JAMARA 406301 Mercedes Benz Arocs 1 20 Metal Meiller 2.4GHz Dump Truck Instructions

: June 5, 2024
: JAMARA

Table of Contents

Components
Spare parts
Insert the batteries
Binding process
Safety Notes
Service center
References
Read User Manual Online (PDF format)
Download This Manual (PDF format)

JAMARA 406301 Mercedes Benz Arocs 1 20 Metal Meiller 2.4GHz Dump Truck Instructions

General information

JAMARA e.K. is not liable for any damage caused to the product itself or through this, provided this is due to improper operation or handling errors. The Customer alone bears the full responsibility for the proper use and handling, including without limitation, the assembly, the charging process, the use and choice of the operation area. Please refer to the operating and user instructions, it contains important information and warnings.

Not suitable for persons under 14 years!

For model building only – Not a toy!
Read the instructions carefully before using the product and keep them for future reference.
Charge before use! Avoid deep discharge!

Certificate of Conformity

Hereby JAMARA e.K. declares that the product „Muldenkipper Mercedes-Benz Arocs Metal Meiller, No.406301“ complies with Directive 2014/53/EU, 2011/65/EU. The full text of the EU Declaration of Conformity is available at the following Internet address:www.jamara-shop.com/Conformity

Read the complete instructions and security instructions carefully before using the model.
Caution! Please fully and carefully read warnings/ safety instructions. These are for your own security and can avoid accidents/injuries.

Attention!
Before operating:
First switch on the model and then the transmitter.

In case several models are used at the same time first switch on
the model and then the appropriate transmitter. Do not switch
on several models or transmitters at the same time as multiple
models could react to the same transmitter.

When finished:
First switch off the model then the transmitter.

Never operate your model beyond sight. Both the maximum visibility as well as the max. range of your model will depend on many factors such as weather, location and interfering frequencies. Therefore, before each use perform a range test with a second person securely holding the model and also check how the model reacts if there is a signal failure e.g. when empty transmitter batteries are installed.

Components

Transmitter:

Forward/reverse
Left/right
Trim left (Fine adjustment)
Trim right (Fine adjustment)
Motorsound on/off
LED Light on/off
Horn
LED signal light on/off
Dump lift
Dump lower
Start Key
ON/OFF Switch
Battery compartment
Modell:
ON/OFF Switch
Battery compartment

Spare parts

| No. 413393
Battery
---|---
| No. 413394
Charger
| No. 413391
Remote control

Insert the batteries

Transmitter

Remove the battery compartment cover.
Fit the 3 x AA batteries, observe the correct polarity.
Replace the battery hatch

Car

Charging the battery

Plug the USB cable into your USB jack of your PC and plug the battery pack into it. LED lights up.
Connect the drive battery to the charger. LED flashes.
Battery fully charged. LED goes out.
The charging time by completely dischar ged battery pack about 3 hours.

Battery warning:

Non-rechargeable batteries are not to be recharged! Do not open!
Do not dispose of in fire!
Do not mix old and new batteries!
Do not mix alkaline batteries, standard (carbon-zinc) or rechargeable batteries!
Rechargeable batteries are to be removed from the toy before being charged!
Rechargeable batteries are only to
be charged under adult supervision!
The supply terminals are not to be short-circuited!

Danger

Always disconnect the battery from the charger immediately after charging. Always disconnect the charger from the power supply immediately after disconnecting the battery.
Inserting the rechargeable battery or charger after charging will result in damage to the battery, charger or the power supply (fire hazard).

Danger

If your model has an on/ off switch, always turn off the model immediately after each use. If your model has a removable battery or a disconnectable connector to the battery, the battery should be disconnected from the model immediately after each use. The battery can be deep-discharged by accidentally turning it on or by leaving the battery plugged in. By deep discharge the battery it loses power, can be damaged so much that charging or discharging is no longer possible and the battery can ignite itself during charging or discharging (fire hazard). Never attempt to charge or discharge deep-discharge batteries. The voltage of the battery should never be under 6 Volt to avoid a deep discharge. The fully charged battery has a voltage of 8,2 Volt.. After usage, the intact battery has to be fully charged after a cooling phase of at least 10 min but not longer than 12 hrs. This is to avoid a deep discharge caused by a self-discharge. When not using or storing the battery it has to be checked at least every three months for voltage (min. 7,8 Volt) or damage and if necessary charged or disposed.

Binding process

First, insert batteries into the transmitter, the LED starts to blink. Now turn on the model. If the binding is successful, the LED on the transmitter stops flashing. When operating multiple models, make sure that you have the right binding. Always connect one model after another.

Safety precausions for Lithium battery

Because of the high power compactivity (up to 150 Wh/kg) the cells are quite dangerous and need special care! The company Jamara excludes explicitly, all types of liability for damages, that can occure when using the Lithium- Polymer-Cells indequate.

When using the battery incorrect there is a risk of getting fire or acid-injuries.
Overcharging, too high power, or discharging at low level destroys the cell.
Protect from mechanical stress (squeezing, pushing, bending, drilling).
Never open or cut batteries, do not throw into fire, keep away from children.
Handle damaged or leaking battery with care. Injuries or damages to the product can occure.
Under no circumstance short-circuit the device and always watch out for correct polarity.
Protect batteries from heat above 65 °C , mount away from hot objects (for example exhaust pipe).
Before storing batteries (for example in the winter) charge the battery. Do not store in fully charged or in non charged state!
The contents of the cell is harmfull for skin and eye.
If the content comes into contact with skin, clean with plenty of water and take off moisted clothes.
If the content comes into contact with the eyes, clean with plenty of water and consult a doctor.

If the cell overheats, swells, burns or smoke is coming from it, do not touch it under any circumstances. Keep away in a safe distance and prepare adequate extinguishing agents such (No water explosion, well dry sand, fire extinguishers, fire blanket, salt water).

Safety precausions

Safety Notes

Keep hands away from moving parts
Keep away from Children. Contains small parts which can be swallowed.
The batteries are nearly empty, replace the batteries.
Pay attention to the polarity

Safety Notes

Pay attention to the frequencies in your environment!
Do not drive in rain, snow, wetness or sand.
Never drive on roads or areas used by real vehicles.
Never run out of the reach of your remote control.

Safety Notes

Do not leave in very strong sunlight.
Clean by using a damp cloth.
Store batteries/battery packs separately when not in use.

Disposal restrictions

Batteries and accumulators must not be disposed of in domestic waste. You are obliged to dispose of batteries (seperate collection) appropriately. After use you can return batteries free of charge to the retail store. As batteries contain substances that can be irritant, can cause allergy and are highly reactive, separate collections and proper recycling is important to the environment and to your health. If the batteries are marked with a chemical symbol Hg, Cd or Pb below the crossed-out waste bin on wheels it refers to that more than 0.0005% of mercury (Hg), more than 0.002% of cadmium (Cd) or more than 0.004% Lead (Pb) is included.

Disposal restrictions

Electrical appliances must not be disposed of in domestic waste and must be disposed of separately.
You are obliged to take out the batteries, if possible, and to dispose of the electrical equipment at the communal collection points. Should personal data be stored on the electrical appliance you must remove them by yourself.