Eloflex F Electric Wheelchair Instruction Manual
- June 6, 2024
- Eloflex
Table of Contents
F Electric Wheelchair
INSTRUCTION MANUAL FOR USE, DRIVING AND SAFETY
Read this documentation before using your Eloflex to make sure that you use it
in a manner that is safe, and which does not harm you,
your environment or your power wheelchair.
Eloflex
Thanks and good luck!
Thank you for choosing an Eloflex as your power wheelchair. It means a lot to
us because our vision is to make people’s everyday life a little easier and to
give people with disabilities a greater freedom. We hope you experience both
with the help of your Eloflex.
We believe that you will enjoy much of your new power wheelchair. This manual
contains important information on safety, use and care. We encourage you to
read through this entire documentation before using your Eloflex for the first
time. We also suggest that you train to run your Eloflex on a secluded, open
and level surface before using it in other contexts. Eloflex power wheelchair
is designed for users with many different needs. Decide whether Eloflex is
suitable for the user is always taken by the ordinator or dealer together with
the user himself. Eloflex accepts no responsibility for cases where the power
wheelchair is not adapted to the user’s needs.
An Eloflex should primarily be used in its standard design. If the power
wheelchair has to be adapted or altered in any way, it must only be carried
out by your assistant center or by Eloflex. Please note that damages and
faults caused by non-compliance with the operating instructions or due to poor
maintenance are not covered by the warranty.
Good luck and great joy with your Eloflex.
Drive carefully!
Content
Page
Intended use
3
Folding
4-5
Install the joystick
6
Charging instructions
6
Change the seat width
7
Manual driving
7
Anti-tip device
7
Joystick
8
The Footrest
9
The Backrest
10
The Armrest
11
Disassemble & assemble – model D2 12
Fold joystick
13
Raise & lower seat – model P
13
Transport & storage
14
Accessories
15
Driving
16-17
Safety
18-19
Technical specifications
20
Contact
20
2
Intended use
Type classification and intended use
Eloflex power wheelchairs have been developed for people who have difficulty
walking or cannot walk at all, but who have vision ability, physical ability
and mental ability to control an power wheelchair.
The Eloflex power wheelchair is sufficiently compact and flexible for indoor
use, but the chair is also suitable for outdoor use. The chapter “Technical
data” at the back of this document contains information on speed, turning
radius, range, maximum lifting capacity and maximum weight for the user and so
on. We encourage you to read all safety information in the chapter “Safety” in
this document.
Eloflex is tested and approved according to EN12184: 2014 – class B (indoor
and outdoor use). Eloflex is also approved according to ISO-7176, IEC60601 and
the batteries are approved according to UN38.3
Eloflex power wheelchairs meet the applicable requirements of the EU
Regulation (2017/745), the Medical Device Regulation (MDR), which ensures the
safety and performance of medical devices..
Class 1 conformity assessment / CE marking has been issued in accordance with
the Medical Directive 93/42 EEG / MPG (Medical Devices Act) and applies only
to the complete product. The CE marking will be void if you use replacement
components or accessories that have not been approved for this product.
Needs
The purpose of an Eloflex power wheelchair is to compensate for an injury or
disability, which is why it is recommended in the following circumstances: ·
If the user has the inability to walk or very limited ability to walk, which
makes it difficult to move in his / her own home. · If there is a need to
leave the home to get out or to visit places that are normally visited in
order to carry out everyday affairs. · When the user has difficulty getting
to, or performing work or activities because of his / her mobility
disabilities. It is advisable to use Eloflex power wheelchairs both indoors
and outdoors, if it is not possible to use hand-operated wheelchairs due to
mobility problems, but it is still possible to properly handle power
wheelchairs.
Accessories
Chargers and bag with simpler tools are available when delivered in the
storage bag under the seat.
Utility
Only use the Eloflex power wheelchair when fully functional. Otherwise you put
yourself and others at risk. The following list does not include all possible
situations. It describes only certain situations that may affect the usability
of the power wheelchair. · Do not use the power wheelchair if the batteries
are
defective or deformed · Do not use the power wheelchair if the engine is jerky
or makes abnormal noise · Do not use the power wheelchair if the brake
function appears to be wrong · If your tires are worn, contact your assistant
center or dealer · If you notice any damage to the seat belt, armrest, seat,
backrest, joystick or other part of the chair, contact your assistant center
or dealer. · If you notice any damage to the electrical system (cables,
batteries, chargers, etc.), please contact your assistant center or dealer
Warranty
You always have a two-year warranty on your Eloflex power wheelchair. The
warranty conditions are in line with the applicable national and general terms
and conditions and rules and regulations. The detailed warranty conditions can
be downloaded at www.eloflex.eu. Note that you should save the original carton
for your Eloflex during the warranty period (the carton can be folded together
and set aside).
Life span
The estimated lifetime of an Eloflex is 5 years. However, the life of the
product is largely affected by how it is used and managed. An Eloflex can have
a much longer life if you take care of it in a good way and only use it in
line with the information in this document.
Safety regulations and risks
PLEASE READ THE SAFETY INSTRUCTIONS FROM THE PAGE 16 BEFORE YOU USE YOUR
ELOFLEX.
3
Folding
Fold up
Step 1
Place the folded chair on the ground as shown on the right. Grasp the backrest
and pull upwards to open the chair. Hold on with one hand on the seat cushion.
Step 2
Close the lock – this is very important!
Collapse
Step 1
Open the lock as shown in the pictures to the right.
Step 2
Put one hand on the front of the seat cushion. Grasp the top of the backrest
with the other hand and fold it forward. Push the chair together according to
the pictures on the right.
F P D2 L H
“Klick”
It is very important that you close the lock before using the power wheelchair.
4
Folding
Fold up
Stand behind the chair and push the seat edges downwards.
Fold
Stand behind the chair and lift the seat edges upward.
Fold the backrest
You can fold the upper part of the backrest during transport by pressing the
two locking buttons and folding the backrest backwards.
X
5
Install the joystick
Step 1
Mount the joystick in the tube under the armrest and tighten the screw in the
desired position.
F P D2 L H X
Step 2
Assemble the cable connectors and gently rotate until the pins enter the holes
and the grooves in the two connectors engage. Then screw the sleeves together
on each contact.
IMPORTANT!
Be careful not to damageor bend the pins in the connector.
Charging instructions F P D2 L H X
This is how you charge
Start by turning off your Eloflex (all lights on the joystick should be off).
Connect the charger to the socket on the front of the joystick. Make sure that
the contacts’ position matches each other. Then plug the charger’s power cable
into a wall outlet.
Charging is indicated by a lamp on the charger. Red lamp means that charging
is in progress. After about three hours, the batteries are charged at 90
percent. The chair can now be used again.
After about 5-8 hours, the light on the charger becomes green and the
batteries are fully charged. During charging, the charger itself becomes warm,
and this is normal. For maximum battery life, charging. Charging instructions
should take place for about five hours when 6
the bar on the battery indicator at the joystick has dropped to one third
(when three of the lights are green).
The batteries will not be damaged by maintenance charges but for maximum
battery lifespan we recommend that you disconnect the charger when the
batteries are fully charged. Charging the batteries can be done
IMPORTANT! NEVER connect the charger directly to the battery.
down to -10 degrees. When charging in lower temperatures, the batteries will
not get fully charged.
If your Eloflex is used in minus degrees, the mileage is affected. For
example, at -10 degrees, the mileage can be reduced by up to 50 %.
Change the seat width F P D2 L H X
You can increase the seat width by moving out the armrests using the widening
kit. You can choose to increase the seat width by 5 or 10 cm.
Step 1
Loosen the armrests on each side by unscrewing its two brackets.
Step 2
Fit the widening sleeve between the chair and the armrest. Reinstall the
armrests.
You buy the widening kit where you bought your Eloflex.
Manual driving
2 1
F P D2 L H X
Turn off the power wheelchair with the joystick. Then push the red levers on
the motors (see picture) to disconnect the magnetic brakes. In this position,
the chair can be rolled manually.
Note! If the user uses the chair without assistance, the magnetic lock of the
chair must always be switched on.
ON OFF
IMPORTANT!
NEVER kick on the red levers with your foot. Only use your hands.
Anti-tip device
F P D2 L H X
For safe driving, the anti-tip devices must always be in their outer position.
1. Loosen the thumbscrew.
2. Pull out the anti-tip device.
3. Tighten the thumbscrew.
NOTE! The anti-tip devices must always be extended when using the chair.
2 1
7
Joystick
Battery status Reduce speed Joystick
F P D2 L H X
1
Power on and off Increase speed
2
Horn
USB connector
TIP: Use the USB connector on the underside of the joystick to charge your
mobile phone.
Joystick: Controls the chair’s speed and direction.
Power on and off: Press to turn your Eloflex on and off.
Horn: Press to call attention.
8
Increase speed: Press to increase the chair’s maximum speed.
Minska hastigheten: Press to reduce the chair’s maximum speed.
1 Battery status: This indicates how much power is left in the batteries. When
the batteries are fully charged, all the lights illuminate. As the batteries
are emptied, the lights go out in turn. Charge when two-thirds of the lights
go out.
2 Speed indicator: All bars light = max speed.
Footrest
F P D2 L H
For easier entry and exit, the footrest can be folded up as shown down below.
Adjust the footrest
You can change the height of the footrest in two fixed positions.
Remove the black plastic cover from the four nuts. (1)
Tighten the retaining screws while holding the nut. (2)
Refit the footrest in the other mounting hole. If the footrest does not remain
in the raised position, you can adjust the inertia of the footrest by
tightening the fixing screws (2).
Footrest
Fold up the footrests
For easier entry and exit, the footrests can be folded up as shown on the
right.
Fold out the footrests
The footrests can also be folded aside by loosening the lock on the inside.
Remove the footrests
You can remove the entire footrest from the chair by lifting it upwards when
it is in out folded position.
2 1
X
9
Backrest
Adjust the height
You can steplessly adjust the height of the backrest. 1. Loosen the knobs
behind the backrest 2. Pull up the backrest to the desired height. 3. Tighten
the lock knobs. 4. If necessary, adjust the backrest cover to
the desired position.
Adjust the backrest
Adjust the inclination of the backrest by loosening the adjusting bolts and
positioning the backrest in an angled position that feels comfortable. You can
choose between 2, 11 and 22 degree angles.
Adjust the backrest
Adjust the angle
You can set the backrest slope in three different positions.
Do this
1. The locking pins for the backrest
angle can be found at the bottom
1
behinde the backrest.
2. Pull out the pins and change the angle to the desired position.
3. Make sure the lock pins are in their internal position before using the chair. (See picture)
3
10
F P D2 L H
X
2 Adjust the back
Fold up the trim of the back by pulling it. Tighten the Velcro straps for a
comfortable sitting position. Then fold the trim down and press lightly so
that it gets stuck in the Velcro strips.
Lift the armrests
To lift the armrests up and down, first loosen the lock by turning the locking
lever half a turn. Then lift the armrests.
It is important that you lock the armrests when you fold them down again by
turning the lock lever back half a turn.
Lift the armrests
You can fold up the armrest to facilitate getting in and out of the chair.
Press the lock button and then fold the armrest upwards.
IMPORTANT! Always keep both armrests folded down when traveling in the chair.
Adjust the armrests
For optimal seating comfort, you can adjust the height of the armrests. 1.
First release the lock by lifting the lock lever. 2. Then raise or lower the
armrests to the desired height. 3. Lower the locking lever.
F P D2 L
OPEN LOCKED
X
PUSH LIFT
H
11
Disassemble and assemble
Dissemble
1
Step 1
Fold the chair and put it upright. Make sure that the anti-tip devices are
facing forward when you raise the chair so that the lower part can stand on
its own.
Step 2
Push down the handle of the locking mechanism while lifting the upper part off
the lower part. The upper part then stands firmly with the help of the locking
hook.
2
Assemble
Step 1
Lift the upper part and place it in the
correct position using the guide rails on
the lower part. The locking mechanism
will lock automatically.
The connector is connected when
1
docking the upper part.
Step 2
Fold up the chair again. It is important that you close the locking hook
before starting the power wheelchair and using it.
12
D2
Fold down the joystick
The smart joystick mount allows the user to quickly lower the joystick without
removing it. This means that you get closer to the edge of the table, which
gives a better sitting position. 1. Lift the lock lever to release the
joystick. 2. Gently pull the joystick forward. Then let the joystick hang
straight down.
Raise and lower the seat
You can raise the seat and at the same time tilt it forward for easier getting in and out.
Raise the seat
1. Make sure the wheelchair is in the 2
1
locked position and that the power is on.
2. Fold up the footrest.
3. Put both feet on the ground
4. Press and hold down the plus
button (arrow 1) on the joystick.
5. Release the button when the desired height has been reached.
Lower the seat
1. Make sure you are sitting firmly and in the middle of the seat. 2. Press
and hold the minus button
(arrow 2) on the joysticken 3. Release the button when the seat is at the
bottom of its basic position.
IMPORTANT! Never drive
the chair with the seat raised.
P D2 H P
13
Transport and storage
· To lift the chair, it is recommended that the chair is first folded. · A
folded chair can be put in the luggage of a car or set in a
wardrobe. · If the chair is not to be used for a while, we recommend that
the batteries be fully charged before the chair is set aside. · The chair
should be stored indoors in frost-free, dry and
ventilated areas. Storage temperature 0-30 degrees. · When transporting by bus
or by handicap transportation, the
Eloflex must be attached to the fastening points shown in the pictures at the
bottom. Note that Eloflex is not tested as a car seat. We therefore always
recommend that the user moves over to the car’s own seats.
14
Accessories
You can make your Eloflex even smarter and adapt it to your own, individual
needs with our accessories. We are constantly developing new accessories.
ELOFLEX HEADREST The headrest makes your Eloflex more
personalized and useful, even for those requiring a little extra support for
the head and neck.
ELOFLEX ATTENDANT CONTROL With one of our attendant controls, the person
behind can easily drive the power wheelchair without using
muscle power.
ELOFLEX PREMIUM CUSHIONS With one of our premium cushions, you can further
adjust your seating comfort. We have both thicker and
air-filled cushions.
ELOFLEX COVER When you want to be a little extra
careful with your Eloflex when transporting, when you check in on the flight
or load the wheelchair in the car.
ELOFLEX RAMPS Easily load your Eloflex into the car with the help of load
ramps that are
collapsible and easy to lift.
ELOFLEX GEL-FILLED WHEELS Our gel-filled wheels provide extra comfort when
driving on uneven surfaces and you never have to worry
about getting a puncture.
ELOFLEX ADJUSTABLE LEG RESTS The adjustable leg rests individually
adapt your Eloflex. We also have extensions to the standard footplate.
ELOFLEX SIDE BAG Eloflex side bag gives you the opportunity to securely store
things
you need close at hand.
ELOFLEX JOYSTICK EXTENSION The joystick extension allows tall users to sit
comfortably with the arm when
driving the Eloflex.
15
DRIVING
Safety instructions when driving
There is a risk of injury by tipping the wheelchair. · Only drive in inclines
that do not exceed the maximum allowable slope · Always use anti-tippers when
traveling with Eloflex · Driving downhill should always be done at a lower
speed · Avoid areas where there is a risk of icy or slippery surfaces · Never
try to drive up or down stairs with your power wheelchair · Never drive over
obstacles higher than the recommended maximum height · Avoid rapid movements
with the joystick and sudden changes in driving direction while driving
Risk of being stuck in remote places. · A user with greatly reduced mobility
should not drive longer distances outdoors alone
Risk of injury if one foot slips off the footrest and falls under the powered
wheelchair while driving. · Always place your feet in the middle of the
footrest while driving
Risk of injury if you collide with other objects in narrow passages. · Drive
through narrow passages with the lowest speed and greatest attention
There is a risk that the wheelchair will tip over if the anti-tip devices are
removed, damaged or mounted at a position that deviates from the standard
mounting. · The anti-tip devices must always be mounted when the power
wheelchair is used · The anti-tip devices only work on a solid surface. On
soft surfaces such as lawns and snow, the anti-tip device can lose its effect.
Therefore, drive extremely carefully on soft surfaces.
16
Driving
Read
The user must read these safety and driving instructions before using the
Eloflex power wheelchair.
Practice
Practice makes perfect. Train to drive your Eloflex together with an assistant
by starting on an open plan surface, preferably outdoors, before using your
power wheelchair among other people, in stores or restaurants etc. · Move
forward by moving the joystick slowly forward. · Stop by releasing the
joystick.
Reverse
Reverse by moving the joystick slowly backwards. To stop, release the
joystick. Remember to always look backwards before you start reversing to be
sure that no person or thing is in the way.
Spin
Spin by moving the joystick gently sideways. Take care so nothing is in the
way of the sides when you spin.
Turn
Turn as you drive by gently moving the joystick sideways in the same direction
you want to turn. Always lower the speed when turning.
Obstacle
Practice avoiding and passing obstacles. Move the joystick sideways while
driving forward to avoid obstacles. Remember to lower the speed as you
approach obstacles.
Fast driving
Fast driving: Press the joystick in the forward position if you want to drive
fast. Remember to retract the joystick and lower the speed as soon as you feel
insecure, whether you are turning or approaching an obstacle
Run over obstacles
Run over obstacles: Drive slowly to the obstacle and make sure the front
wheels are in the direction of travel. Then move the joystick slowly forward
while leaning backwards to drive over the obstacles Eloflex is tested and
approved for ob stacles up to a maximum of 6 cm.
Run on slope
Driving on slopes: Try driving straight up or down for an inclined surface.
Lean slightly forward as you drive up, and backwards as you drive down, to
maintain the center of gravity. Avoid driving sideways if possible and
compensate for any side slope by leaning in the opposite direction. Always
drive slowly on slopes. Avoid surfaces that tilt more than 9 degrees.
Elevators
Using the elevator: Remember to check the width of the elevator door and how
quickly the door is closed before you enter the lift. Keep in mind that you
may have to reverse out of the lift if it is not large enough to allow you to
turn around
Driving on the road
Driving on the road: Drive primarily on sidewalks, walkways and cycle paths
and, ultimately, on busy roadways with your Eloflex..
Cross the roadway
Crossing the roadway: if possible, always choose to cross the road at a
pedestrian crossing. Pay attention to intersecting cars. Use chamfered part of
the pavement if available. Avoid curbs higher than 6 cm.
17
SAFETY
General safety instructions
There is a risk of personal injury if the power wheelchair is used for
purposes other than those described in this document. · Use the power
wheelchair only according to the instructions in this manual (see above,
chapter “Type classification and intended use”)
There is a risk of personal injury if the power wheelchair is used for reduced
driving ability. · Do not use the wheelchair when your driving skills are
impaired due to, for example, illness, medication or alcohol.
There is a risk of injury if the power wheelchair is involuntarily moved. ·
Switch off the wheelchair before boarding and exiting or if there is a risk
that you, another person or an object could come in contact with the joystick.
· When the motors are disengaged, the brakes do not work. Therefore, the
wheelchair must only be pushed on flat ground, never on slopes. Never leave
the wheelchair in or near slopes with disengaged motors.
There is a risk of personal injury if the powered wheelchair is switched off
during travel with, for example, the on / off button or by tearing off a
cable, as it stops with a hard jerk. · Release the joystick when braking in an
emergency. Then the wheelchair stops automatically.
There is a risk of injury due to falls from the wheelchair · Do not move
forward, do not bend forward between the knees and do not lean over the
wheelchair edge, for example to reach objects. · Always use a seat belt and
re-adjust it before each trip. · Drive as close to the new seat as possible
when transferring to another seat.
There is a risk of personal injury if the maximum permissible load is
exceeded. · Observe the maximum permissible load (see chapter “Technical data”
at the back of this document). · The power wheelchair may only be used by a
single person. Never use the wheelchair to transport more than one person at a
time.
There is a risk of personal injury and damage to the wheelchair if the lock is
released when folding is not properly clamped when the power wheelchair is
used. · If the power wheelchair’s lock has not clicked into place properly,
the chair can suddenly collapse when used, which can cause you to fall out of
the wheelchair. · Always ensure that the locking hook is in a correct position
before using the power wheelchair. There is a risk of personal injury and
crushing damage when folding the wheelchair. · Always fold and raise the power
wheelchair as described in the operating instructions. · Pay attention so that
none or nothing is squeezed when folding and unfolding.
There is a risk of personal injury and damage to the wheelchair if it is used
in damp areas. · The power wheelchair must not be used during showering. · The
power wheelchair must not be used when bathing.
18
Safety
Crossing railway tracks
Always cross the railway track straight from the front, never obliquely from
the side. Never cross the railway tracks alone, always have someone with you
who can help you.
Sharp edges
Be careful when driving on steep slopes, as the chair is likely to break.
Eloflex is tested and approved for gradient with a maximum of 9 degrees.
Always have someone with you who can help you.
High edges
Be careful when driving up or out for an edge. Eloflex is tested and approved
for edges up to a maximum of 6 cm. Always have someone with you who can help
you.
Transfer
We recommend that you always have someone who can help you with transfers to
and from your Eloflex. Always turn off the power before starting the movement.
Always lift up the armrests and footrest before moving to make getting in and
out of the chair easier.
Don’r repair on your own
Never try to repair a broken power wheelchair on your own. If you try to
repair the chair yourself, the warranty does not apply. Always turn to Eloflex
or to the shop or assistant center that sold / prescribed the chair. Never
modify your power wheelchair on your own.
No toy
Never allow children who do not normally use an power wheelchair to sit on or
use your Eloflex
Cleaning
Never clean your Eloflex with running water. Only wipe it with a damp cloth.
If your Eloflex is slow to fold up and together, you can lubricate the joints
with oil or silicone spray
Beware of heat
Never leave your Eloflex in direct sunlight or near a heat source as the
batteries may be damaged. Never be near open fire with your Eloflex. You can
use your Eloflex from -10 degrees up to +45 degrees. At freezing temperatures,
the range can be affected.
Storage
Keep your Eloflex out of the reach of children when not in use. The chair
should be stored indoors in frost-free, dry and ventilated areas. Storage
temperature 0-30 degrees.
The charger
The charger must never be covered when used to charge your Eloflex. The
charger becomes hot and there is a risk of accident or injury.
Batteries
Never store the batteries in direct sunlight or in a location that can reach
below zero temperatures. The batteries should be stored in a dry and
ventilated place.
19
Technical specifications
MODEL
F
X
D2
P
H
L
Weight
26 kg
28 kg
16+17 kg
28 kg
38 kg
26 kg
Range
30 km
25 km
30 km
30 km
40 km
30 km
Max load
120 kg
120 kg
160 kg
160 kg
200 kg
120 kg
Speed
6,5 km/h
6,5 km/h
6,5 km/h
6,5 km/h
8 km/h
6,5 km/h
Battery
2 x Lithium ION 2 x Lithium ION 2 x Lithium ION 2 x Lithium ION 2 x Lithium ION 2 x Lithium ION
10AH/24V
7,5AH/24V
10AH/24V
10AH/24V
20AH/24V
10AH/24V
Turning radiation
78 cm
88 cm
89 cm
85 cm
99 cm
76 cm
Wheels Front Rear
8″ solid 12″ air
8″ solid 12″ air
8″ solid 12″ air
8″ solid 12″ air
9″ air 13″ air
8″ solid 10″ solid
Seat height
52 cm
51 cm
50 cm
54 cm
54 cm
52 cm
Seat width
45 / 50 / 55 cm 45 / 50 / 55 cm 45 / 50 / 55 cm 45 / 50 / 55 cm
51 cm
45 / 50 / 55 cm
Seat depth
43-48 cm
43-48 cm
44-47 cm
43-48 cm
51 cm
43-48 cm
Size
95 x 63 x 100 cm 100 x 62 x 102 cm 96x62x107 cm 90 x 62 x 107 cm 103 x 66 x 115 cm 95x59x99 cm
Size folded
75 x 63 x 40 cm 76 x 32 x 78 cm 76x62x50 cm 74 x 62 x 40 cm 83 x 66 x 45 cm 70x59x35 cm
© Copyright Eloflex
This document contains copyrighted information and may not be copied or
reproduced in whole or in part without the written permission of Eloflex.
Eloflex is reserved for any typographical errors in this document and we
reserve the right to product changes.
Contact Eloflex
If you have any questions or need help, please contact your help center or
dealer. If you want direct contact with us, you will find contact information
on our website, www.eloflex.eu.
Sungo Europe B.V. Olympisch Stadion 24, 1076DE Amsterdam, Netherlands SRN:NL- AR-000000247 Kunshan Aoshida Electric Technology Co., Ltd No. 108 Matang Road, Penglang Town, Development Zone, Kunshan City, Jiangsu