KARCHER IVR-B 20/8 Industrial Vacuum Cleaner Instruction Manual

KARCHER IVR-B 20/8 Industrial Vacuum Cleaner

General notes

Read these original operating instructions and the enclosed safety instructions before using the device for the first time. Proceed accordingly. Keep both books for future reference or for future owners.

Intended use

WARNING
Inhalation of dusts poses a health hazard
Health hazard
Never use the appliance to vacuum up dust which poses a health hazard.
ATTENTION
Short-circuit due to high levels of humidity
Damage to the device
Only use the device indoors.
The device is intended for:

• the vacuuming of non-flammable and
  non-explosive substances.

• the vacuuming of dusts and coarse dirt.

• For vacuuming moist and liquid substances.

• industrial use.

Any other use constitutes improper use.

Accessories and spare parts

Only use original accessories and original spare parts. They ensure that the appliance will run fault-free and safely. Information on accessories and spare parts can be found at www.kaercher.com.

Scope of delivery

Check the contents for completeness when unpacking. If any accessories are missing or in the event of any shipping damage, please notify your dealer.

Safety devices

Hazard levels

DANGER

• Indication of an imminent threat of danger that will lead to severe injuries or even death.

WARNING

• Indication of a potentially dangerous situation that may lead to severe injuries or even death.

CAUTION

• Indication of a potentially dangerous situation that may lead to minor injuries.

ATTENTION

• Indication of a potentially dangerous situation that may lead to damage to property.

Safety instructions

WARNING

• The device is not suitable for vacuuming up dusts that are harmful to human health.
• Protect the device from rain. Do not store the device outdoors.
• Every time before use, check whether the equipotential bonding conductors (earthing conductors) are connected.

CAUTION

• Switch off the device after each use and remove the mains plug.

ATTENTION

• Only use the device indoors.
• Risk of crushing! Wear gloves when removing or installing the suction head, filter inlay or collection container.
• Risk of damage! Never vacuum without a filter or with a damaged filter.
• Wear safety shoes when operating the device.
• Be careful to ensure that there is no dust spillage when replacing accessories.

Behavior in the event of an emergency

DANGER
Risk of injury and material damage when vacuuming inflammable materials, or in the case of a short-circuit or other electrical faults Danger of inhalation of gases hazardous to health, the danger of electric shock, danger of burns. In the event of an emergency, switch off the device and unplug the mains plug.

Electrical connection
The device may only be connected to an electrical connection that has been set up by a qualified electrician as per IEC 60364. For the connection values see Technical data and type plate. Use of an extension cable is prohibited.

DANGER
The danger of electric shock
The danger of death Avoid damaging the power cables by driving over them or otherwise crushing them, or by jerking them. Protect the cables from heat, oil and sharp edges. Check the mains connection of the device for damage every time before the operation. Do not operate the device using a damaged cable. Have any damaged cables replaced by a qualified electrician?

Description of the unit

See graphics page for illustrations
Illustration A

1. Suction turbine
2. Container
3. Locking clip
4. Handles for the container (IVR-B 30/15 and 50/30 only)
5. Container lid
6. Handles for the container lid
7. Suction hose connection
8. Power switch with overload protection
9. Mains cable
10. Pressure limiting valve (IVR-B 30/15 and 50/30 only)

Initial startup

See graphics pages for illustration

1. Ensure that the container lid is fitted correctly.
2. Insert the suction hose into the suction hose connection.

Illustration B

Operation

See graphics page for illustrations

1. Plug the mains plug into the socket.

2. Switch on the device using the power switch.
   Illustration C

3. Start vacuuming.

Motor circuit breaker

The motor circuit breaker interrupts the motor circuit when the current consumption of the motor is too high.

1. Allow the motor to cool down.
2. Check the suction hose, the container and the exhaust outlet for a blockage.
3. Switch the device on.

Note
If the motor circuit breaker trips again, cease operation and contact Customer Service.

Emptying the collection container

See graphics pages for illustration

1. Switch the device off and disconnect it from the power supply.

2. Unlock the locking clips.
   Illustration D

3. Remove the container lid and put it to one side.

4. Remove the suction hose from the suction hose connection.

5. Remove the container from the base plate and empty.

6. Dispose of or reuse the contents in accordance with statutory regulations.

7. Place the container on the base plate.

8. Insert the suction hose into the suction hose connection.

9. Replace the container lid and check it for a correct fit.

10. Lock the locking clips.

Ending operation

1. Switch off the device using the on/off switch
2. Empty and clean the collection container.
3. Remove the accessories and clean and dry them as necessary.

Transport

CAUTION
Failure to observe the weight
Risk of injury and damage Be aware of the weight of the device during transport and storage.

1. When transporting in vehicles, secure the device against slipping and tipping over according to the applicable guidelines.

Storage

CAUTION
Failure to observe the weight Risk of injury and damage Be aware of the weight of the device during transport and storage.

1. Store the device indoors only.

Care and service

• Rinse off the device and accessories at regular intervals using a suitable liquid and allow to dry.
• Check the cartridge filter regularly for damage. Replace the cartridge filter if damaged.

Replacing the cartridge filter

See graphics page for illustrations
Illustration E
IVR-B 30/15, IVR-B 50/30

1. Cartridge filter
2. Washer 4x
3. 4x nuts

Illustration F
IVR-B 20/8

1. Cartridge filter
2. Washer
3. Nut
   • Unscrew the nut(s) and remove the washer(s).
   • Remove the cartridge filter.
   • Insert the new cartridge filter. Ensure that the filter is inserted correctly and that the earth cable is connected during installation.
   • Insert the washer(s) and nut(s).
   • Tighten the nut(s).

Troubleshooting guide

DANGER
Risk of injury
The danger of the device unintentionally starting and danger of electric shock Switch off the device and unplug the mains plug before performing any work on the device. Have all checks and work on electrical parts performed by a qualified technician.

The motor (suction turbine) does not start up
No electrical voltage present

• Check the socket and the power supply fuse.
• Check the mains cable and the mains plug of the device

The suction power decreases
Nozzle, suction hose or suction pipe clogged.

• Check the nozzle, the suction hose and the suction pipe and clean if necessary. The filter is dirty.
• Clean the filter.

Customer Service department
If the malfunction cannot be corrected, the device must be checked by the Customer Service department.

Warranty

The warranty conditions issued by our relevant sales company apply in all countries. We shall remedy possible malfunctions on your appliance within the warranty period free of cost, provided that a material or manufacturing defect is the cause. In a warranty case, please contact your dealer (with the purchase receipt) or the next authorised customer service site. (See overleaf for the address).

Technical data

Declaration of Conformity

EU Declaration of Conformity

We hereby declare that the machine described below complies with the relevant basic safety and health requirements in the EU Directives, both in its basic design and construction as well as in the version placed in circulation by us. This declaration is invalidated by any changes made to the machine that are not approved by us.
Product: Dry vacuum cleaner
Product: Wet/dry vacuum cleaner
Type: 9.989-xxx

Currently applicable EU Directives

• 2006/42/EC (+2009/127/EC)
• 2014/30/EU
• 2011/65/EU

Harmonised standards used

• EN 55014-2: 2015
• EN 55014-1: 2017 + A11: 2020
• EN 60335-1
• EN 60335-2-69
• EN IEC 61000-3-2: 2019
• EN 61000-3-3: 2013 + A1: 2019
• EN 61000-3-11: 2000
• EN 62233: 2008
• EN IEC 63000: 2018

The signatories act on behalf of and with the authority of the company management.

Kärcher Industrial Vacuuming GmbH
Robert-Bosch-Straße 4-8
73550 Waldstetten (Germany)
Ph.: +49 7171 94888-0
Fax: +49 7171 94888-528
Waldstetten, 2021/11/01

We hereby declare that the product described below complies with the relevant provisions of the following UK Regulations, both in its basic design and construction as well as in the version put into circulation by us. This declaration shall cease to be valid if the product is modified without our prior approval.
Product: Dry vacuum cleaner
Product: Wet/dry vacuum cleaner
Type: 9.989-xxx

Currently applicable UK Regulations

• S.I. 2008/1597 (as amended)
• S.I. 2016/1091 (as amended)
• S.I. 2012/3032 (as amended)

Designated standards used

• EN 55014-2: 2015
• EN 55014-1: 2017 + A11: 2020
• EN 60335-1
• EN 60335-2-69
• EN IEC 61000-3-2: 2019
• EN 61000-3-3: 2013 + A1: 2019
• EN 61000-3-11: 2000
• EN 62233: 2008
• EN IEC 63000: 2018

The signatories act on behalf of and with the authority of the company management.

Kärcher Industrial Vacuuming GmbH
Robert-Bosch-Straße 4-8
73550 Waldstetten (Germany)
Ph.: +49 7171 94888-0
Fax: +49 7171 94888-528
Waldstetten, 2021/11/01

http://www.kaercher.com/dealersearch

2-2-HC-A5-GS-awx2508

References

• Cher - Official Site
• her.com
• Cleaning equipment and pressure washers | Kärcher International
• Cleaning equipment and pressure washers | Kärcher International

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>