperatures over 40 °C. Do not store the machine in humid surroundings.
8. Keep in flammable away.
9. Avoid touching hot parts of the machine.
10. When refueling.
    • stop the engine
    • no smoke
    • do not spill

• Take appropriate measures to protect your hearing.
• Beware of hot parts

PRE-OPERATION PREPARATION

1. To prevent get an electric chock, when operating the machine link with earth.
2. Use oil-mixed gasoline, if not, engine will be overheated. Gasoline and oil mixing ratio 50:1 (Picture 2).
3. Fuel tank capacity 4.2L.
4. Do not fill above fuel filter top.(Picture 3)
5. Use fuel tank cap to measure oil as.(Picture 4)
6. Put gasoline and oil into one container with mixing ratio of 50:1
7. After shaking, put them into fuel tank.

STARTING THE ENGINE

Before starting, do not connect electric apparatus. (Picture 5)

1. Shake fuel tank before starting engine.
2. Turn fuel cock lever to “ON”.(Picture 6)
3. Turn chock lever to ①. (Picture 7)
4. Turn engine switch to “ON”. (Picture8)
5. Pull slowly on recoil starter until engaged, then put it briskly. (Picture 9)
6. Return chock lever. (Picture 10).

STOPPING THE ENGINE

1. Before stopping, turn off electric apparatus. (Picture 11)
2. Turn engine switch to “STOP”. (Picture 12)
3. Turn fuel cock lever to “OFF”. (Picture 13)

CONNECTION

1. Wind lead 2 or 3 turns around handle. (Picture 14)
2. Start engine.
3. Plug into AC socket. (Picture 15)
4. SAFETY DEVICES

Press the button to reset protector, to reduce output load if AC protector turns off. (Picture 16)

1. ON
2. OFF

PERIODIC MAINTENANCE

Spark plug (per 50h or per one month)

1. Remove spark plug. (Picture 17)
2. Remove carbon deposits. (Picture 18)
3. Check for discoloration. Standard: Tan color.
4. Check spark plug gap.Standard:0.7~0.8mm. (Picture 19)

AIR FILTER (TIME: per 100h or per one month)

1. Remove air filter. (Picture 20①)
2. Wash clearly in solvent. (Picture 20②)
3. Get Motor oil. (Picture 20③)
4. Squeeze Motor oil out. (Picture 20④)

Warning: Never run engine without air filter.

FUEL COCK AND FUELTANK FILTER

(TIME: per 150h or per three month).

1. Clean fuel cock.
2. Stop engine.
3. Turn fuel cock lever to “OFF”.
4. Clean with solvent. (Picture21)
5. Clean fuel tank filter.
6. Clear in solvent.
7. Wipe off.
8. Insert into fuel tank. (Picture 22)

TROUBLE SHOOTING

Engine won’t start

1. Check fuel
2. Check engine switch
3. Check spark plug
4. If engines still won’t start, check following
5. If fuel cock is clogging
6. If air filter is clogging.
7. Installation and major repair work shall be carried out only by specifically trained personnel.
8. Or consult dealer or manufacturer.

STORAGE

When the generator set is not being operated or being stored more than one month, follow these instructions

1. Drain all the fuel out of the tank, fuel cock, and carburetor.
2. Shake the tank till all the excess being drain off.
3. Pour about one tablespoon of motor oil through the spark plug hole, then pull the starter several times and install the plug (with the ignition off), until you feel that piston is on its compression, stop pulling.
4. Stay the generator set in a dry, well-ventilated place, with the cover placed over it.

ACCESSORIES

1. User’s manual
2. Spark plug sleeve
3. Sleeve stick
4. Handle
5. 12V DC wire

GASOLINE GENERATOR

Type| H130430
AC voltage| 230V~/50Hz
AC output:| 650W| Power factor: 1.0
Max. AC output| 720W,S2 5min
Engine Speed| 3000 /min
LWA (acoustic power)| 94dB(A)
Max. temperature: 40℃| IP23M
Max. Attitude: 1000 m| BJ2022

DECLARATION OF CONFORMITY

Certificate of Compliance: in compliance with 2006/42/EC

We hereby state that the machinery concerned, its layout, and its construction all comply with applicable EC rulings concerning health and safety. Any change to this machinery without prior permission in writing issued by ourselves will make any and every guarantee to said machinery NULL AND VOID.

• Description and nature of the Machine: HBM 2-Takt 720W – 63cc Benzine Generator, Aggregaat 2PK ( H130430 )
• Model and series: QS950A
• Year of construction: 2022
• Harmonized EC rulings that are applied: EN ISO 8528-13:2016
• Date and Place: NL 2841 MJ Moordrecht 07-04-2022
• Signature/ Stamp: Herman Buitelaar ( Directeur )

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>