Journey 8870 Comfy Wheels Scooter Instruction Manual

Journey 8870 Comfy Wheels Scooter

Product Information

Specifications

• Brand : ComfyWheels Scooter by Journey
• Type : Electric 3-wheel scooter
• Recommended Age : 16 years and above
• Charging Time: 6-8 hours for a full charge

Product Usage Instructions

Parts List and Assembly

1. Unpack the scooter and check all parts.
2. Assemble by connecting the tube clamp, bolts, nuts, and screws as per instructions.

Mounting Handle

1. Extend handlebar tube to upright position and insert into front forks.
2. Ensure handlebars face forward with brake on the left and throttle on the right.
3. Adjust handlebar height if needed using the quick release clip.

Foot Grip and Seat Installation

1. Install foot grips on each side of the scooter’s rear section.
2. Install seat cushion, tread, and fasten buttons.
3. Install seat lift pipe with the seat tube.

Charging Instructions

1. Charge battery fully before first ride.
2. Insert charger into the socket on the back of the battery box and plug into the wall.
3. Red light indicates charging, green light indicates full charge.

Vehicle Maintenance

1. Ensure battery is fully charged every 45-60 days if not using regularly.
2. Follow maintenance procedures before each ride for optimal performance.

INTRODUCTION AND NOTES

READ THIS MANUAL COMPLETELY BEFORE RIDING YOUR COMFYWHEELS SCOOTER.

Welcome to Journey Health & Lifestyle!
Thank you for purchasing a ComfyWheels Scooter by Journey. Our hope is that your electric 3-wheel scooter will get you where you’re going while you look good, feel good and have some fun! Please take the time to familiarize yourself with this product manual. Proper use of your 3-wheel scooter will maximize your performance and enjoyment.

SAFETY WARNING: THE COMFYWHEELS SCOOTER IS NOT A TOY AND SHOULD NOT BE OPERATED BY ANYONE UNDER 16 YEARS OLD.

Safety Instruction (Please take note of the following before each ride)

• Only one person at a time should ride
• Before riding be sure to check that all pivot points, locking buttons, quick releases, and latches are secured properly
• Do not place the battery near heat or fire
• Do not expose the charger to water or any moisture
• Check if battery is properly charged and installed
• Charge battery after each use
• Always ride on dry paved surface. Gravel, wet and uneven surfaces are a hazard. Avoid sand and loose impediments
• Do not exceed the speed you are comfortable with

INSTRUCTIONS FOR USE

PARTS LIST

• Charger
• Manual
• Seat
• Tool Kit
• Fuse
• Battery

ASSEMBLY

1. Step 1
   Unpack the ComfyWheels scooter and inspect all the parts to insure all are included. Please contact Journey Health & Lifestytle immediately if any parts are missing or damaged when shipped.

2. Step 2
   Remove the bolts and nuts from the connecting tube clamp. Place the connecting tube into the top opening. Align the bolt holes.

3. Step 3
   Slide the two bolts through the holes connecting tube and neck. Twist the bolts to secure.

4. Step 4
   Tighten bolts, nuts, and the six screws in the two corners using the wrench included in the free tool kit. MOUNTING HANDLE

5. Step 5
   Extend the handle bar tube to full upright position and insert it into the connection hole on the front forks.

6. Step 6
   Ensure the handle bars are facing forward, with the brake on the left and the throttle on the right. Then tighten the handle bar hex bolt securely. Fold the handlebar down to the left-hand side and tighten hex bolt.

7. Step 7
   The height of the handle bars can be adjusted by opening the quick clip release. Raise the handle bars by pulling or pushing on the crossbar, then firmly close the quick release clip. FOOT GRIP INSTALLATION

8. Step 8
   Install the foot grips by placing one on each side of the scooter’s rear section as shown below. SEAT INSTALLATION

9. Step 9
   Install the seat cushion and tread and fasten the buttons.

10. Step 10
    Then the seat lift pipe is installed with the seat tube. SEAT INSTALLATION

11. Step 11
    Install the basket, open the velcro, fix the iron shelf with velcro, and thread it on the front handle.

12. Step 12
    Connect the 3 waterproof power supply lines. Please ensure the pins are straight before connecting. (Pay attention to the position of the connector)

Charging matters
Please charge the battery completely before the first ride. To charge the battery, insert the charger into the socket on the back of the battery box (as shown), then plug the charger into the wall. When the battery is charging, the charger indicator light shows red, when the battery is full, the charger indicator light shows green.

Ensure that the charger is properly connected to the scooter.

WARNING :
TO ENSURE THAT THE BATTERY LIFE IS MAXIMIZED, PLEASE CHARGE IT AT A MINIMUM EVERY 2 MONTHS. WHEN THE BATTERY IS FULLY CHARGED, UNPLUG THE CHARGER.

Vehicle maintenance
Your ComfyWheels scooter requires maintenance to give you years of service. Always follow these simple procedures before your ride.

1. Make sure the battery is fully charged. It takes 6-8 hours to fully charge the battery.
2. The battery needs to be charged fully every 45-60 days if you are not charging consistently. If you allow the battery to die often within charge, it can hinder the battery performance.
3. Inspect all connections each time you ride to insure nothing is loose and wires are not frayed or damaged.
4. Please make sure tires are inflated to their proper pressure as indicated on the tires.
5. Test brakes before you accelerate to make sure they are properly used.
6. Don’t leave your scooter in the rain. It is not waterproof. Water damage will void the ComfyWheels warranty.

SPECIFICATIONS AND WARRANTY

Product Specifications

NOTE : Speed and distance may vary depending upon the terrain and weight load.

Warranty
Journey Health & Lifestyle warrants the ComfyWheels scooter frame, motor, controller, tires, throttle and brakes to be free from defects in materials, workmanship and assembly for twelve (12) months from the original purchase date. Journey Health & Lifestyle war-rants the ComfyWheels scooter battery to be free from defects for six (6) months from the original purchase date.

If you have any questions, call us at our toll-free number: 1-800-958-8324 or visit www.shopjourney.com

FAQ

Q: How often should I charge the battery?
A: It is recommended to charge the battery fully before the first ride and then at least every 45-60 days if not using regularly to ensure proper battery life.

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>