weber GENESIS E/S-310,320, EP-310,320 Gas Grill

Specifications

• Model: Weber GENESIS S-320 NG (2007)
• Type: Natural Gas Grill
• Model Numbers: E/S -310/320, EP -310/320
• Part Number: #89#50507000

Product Information

The Weber GENESIS S-320 NG (2007) is a natural gas grill designed for outdoor use. It comes with specific safety instructions and warnings to ensure safe operation and maintenance.

Product Usage Instructions

1. Gas Leak Detection: Before operating the grill, carefully follow the leak-check procedures mentioned in the manual to ensure there are no gas leaks
2. Lighting Instructions: Always read the Lighting Instructions section of the manual before attempting to light the appliance.
3. Safety Precautions:
   • Do not store or use flammable liquids near the grill.
   • Do not attempt to disconnect any gas fitting while the barbecue is in operation.
   • Use heat-resistant barbecue mitts or gloves when operating the grill.
   • Keep electrical supply cords and fuel supply hoses away from heated surfaces.
   • Ensure all parts are properly assembled according to the assembly instructions before use.

FAQ

• Q: What should I do if I smell gas?
  A: If you smell gas, shut off the gas to the appliance, extinguish any open flames, open the lid, and if the odor continues, keep away from the appliance and call your gas supplier or fire department immediately.

• Q: Can I use liquid propane in a natural gas unit?
  A: No, using liquid propane in a natural gas unit is dangerous and will void your warranty. Always follow the recommended fuel type for your grill.

• Q: What should I do if I suspect a gas leak from the liquid propane cylinder?

• A: Move away from the cylinder, do not try to fix it yourself, and call your fire department for assistance.

• Q: What does the warranty cover?
  A: The warranty covers defects in material and workmanship from the date of purchase, subject to certain conditions as outlined in the manual.

Weber GENESIS S-320 NG (2007)
Owner’s Manual
Shop genuine replacement parts for Weber GENESIS
S-320 NG (2007)

Find Your Weber Grill Parts – Select From 2037 Models

• GAS GRILL
• Natural Gas Grill Owner’s Guide
• E/S -310/320, EP -310/320

• 89557#00000

• YOU MUST READ THIS OWNER’S GUIDE BEFORE OPERATING YOUR GAS GRILL

DANGER

If you smell gas:

1. 1. Shut off gas to the appliance.
   2. Extinguish any open flames.
   3. Open lid.
   4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fi re department.
   Leaking gas may cause a fi re or explosion which can cause serious bodily injury or death, or damage to property.

WARNING:

1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.
2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
   • WARNING : Follow all leak-check procedures carefully in this manual prior to barbecue operation. Do this even if the barbecue was dealer-assembled.
   • NOTICE TO INSTALLER: These instructions must be left with the owner and the owner should keep them for future use.
   • THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONLY.
   • WARNING : Do not try to light this appliance without reading the “Lighting Instructions” section of this manual.

WARNINGS

DANGER
Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property.

WARNINGS

• Do not store a spare or disconnected liquid propane cylinder under or near this barbecue.
• Improper assembly may be dangerous. Please follow the assembly instructions carefully.
•  After a period of storage, and/or nonuse, the Weber® gas barbecue should be checked for gas leaks and burner obstructions before use. See instructions in this manual for correct procedures.
• Do not operate the Weber® gas barbecue if there is a gas leak present.
• Do not use a flame to check for gas leaks.
• Combustible materials should never be within 24 inches (61 cm) of the back or sides of your Weber® gas barbecue.
• Do not put a barbecue cover or anything flammable on, or in the storage area under the barbecue.
• Your Weber® gas barbecue should never be used by children. Accessible parts of the barbecue may be very hot. Keep young children away while it is in use.
• You should exercise reasonable care when operating your Weber® gas barbecue. It will be hot during cooking or cleaning and should never be left unattended, or moved while in operation.
• Should the burners go out while in operation, turn all gas valves off. Open the lid and wait fi ve minutes before attempting to relight, using the lighting instructions.
• Do not use charcoal or lava rock in your Weber® gas barbecue.
• Never lean over open grill or place hands or fingers on the front edge of the cooking box.
• Should a grease fi re occur, turn off all burners and leave lid closed until fi re is out.
• Do not enlarge valve orifices or burner ports when cleaning the valves or burners.
• The Weber® gas barbecue should be thoroughly cleaned on a regular basis.
• Liquid propane gas is not natural gas. The conversion or attempted use of natural gas in a liquid propane unit or liquid propane gas in a natural gas unit is dangerous and will void your warranty.
• Do not attempt to disconnect any gas fitting while your barbecue is in operation.
• Use heat-resistant barbecue mitts or gloves when operating barbecue.
• Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.
• Combustion byproducts produced when using this product contain chemicals known to the state of California to cause cancer, birth defects, or other reproductive harm.
• Do not use this barbecue unless all parts are in place. The unit must be properly assembled according to the assembly instructions.

LIQUID PROPANE GAS UNITS ONLY:

• Use the pressure regulator and hose assembly that is supplied with your Weber® gas barbecue.
• Do not attempt to disconnect the gas regulator and hose assembly or any gas fitting while your barbecue is in operation.
• A dented or rusty liquid propane cylinder may be hazardous and should be checked by your liquid propane supplier. Do not use a liquid propane cylinder with a damaged valve.
• Although your liquid propane cylinder may appear to be empty, gas may still be present, and the cylinder should be transported and stored accordingly.
• If you see, smell or hear the hiss of escaping gas from the liquid propane cylinder:
  1. Move away from liquid propane cylinder.
  2. Do not attempt to correct the problem yourself.
  3. Call your fi re department.

WARRANTY

Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber gas grill that it will be free of defects in material and workmanship from the date of purchase as follows:

• Aluminum castings -2 year on paint excludes fading, 25-years

• Stainless steel Shroud, 25-years

• Porcelain-enameled shroud, 25-years

• Cookbox Assembly -2 year on paint excludes fading, 10-years
  Stainless steel burners tubes, 10-years

• Stainless steel cooking grates, 5-years no rust through or burn through

• Stainless steel Flavorizer bars, 5-years no rust through or burn through

• Porcelain-enameled cast-iron cooking grates, 5-year no rust through or burn through

• Porcelain-enameled cooking grates, 3-years no rust through or burn through

• Porcelain-enameled

• Flavorizer bars, 2-years no rust through or burn through

• Infrared Rotisserie Burner, 2-years

• All remaining parts, 2-years

• When assembled and operated in accordance with the printed instructions accompanying it.

• Weber may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN YOUR SALES SLIP OR INVOICE.

• This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under normal use and service and which on examination shall indicate, to Weber’s satisfaction, they are defective. Before returning any parts, contact the Customer Service Representative in your area using the contact information on our website. If Weber confirms the defect and approves the claim,

• Weber will elect to replace such parts without charge. If you are required to return defective parts, transportation charges must be prepaid. Weber will return parts to the purchaser, freight or postage prepaid.

This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse, misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or  service, or failure to perform normal and routine maintenance, including but not limited to damage  caused by insects within the burner tubes, as set out in this owner’s manual.

• Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes or tornadoes, discoloration due to exposure to chemicals either directly or in the atmosphere, is not covered by this Limited Warranty.

• There are no other express warrants except as set forth herein and any applicable implied warranties of merchantability and fi tness are limited in duration to the period of coverage of this express written Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so this limitation may not apply to you.

• Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the exclusion or limitation of incidental or consequential damages, so this limitation or exclusion may not apply to you.

• Weber does not authorize any person or company to assume for it any other obligation or liability in connection with the sale, installation, use, removal, return, or replacement of its equipment; and no such representations are binding on Weber.

• This Warranty applies only to products sold at retail.

• WEBER-STEPHEN PRODUCTS CO.

• Customer Service Center
  1890 Roselle Road, Suite 308
  Schaumburg, IL 60195, USA

• For replacement parts call: 1-800-446-1071

• www.weber.com®

EXPLODED VIEW

E/S/EP – 310

1. Shroud Hardware
2. Thermometer
3. Thermometer Bezel
4. Shroud
5. Handle
6. Warming Rack
7. Left Side Table
8. Cooking Grates
9. Crossover Tube
10. Cookbox
11. Left Frame Panel
12. Rear Frame Support
13. Front Frame Support
14. Left Trim Piece
15. Left Front Trim Piece
16. Catch Pan Holder
17. Disposable Drip Pan
18. Catch Pan
19. Front Panel
20. Left Door
21. Right Door
22. Door Handle
23. Control Knob
24. Bezel #3
25. Bezel #2
26. Bezel #1
27. Igniter Button
28. Igniter Module
29. Right Side Table
30. Flavorizer® Bar
31. Rear Burner Tube
32. Middle Burner Tube
33. Front Burner Tube
34. Igniter Electrode
35. Back Panel
36. Natural Gas Hose
37. Manifold
38. Right Frame Panel
39. Drip Tray
40. Right Trim Piece
41. Matchstick Holder
42. Right Front Trim Piece
43. Caster
44. Panel inferior
45. Locking Caster

EXPLODED VIEW E/S/EP – 320

1. Shroud Hardware
2. Thermometer
3. Thermometer Bezel
4. Shroud
5. Handle
6. Warming Rack
7. Side Burner Table
8. Side Burner Lid
9. Cooking Grates
10. Side Burner
11. Crossover Tube
12. Cookbox
13. Left Frame Panel
14. Rear Frame Support
15. Front Frame Support
16. Front Frame Support
17. Left Trim Piece
18. Left Front Trim Piece
19. Catch Pan Holder
20. Disposable Drip Pan
21. Catch Pan
22. Front Panel
23. Left Door
24. Right Door
25. Door Handle
26. Control Knob
27. Bezel #3
28. Bezel #2
29. Bezel #1
30. Igniter Button
31. Igniter Module
32. Right Side Table
33. Flavorizer® Bar
34. Rear Burner Tube
35. Middle Burner Tube
36. Front Burner Tube
37. Igniter Electrode
38. Back Panel
39. Natural Gas Hose
40. Manifold
41. Right Frame Panel
42. Manifold Hose
43. Drip Tray
44. Right Trim Piece
45. Matchstick Holder
46. Right Front Trim Piece
47. Caster
48. Bottom Panel
49. Locking Caster

GENERAL INSTRUCTIONS

Your Weber® gas barbecue is a portable outdoor cooking appliance. With the Weber® gas barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer® bars produce that “outdoor” flavor in the food.
The Weber® gas barbecue is portable so you can easily change its location in your yard or on your patio. Portability means you can take your Weber® gas barbecue with you if you move.
The natural gas supply is easy to use and gives you more cooking control than charcoal fuel.

• These instructions will give you the minimum requirements for assembling your Weber® gas barbecue. Please read the instructions carefully before using your Weber® gas barbecue. Improper assembly can be dangerous.
• Not for use by children.
• If there are local codes that apply to portable gas grills, you will have to conform to them. Installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable.
• This Weber® gas barbecue is designed for natural (piped in city) gas only. Do not use liquid propane (LP) bottled gas. The valves, orifices and hose are for natural gas only.
• Do not use with charcoal fuel.
• Check that the area under the control panel and the bottom tray are free from debris that might obstruct the flow of combustion or ventilation air.
• FOR INSTALLATION IN CANADA
  These instructions, while generally acceptable, do not necessarily comply with the Canadian Installation codes, particularly with piping above and below ground. In Canada the installation of this appliance must comply with local codes and/or Standards CAN/ CGA-B149.1 (Installation Code for Natural Gas Burning Appliances and Equipment).

STORAGE

• The gas must be turned off at the natural gas supply when the Weber® gas barbecue is not in use.
• When the Weber® gas barbecue is stored indoors, the gas supply must be disconnected.
• The Weber® gas barbecue should be checked for gas leaks and any obstructions in the burner tubes before using. (See Section: “Maintenance/Annual Maintenance”).
• Check that the areas under the control panel and the slide out bottom tray are free from debris that might obstruct the flow of combustion or ventilation air.
• The Spider /Insect Screens should also be checked for any obstructions. (See Section: “Maintenance/Annual Maintenance”).

OPERATING

• WARNING: Only use this barbecue outdoors in a well-ventilated area. Do not use in a garage, building, breezeway or any other enclosed area.
• WARNING: Your Weber® gas barbecue shall not be used under overhead combustible construction.
• WARNING: Your Weber® gas barbecue is not intended to be installed in or on recreational vehicles and/or boats.
• WARNING: Do not use the barbecue within 24 inches of combustible materials. This includes the top, bottom, back or sides of the grill.
•  WARNING: The entire cooking box gets hot when in use. Do not leave unattended.
• WARNING: Keep any electrical supply cord and the fuel supply hose away from any heated surface.
•  WARNING: Keep the cooking area clear of flammable vapors and liquids, such as gasoline, alcohol, etc., and combustible materials.

Gas Supply Testing

• Disconnect your Weber® gas barbecue when the gas supply is being tested at high pressures. This appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of 1/2 psig (3.5 kPa).
• Turn off your Weber® gas barbecue when the gas supply is being tested at low pressures. This appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at the pressure equal to or less than 1/2 psig (3.5 kPa).

COOKING

• WARNING: Do not move the Weber® gas barbecue when operating or while barbecue is hot.
• You can adjust BURNER 1, 2, and 3 as desired. The control settings: High (H), Medium (M), Low (L), or Off (O) are described in your Weber® cookbook. The cookbook uses these notations to describe the settings of BURNER 1, 2, and 3. For example, to sear steaks, you would set all burners at H (high). Then to complete cooking, you would set BURNER 1 and BURNER 3 at M (medium). Refer to your
• Weber® cookbook for detailed cooking instructions.
• Note: The temperature inside your cooking box for the fi rst few uses, while surfaces are still very reflective, may be hotter than those shown in your cookbook. Cooking conditions such as wind and weather, may require the adjustment of the burner controls to obtain the correct cooking temperatures.
• Preheating – Your Weber® gas barbecue is an energy-efficient appliance. It operates at an economical low BTU rate. To preheat: after lighting, close lid and turn all burners to high (H). Preheating to between 500° and 550° F (260° and 290° C) will take 10 to 15 minutes depending on conditions such as air temperature and wind.
• Drippings and grease – The Flavorizer® bars are designed to “smoke” the correct amount of drippings for flavorful cooking. Excess drippings and grease will accumulate in the catch pan under the slide out bottom tray. Disposable foil drip pans are available that fi t the catch pan.
• WARNING: Check the bottom tray for grease build-up before each use. Remove excess grease to avoid a grease fi re in the slide out bottom tray.

CLEANING

• WARNING : Turn your Weber® gas barbecue off and wait for it to cool before cleaning.
• CAUTION : Do not clean your Flavorizer® bars or cooking grates in a self-cleaning oven. For availability of replacement cooking grates and Flavorizer® bars contact the Customer Service
• Representative in your area using the contact information on our website. Log onto www.weber.com®
• Outside surfaces – Use a warm soapy water solution to clean, then rinse with water.
• CAUTION : Do not use oven cleaner, abrasive cleansers (kitchen cleansers), cleaners that contain citrus products, or abrasive cleaning pads on barbecue or cart surfaces.
• Slide out Bottom tray – Remove excess grease, then wash with warm soapy water, then rinse.
• Flavorizer® bars and Cooking grates – Clean with a suitable brass bristle brush. As needed, remove from grill and wash with warm soapy water, then rinse with water.
• Catch pan – Disposable foil trays are available, or you can line the catch pan with aluminum foil. To clean the catch pan, wash with warm soapy water, then rinse.
• Thermometer – Wipe with warm soapy water; clean with plastic scrub ball.
• Inside cooking module – Brush any debris off of burner tubes. DO NOT ENLARGE BURNER PORTS (OPENINGS). Wash inside of cooking box with warm soapy water and a water rinse.
• Inside Lid – While lid is warm, wipe inside with paper towel to prevent grease build-up. Flaking built-up grease resembles paint flakes.
• Stainless steel surfaces – Wash with a soft cloth and a soap and water solution. Be careful to scrub with the grain direction of the stainless steel.
• Do not use cleaners that contain acid, mineral spirits or xylene. Rinse well after cleaning.

Preserve Your Stainless Steel

• Your grill or its cabinet, lid, control panel and shelves may be made from stainless steel.
• To keep the stainless steel looking its best is a simple matter. Clean it with soap and water, rinse with clear water and wipe dry. For stubborn particles, the use of a non-metallic brush can be used.
• IMPORTANT : Do not use a wire brush or abrasive cleaners on the stainless steel surfaces of your grill as this will cause scratches.
• IMPORTANT : When cleaning surfaces be sure to rub/wipe in the direction of the grain to preserve the look of your stainless steel.

GAS INSTRUCTIONS

• INSTALL GAS SUPPLY
• General Specifi cations for Piping
• Note: Contact your local municipality for building codes regulating outdoor gas barbecue installations. In absence of Local Codes, you must conform to the latest edition of the National Fuel Gas Code:
• ANSI Z 223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas and Propane Installation Code. WE RECOMMEND THAT THIS INSTALLATION BE DONE BY A PROFESSIONAL.
• Some of the following are general requirements taken from the latest edition of the National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas and Propane Installation Code for complete specifi cations.
• This barbecue is designed to operate at 7 inches of water column pressure (.2526 psi).
• A manual shut-off valve must be installed outdoors, immediately ahead of the quick disconnect.
• An additional manual shut-off valve indoors should be installed in the branch fuel line in an accessible location near the supply line.
• The quick disconnect connects to a 3/8 inch NPT thread from the gas source. The quick disconnect fitting is a hand-operated device that automatically shuts off the flow of gas from the source when the barbecue is disconnected.
• The quick disconnect fitting can be installed horizontally, or pointing downward. Installing the fitting with the open end pointing upward can result in collecting water and debris.
• The dust covers (supplied plastic plugs) help keep the open ends of the quick disconnect fitting clean while disconnected.
• Pipe compound should be used which is resistant to the action of natural gas when connections are made.
• The outdoor connector must be firmly attached to rigid, permanent construction.
• WARNING : Do not route the 10 foot hose under a deck. The hose must be visible.

Gas Line Piping

• If the length of the line required does not exceed 50 feet, use a 5/8″ O.D. tube. One  size larger should be used for lengths greater than 50 feet.
• Gas piping may be copper tubing, type K or L; polyethylene plastic tube, with a minimum wall thickness of .062 inch; or standard weight (schedule 40) steel or wrought iron pipe.
• Copper tubing must be tin-lined if the gas contains more than 0.3 grams of hydrogen sulfi de per 100 cubic feet of gas.
• Plastic tubing is suitable only for outdoor, underground use.
• Gas piping in contact with earth, or any other material which may corrode the piping, must be protected against corrosion in an approved manner.
• Underground piping must have a minimum of 18″ cover.

Test Connections

• All connections and joints must be thoroughly tested for leaks in accordance with local codes and all listed procedures in the latest edition of the National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or
• CAN/CGA-B149.1

DANGER
Do not use an open flame to check for gas leaks. Be sure there are no sparks or open flames in the area while you check for gas leaks. This will result in a fi re or explosion which can cause serious bodily injury or death and damage to property.

TYPE OF GAS

• Your natural gas grill is factory built to operate using natural gas only. Never attempt to operate your grill on gases other than the type specified on the grill rating plates.
• Your grill operates at 7” of water column pressure. If replacement of the hose becomes necessary, factory specified parts are required. See your local dealer.
• For safety and design reasons, the conversion of a Weber® grill from operation using Natural gas to operation using LP gas requires the change out of the entire gas supply system of the grill. If this  becomes necessary, see your dealer for additional information.
• WHAT IS NATURAL GAS?
• Natural gas, often called methane, is a safe modern fuel. Natural gas is supplied by your local utility and should be readily available if your house is already heated with gas.
• PORTABLE INSTALLATION
  Weber® recommends moving the grill at least two (2) feet from the gas supply and
  any combustible surfaces. After the gas supply has been run and checked for leaks in accordance to the assembly instructions, you are ready to grill. To connect the hose
  to the gas supply, pull back the outer fitting, insert the hose fitting all of the way, and release the outer fitting. This process will produce a gas joint.

1. Swivel Connection

2.  Install covers when hose is disconnected

3. Shut Off Valve

4. Coat this pipe nipple with gas resistant pipe dope

5. Socket

6. Male Connection

7. Socket

8. Sleeve

9. Push Sleeve Back

10. Plug

Push plug until sleeve snaps forward locking plug in socket. (This turns on gas automatically.)
When properly assembled the plug cannot be removed without pushing the sleeve back. To disconnect, push sleeve back and pull out plug. (This automatically shuts off gas.)

LEAK CHECK PREPARATION
CHECK THAT ALL BURNER VALVES ARE OFF
Valves are shipped in the “OFF” position, but you should check to be sure that they are turned off. Check by pushing in and turning clockwise. If they do not turn, they are off. Proceed to the next step. If they do turn continue turning them clockwise until they stop, then they are off. Proceed to the next step.

REMOVE CONTROL KNOBS & CONTROL PANEL FOR LEAK TESTING
You will need: Phillips screwdriver.

1. Remove control knobs.
2. Remove screw and washer from back of control panel with a Phillips screwdriver.
3. Tilt the back edge of the control panel up. Push in on the front edge to release locking tabs. Carefully pull control panel away from frame.
4.  Disconnect the igniter wires from the ignition module.
5. Replace control panel when Leak Check is completed.

CHECK THE FLEXIBLE HOSE TO MANIFOLD CONNECTION
The natural gas hose has been attached during the manufacturing process. We do recommend that the hose to gas manifold connection be leak tested, following guidelines in this Owner’s Guide, prior to barbecue operation.
CHECK FOR GAS LEAKS

• Do not use an open flame to check for gas leaks. Be sure there are no sparks or open flames in the area while you check for leaks. Sparks or open flames will result in a fi re or explosion which can cause serious bodily injury or death and damage to property.
• WARNING: You should check for gas leaks every time you disconnect and reconnect a gas fitting.
• Note: All factory-made connections have been thoroughly checked for gas leaks. The burners have been flame-tested. As a safety precaution however, you should recheck all fittings for leaks before using your Weber® gas barbecue. Shipping and handling may loosen or damage a gas fitting.
• WARNING: Perform these leak checks even if your barbecue was dealer or store assembled.
• You will need: a soap and water solution, and a rag c brush to apply it.
• Make sure side burner is off (See LEAK CHECK PREPARATION). Remove valve control knob and screws. Remove porcelain top.
• To perform leak checks: Slide back the collar of the quick disconnect (1). Push male fi tting of the hose into the quick disconnect, and maintain pressure. Slide the collar closed (2). If it does not engage or lock, repeat procedure. Gas will not flow unless the quick disconnect is properly engaged.
• Turn on gas supply.
• Check for leaks by wetting the connections with the soap and water solution and watching for bubbles. If bubbles form or if a bubble grows, there is a leak.
• Note: Since some leak test solutions, including soap and water, may be slightly corrosive, all connections should be rinsed with water after checking for leaks.
• WARNING: Do not ignite burners when leak checking.

Check :

1. Hose to manifold connection.
   WARNING: If there is a leak at connection(1), retighten the fi tting with a wrench and recheck for leaks with soap and water solution. If a leak persists after retightening the fi tting, turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®.

2. Hose to quick disconnect connection.

3. Valves to manifold connection

4. WARNING: If there is a leak at connections(1) or(2) turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our website. Log onto www.weber.com®.

5. When leak checks are complete, turn gas supply OFF at the source and rinse connections with water.

Check:

1. Hose to manifold connection

2. Side burner hose to manifold connection and side burner hose to side burner gas line connection.
   WARNING: If there is a leak at connection (1), retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our website. Log onto www.weber.com®.

3. Hose to quick disconnect connection.

4. Valves to manifold connections.

5. Side burner hose to side burner connection, side burner valve to orifice.
   WARNING : If there is a leak at connections (2), (3), (4) or (5), turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our website. Log onto www.weber.com®.
   When leak checks are complete, turn gas supply OFF at the source and rinse connections with water.

OPERATING INSTRUCTIONS

1. LIGHTING
   Summary lighting instructions are inside the left hand cabinet door.

DANGER
Failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious  bodily injury or death.

Crossover® Ignition System

• Note : The Crossover® Ignition System ignites BURNER 1 with a spark from the igniter electrode inside the Gas Catcher™ ignition chamber. You generate the energy for the spark by pushing the electronic ignition button. You will hear it sparking.
• WARNING : Check hose before each use of barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only Weber® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our website. Log onto www.weber.com®.

MAIN BURNER LIGHTING

1. Open the lid.

2. Make sure all burner control knobs are turned OFF. (Push control knob down and turn clockwise to ensure that it is in the OFF position.)

3. Turn the gas supply valve on.
   WARNING: Do not lean over the open barbecue. Keep your face and body at least one foot away from the matchlight hole when lighting the barbecue.

4. Push BURNER 1 control knob down and turn to START/HI.

5. Push the electronic ignition button several times. You will hear it spark.

6. Check that the burner is lit by looking through the matchlight hole on the front of the cooking box. You should see a flame.
   WARNING : If the burner does not light, turn the Burner 1 control knob to OFF and wait 5 minutes to let the gas clear before you try again or try to light with a match.

7. After BURNER 1 is lit you can turn on BURNER 2 and BURNER 3.
   Note – Always light BURNER 1 fi rst. The other burners ignite from BURNER

TO EXTINGUISH
Push down and turn each burner control knob clockwise to the OFF position. Turn gas supply OFF at the source.

MAIN BURNER MANUAL LIGHTING

DANGER
Failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death.

1. Open the lid.

2. Make sure all burner control knobs are turned OFF. (Push each knob down and turn clockwise to ensure they are in the OFF position.)

3. Turn the gas supply valve on.

4. Insert match holder with lit match into the matchlight hole in the front of the cooking box.
   WARNING : Do not lean over open barbecue. Keep your face and body at least one foot away from the matchlight hole when lighting the barbecue.

5. Push BURNER 1 control knob down and turn to START/HI.

6. Check that the burner is lit by looking through the matchlight hole on the front of the cooking box. You should see a flame.
   WARNING: If the burner does not light, turn the Burner 1 control knob to OFF and wait 5 minutes to let the gas clear before you try again or try to light with a match.

7. After BURNER 1 is lit you can turn on BURNER 2 and BURNER 3.
   Note – Always light BURNER 1 fi rst. The other burners ignite from BURNER

TO EXTINGUISH
Push down and turn each burner control knob clockwise to the OFF position. Turn gas supply OFF at the source.

LIGHTING THE SIDE BURNER

• DANGER
  Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flame-up which can cause serious bodily injury or death.

• WARNING: Check hose before each use of barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only Weber® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®.

1. Open the side burner lid.
2. Check that the side burner valve is turned off (Push control knob in and turn clockwise to ensure that it is in the “OFF” position), turn all burners not being used to the “OFF” position (push in and turn clockwise).
3. Turn the gas supply valve on.
4. Push down and turn the side burner control valve to “HI”.
5. Press the igniter button several times so it clicks each time.

• CAUTION: Side burner flame may be difficult to see on a bright sunny day.
• WARNING: If the side burner does not light:
  • Turn off the side burner control valve, main burners and gas supply at source.
  • Wait 5 minutes to let the gas clear before you try again, or try lighting with a match (see “Manually Lighting the Side Burner”).

MANUALLY LIGHTING THE SIDE BURNER

DANGER
Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flare-up that can cause serious bodily injury or death.

1. Open the side burner lid.
2. Check that the side burner valve is turned off (Push control knob in and turn clockwise to ensure that it is in the “OFF” position), turn all burners not being used to the “OFF” position (push in and turn clockwise).
3. Turn the gas supply valve on.
4. Put match in a match holder and strike match.
5. Hold match holder and lit match by either side of the side burner.
6. Push down and turn the side burner control valve to “HI”.

CAUTION: Side burner flame may be difficult to see on a bright sunny day.
ARNING: If the side burner does not light:

• CAUTION: Side burner flame may be diffi cult to see on a bright sunny day.
• WARNING: If the side burner does not light:

TROUBLESHOOTING

Burners burn with a yellow or orange flame, in conjunction with the smell of gas.| Inspect Spider / Insect Screens for possible obstructions. (Blockage of holes.)| Clean Spider / Insect Screens. (See Section “Annual Maintenance”)
Burner does not light, or flame is low in “HI” position.| Is fuel hose bent or kinked?| Straighten fuel hose.
Does the burner light with a match?| If you can light the Left burner with a match, then check the electronic ignition system.
Experiencing flare-ups   CAUTION: Do not line the bottom tray with aluminum foil.| Are you preheating barbecue in the prescribed manner?| All burners on “HI” for 10 to 15 minutes for preheating.
Are the cooking grates and Flavorizer® bars heavily coated with burned-on grease?| Clean thoroughly. (See Section “Cleaning”)
Is the bottom tray “dirty” and not allowing grease to flow into catch pan?| Clean bottom tray
Burner flame pattern is erratic. Flame is low when burner is on “HI.” Flames do not run the whole length of the burner tube.| Are burners clean?| Clean burners. (See Section “Maintenance”.)
Inside of lid appears to be “peeling.” (Resembles paint peeling.)| The lid is porcelain enamel or stainless steel, not paint. It cannot “peel”. What you are seeing is baked on grease that has turned to carbon and is flaking off. THIS IS NOT A DEFECT.| Clean thoroughly. (See Section “Cleaning”.)
Cabinet doors are not aligned.| Check the adjustment pin on the bottom of each door.| Loosen adjustment nut/s. Slide door/s until aligned. Tighten nut.
If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®.

SIDEBURNER TROUBLESHOOTING

Straighten hose.
Push button ignition does not work.| Does burner light with a match?| If match lights burner, check igniter (see below).
If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®.

MAINTENANCE

SIDE BURNER MAINTENANCE
WARNING : All gas controls and supply valves should be in the “OFF” position.
Make sure black wire is connected between the igniter and electrode. Make sure white wire is connected between the igniter and grounding clip. Spark should be a white/blue color, not yellow.

1. Igniter Wire
2. Ground wire
3.  Burner

WEBER® SPIDER /INSECT SCREENS
Your Weber® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section (1) of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the combustion air opening. This could result in a fi re in and around the combustion air openings, under the control panel, causing serious damage to your barbecue.
The burner tube combustion air opening is fitted with a stainless steel screen (2) to prevent spiders and other insects access to the burner tubes through the combustion air openings.
We recommend that you inspect the Spider/Insect screens at least once a year.
(See Section “Annual Maintenance”.) Also inspect and clean the the Spider/Insect screens if any of the following symptoms should ever occur:

1. The smell of gas in conjunction with the burner flames appearing yellow and lazy.
2. Barbecue does not reach temperature.
3. Barbecue heats unevenly.
4. One or more of the burners do not ignite.

DANGER
Failure to correct the above mentioned symptoms may result in a fi re, which can cause serious bodily injury or death, and cause damage to property.

• ANNUAL MAINTENANCE
• Inspection and cleaning of the Spider/Insect screens
• To inspect the Spider/Insect screens, remove the control panel. If there is dust or dirt on the screens, remove the burners for cleaning the screens. Brush the Spider/Insect screens lightly with a soft bristle brush (i.e. an old toothbrush).
• CAUTION : Do not clean the Spider/Insect screens with hard or sharp tools. Do not dislodge the Spider/Insect screens or enlarge the screen openings.
• Lightly tap the burner to get debris and dirt out of the burner tube. Once the Spider/Insect screens and burners are clean replace the burners.
• If the Spider/Insect screen becomes damaged or cannot be cleaned, please contact the Customer Service Representative in your area using the contact information on our website. Log onto www.weber.com®.

MAIN BURNER FLAME PATTERN

The Weber® gas barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown.

1. Burner tube
2. Tips occasionally flicker yellow
3. Light blue
4. Dark blue
   If the flames do not appear to be uniform throughout the burner tube, follow the burner cleaning procedures.

MAIN BURNER CLEANING PROCEDURE

• Turn off the gas supply.
• Remove the manifold (See “Replace Main Burners”).
• Look inside each burner with a flashlight.
• Clean the inside of the burners with a wire (a straightened-out coat hanger will work). Check and clean the air shutter opening at the ends of the burners. Check and clean the valve orifi ces at the base of the valves. Use a Steel bristle brush to clean outside of burners. This is to make sure all the burner ports are fully open.
• CAUTION: Do not enlarge the burner ports when cleaning.

REPLACING MAIN BURNERS

1. Your Weber® gas barbecue must be OFF and cool.

2. Turn gas OFF at source.

3. To remove control panel:

   • Take off the burner control knobs.
   • Remove screw and washer from back of control panel with a Phillips screwdriver.
   • Tilt the back edge of the control panel up. Push in on the front edge to release locking tabs.
   • Disconnect the igniter wires from the ignition module.
   • Carefully pull control panel away from frame.

4.  Remove the two nuts (a) that hold the manifold support bracket to the cooking box. Allow the manifold support bracket to pivot down away from the cookbox, releasing the valve assembly from the burners (b).

5. Slide the burner assembly out from under the guide screw and washer (a) in the corners of the cooking box.

6. Lift and twist the burner assembly slightly, to separate the crossover tube (b) from the burners. Remove the burners from the cooking box.

7. To reinstall the burners, reverse 3) through 7).
   CAUTION : The burner openings (c) must be positioned properly over the valve orifices (d).
   Check proper assembly before fastening manifold in place.
   WARNING : After reinstalling the gas lines, they should be leak checked with a soap and water solution before using the barbecue. (See Step: “Check for gas leaks.”)

CROSSOVER® IGNITION SYSTEM OPERATIONS
If The Crossover® Ignition System fails to ignite the BURNER 1, light BURNER 1 with a match. If BURNER 1 lights with a match, then check the Electronic Ignition System.

• Check that both of the ignition wires are attached at the igniter module properly.
• Check that the ignition wire is attached at the ceramic igniter properly.
•  Check that the ceramic igniter assembly (A) is fully positioned into burner tube 1 igniter channel (B).
• Check that the ceramic igniter is properly positioned over the burner holes on BURNER 1.
• Check that the Electronic Ignition Button is working by listening and looking for sparks at BURNER 1.

REPLACE BATTERY IF NECESSARY
AAA alkaline battery only. See illustration:
If the Electronic Ignition System still fails to light, contact the Customer Service Representative in your area using the contact information on our website. Log onto www.weber.com®.

ATTENTION: This product has been safety tested and is only certified for use in a specifi c country. Refer to country designation located on outer carton.
These parts may be gas carrying or gas burning components. Please contact Weber-Stephen Products Co., Customer Service Department for genuine Weber- Stephen Products Co. replacement part(s) information.
WARNING: Do not attempt to make any repair to gas carrying or gas burning components without contacting Weber-Stephen Products Co., Customer Service Department. Your actions, if you fail to follow this product Warning, may cause a fi re or an explosion resulting in serious personal injury or death and damage to property.

WEBER-STEPHEN PRODUCTS CO.
www.weber.com®
©2007 The following trademarks are registered in the name of Weber-Stephen Products Co
FOUR GOOD REASONS TO REGISTER YOUR WEBER® GRILL RIGHT NOW
Register your grill online at www.weber.com® (If you register online, you do not need to send in this registration card.)

Spring. Summer. Fall. Winter. Four FREE issues of Weber Nation™, our hot e-mail newsletter all about grilling, will be coming your way. Each issue is packed with grilling tips and advice, triple-tested recipes, and everything you need to know to become a bona fide Weber Grilling Guru. All you have to do to activate your subscription is log on to www.weber.com® and register your grill. We’ll ask you a few short questions about the kind of food you like to grill and the topics that interest you so we can serve up your newsletter just the way you like it. Whether you are just starting out or a practiced hand at the grill, you’ll get just what you need to perfect your skills. So don’t put it off. Register now. Your hunger (and your pride) will thank you for it.

1. How Can We Reach You?

2. How would you prefer for us to contact you?

3. By US mail

4. By e-mail

5. By phone

6. No preference

7. Please don’t contact me unless it is in regards to a technical matter related to my grill

8. I prefer to receive information in Spanish

9. When did you buy your grill?

10. Without tax, how much did you pay for your grill?

11. Where did you buy your grill?

12. Which model did you purchase?

13. Have you ever owned a Weber® grill before?

    • Thanks for sharing your contact information with us. Again, it all stays strictly
    • between us — Weber does not share customers’ names with anyone else. If you need replacement parts or have questions about the assembly, use or maintenance of your grill, please call Weber Customer Service
    • For purchases made in the U.S.: Product Registration
    • For purchases made in the U.S.: Product Registration
    • For purchases made in Canada: Product Registration
    • Knowing more about who buys our grills helps the crew back in R&D come up with new cutting edge Weber products. Please fill in the answers you feel comfortable sharing with us, and pass by any question you prefer to leave blank.
    • Thank you for being so generous

14. Are you:

15. Male

16. Female

17. Are you married?

18. Yes

19. No

20. What’s your date of birth?

21. Including yourself, how many people live in your household?

22. Do you own or rent the place you call home?

23. Own

24. Rent

25. What’s your annual household income?

26. <$15,000 9.

27. $60,000-$74,999

28. $15,000-$24,999 10

29. $75,000-$99,999

30. $25,000-$29,999 11.

31. $100,000-$149,999

32. $30,000-$34,999 12.

33. $150,000-$174,999

34. $35,000-$39,999 13.

35. $175,000-$199,999

36. $40,000-$44,999 14.

37. $200,000-$249,999

38. $45,000-$49,999 15.

39. $250,000-$299,999

40. $50,000-$59,999 16. >

41. $300,000

42. Which activities or interests do you have that keep you (or your partner) busy?

43. Arts or antiques

44. Bicycling

45. Boating or sailing

46. Buying videos

47. Subscribing to cable TV

48. Camping or hiking

49. Attending cultural arts or events

50. Dieting

51. Donating to charity

52.  Fishing

53. Foreign travel

54. Gardening or plants

55. Golf

56. Grandchildren

57. Houseplants

58. Hunting

59. Motorcycles

60. Needlework

61. My cat

62. My dog

63. Listening to music on my CD player

64. Listening to music on any device

65. Personal computers

66. Photography

67. Physical fitness or exercise

68. Politics

69. Running

70. Shopping by mail order or catalog

71. Snow skiing

72. Stocks & bonds

73. Tennis

74. Veterans’ affairs

75. Walking

76. Watching sports on TV

77. Other

PLACE STICKER HERE
Serial number
©2007 Weber-Stephen Products Co. All rights reserved. Printed in U.S.A.

References

• gas.la
• gaz.La
• light.is
• Забота о животных
• place.si - This website is for sale! - place Resources and Information.
• position.is in parked
• The domain name Weber.LA is for sale
• Repair Your Grill: Shop Replacement Parts for 24,880 Models
• Weber Grill Parts - Select From 2037 Models

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>