GENERALAire MAC 1200 Mini Media Air Cleaner Instruction Manual
- July 30, 2024
- GeneralAire
Table of Contents
This Owner’s Manual is provided and hosted by Appliance Factory
Parts.
Appliance Factory Parts
Experts BBQ, Humidifier , & Appliance Parts
1-800-955-7075
Shop genuine replacement parts for GENERAL
1200
MAC 1200 Mini Media Air Cleaner
Find Your GENERAL Air Cleaner Parts – Select From 69
Models
——– Manual continues below ——–
INSTALLER: PLEASE FILL OUT AND MAIL GUARANTEE CARD AFTER INSTALLATION IS
COMPLETE. LEAVE INSTALLATION INSTRUCTIONS WITH HOME OWNER
This air cleaner is designed for use in systems up to 1200 CFM. For higher
airflows additional unitsmay be required. See Typical Installations below.
MINI MAC 1200 MEDIA AIR CLEANER
FOR INSTALLATION IN THE RETURN AIR DUCT OF ANY FORCED AIR HEATING AND COOLING
SYSTEM
INSTALLATION INSTRUCTIONS
IMPORTANT: A 26 INCH CLEARANCE MUST BE ALLOWED FOR REMOVAL OF THE MEDIA CARTRIDGE FROM THE CABINET.
- Turn off electricity to furnace.
- Remove front cover.
- Slide media cartridge from air cleaner cabinet, and discard packing material.
- Remove and discard existing furnace air filter.
- Install cabinet in return air system. Properly install airflow direction arrows on interior of cabinet. Duct supports are recommended to support weight of cabinet. See typical installations.
- Slide the media cartridge into the cabinet. Be sure the airflow arrow on the cartridge is in the same direction as the arrow in the cabinet. The wire mesh is always on the downstream side of the filter media. Replace cover.
- If a condition indicator is to be used, install on a vertical duct surface between the air cleaner and the furnace blower.
- Turn on electricity and furnace and check performance of all equipment.
FILL OUT AND MAIL THIS WARRANTY CARD AND LITERATURE REQUEST FORM
HEPA AIR CLEANER
UV AIR PURIFIERS
ELITE STEAM HUMIDIFIERS
ELECTRONIC TEMPERATURE COMPENSATING HUMIDISTAT
HIGH EFFICIENCY AIR CLEANERS
HUMIDIFIERS
AIR FILTER GAGE
FUEL OIL FILTERS AND ACCESSORIES
MAINTENANCE
The Air Cleaner Media 14164 will normally need to be replaced every 4 to 6 months (end of the heating or cooling season) with normal usage. If an air cleaner condition indicator is used, change the media when the device indicates that service is required. Additionally, the frequency of filter replacement can be determined by visual examination.
PARTS LIST
PRESSURE DROP SCHEDULE
| CFM | IN W.C. |
|---|---|
| 600 | 0.05 |
| 800 | 0.08 |
| 1000 | 0.12 |
| 1200 | 0.16 |
LIMITED WARRANTY
This air cleaner, if properly registered by the return of the attached
warranty registration card to the manufacturer, is warranted to the consumer
against defects in materials and workmanship for a period of two years from
the date of installation. The air cleaner media is not covered by this limited
warranty or any other warranties.
Any other defective parts will be repaired without charge except f or removal,
reinstallation and transportation costs. To obtain repair service under this
limited warranty, the consumer must send t he defective part or the complete
unit to the manufacturer.
THERE ARE NO EXPRESS WARRANTIES C OVERING THIS AIR CLEANER O THER THAN A S SET
FORTH ABOVE, THE IMPLIED WARRANTIES O F MERCHANTABILITY A ND FITNESS FOR A
PARTICULAR PURPOSE ARE LIMITED IN DURATION TO TWO YEARS.
THE MANUFACTURER ASSUMES NO LIABILITY IN CONNECTION WITH THE INSTALLATION OR
USE OF THIS PRODUCT, EXCEPT AS STATED IN THIS LIMITED WARRANTY. THE
MANUFACTURER WILL IN NO EVENT BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL
DAMAGES.
This limited warranty gives you specific legal rights, and you may also have
other rights which vary from state to state. Some states do not allow either
limitations on implied warranties, or exclusions from incidental or
consequential damages, so the above exclusion and limitation may not apply to
you. Any questions pertaining to t his limited warranty should be addressed to
the manufacturer. (U.S.A.: The manufacturer has elected not to m ake available
the informal dispute settlement mechanism which is specified in the Magnuson-
Moss Warranty Act.)
GENERAL FILTERS, INC.
43800 GRAND RIVER AVE.
NOVI, MICHIGAN 48375-1115
WWW.GENERALAIRE.COM
CANADIAN GENERAL FILTERS, LTD.
39 CROCKFORD BLVD.
SCARBOROUGH, ONTARIO M1R3B7
WWW.CGFPRODUCTS.COM
OWNER FILL IN REGISTRATION AND MAIL TO:
GENERAL FILTERS, INC. 43800 GRAND RIVER AVE NOVI, MI 48375-1115
WARRANTY REGISTRATION
MODEL MAC-1200 Media Air Cleaner
OWNER’S NAME……………………………………..
STREET ADDRESS……………………………
CITY………………………….
STATE………………………………………….
POSTEL CODE ……………………………
DEALER’S NAME…………………………..
STREET ADDRESS …………………….
CITY………………………….
STATE………………………………………….
References
- Repair Your Grill: Shop Replacement Parts for 24,880 Models
- General Air Cleaner Parts - Select From 69 Models
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>