RugDoctor 1093575 Cordless Floor Cleaner User Manual

Cordless Floor
Cleaner User Manual
Please keep this user manual for
future reference
Model: 1093575

Important Safety Instructions

1.  Read all instructions and warnings before using this appliance. Failure to follow the warnings and instructions may result in electric shock, fire, or serious injury.
2. Please read this instruction manual carefully before use, properly save and store it for future use. This product is designed for home use. Do not use it for industrial and outdoor use.

Important Battery Information

1. Use only with: T-DC53H battery pack

2. If battery leakage occurs, there is sufficient protection and the shell is made from flame retardant material
   How to replace batteries

3. This appliance contains batteries that are only replaceable by skilled persons.
   How to deal with leaking batteries

4. Please contact Rug Doctor Customer Services UK on 01903 235558.

WARNING

1. Before use, the product checks whether the local voltage is consistent with the voltage marked on the power adaptor.
2. Inspect the product before use, and stop using if the product or adaptor is damaged.
3. Use only as described in this manual.
4. This appliance cannot be used by children and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge unless they have been given supervision or instruction concerning the use of the appliance in a safe way and understand the hazards involved.
5. Do not use this product as a toy. Keep this product away from the reach of children. Take care of children and make sure they do not regard this product as a toy.
6. Do not touch the plug with a wet hand.
7. Do not use or disassemble or replace any component if there is damage to the power cord, plug, battery, or conductive parts. Disassembly or replacement of the components by yourself may cause electric shock or fire. Rug Doctor will not take responsibility. Once damaged, the product needs to be repaired or replaced by Rug Doctor, Rug  Doctor’s distributor, or a qualified person designated by Rug Doctor to avoid injury.
8. Recharge only with the adaptor specified by Rug Doctor.
9. Only to use the battery pack specified by Rug Doctor. Use of any other battery pack may cause an explosion, injury, and or product damage.
10. If the product does not operate in accordance with the instructions, is seriously impacted, falls from a height, is damaged, or falls into the water, do not use it and contact Rug Doctor.
11. Only use Cordless Floor Cleaner specified replacement parts or attachments. Rug Doctor will not take responsibility.
12. Do not use or disassemble or replace any component if there is damage to the power cord or plug. Once damaged, the product needs to be repaired or replaced by Rug  Doctor, Rug Doctor’s distributor, or a qualified person designated by Rug Doctor to avoid injury.
13. Do not drag the cord or carry the cord to move the product, or use the cord as a handle.
14. Do not pull or press the cable. Keep the cable away from heated surfaces. Do not place the cable in a closed-door or pull it through a sharp edge or corner. Keep the cable away from walking areas. Do not operate product across the cable.
15. Do not use the product to pick up flammable or explosive liquids such as gasoline, or use where these liquids or vapors may exist
16.  Do not use the product to pick up burning or smoking objects, such as cigarette butts, matches, or hot ashes.
17. Do not use the product to pick up sharp objects like broken glass.
18. Do not use a cleaning solution containing vinegar or acid solution, it will damage the parts and affect the use.
19.  Please unplug the charger when the product is long idled or before repairing.
20. Do not wash parts of or the whole product directly under the tap, this will cause a short circuit and damage the product.
21.  This appliance can be used by children aged 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning the use of the appliance in a safe way and understand the hazards involved.
22. Children should be supervised to ensure that they do not play with the appliance.
23. Cleaning and user maintenance shall not be made by children without supervision.
24. The appliance is only to be used with the power supply unit provided with the appliance.

Rug Doctor Cordless Floor Cleaner

1. On/off button
2. Water spray button
3. LED screen
4. Floorhead upper cover latch
5. Brushroll
6. Handle
7. Battery pack| 8. Clean water tank release button
9. Clean water tank
10. Floorhead
11. Stand base
12. Mini brush
13. Mains adaptor
14. Rug Doctor 2 in 1 Cleaning Solution
---|---

Machine Assembly

Handle and Mainbody Assembly

1. Take the parts of the machine out of the box.
2.  Align the metal of the handle with the connecting rod on the main body. Insert the handle vertically into the main body until a “click” sound is heard. (Figure 1)

ATTENTION
Pay attention to the assembly direction of the handle, do not insert it in the opposite direction to avoid damage. Insert the handle vertically into the main body until a “click” sound is heard to avoid poor contact and a loose handle.

Mains Adaptor Assembly
Take the adaptor out of the box. Insert the connector into the socket at the back of the body. After the power plug is connected to the A/C power socket. The machine starts to charge. (Figure 2)

ATTENTION
When charging, do not overstretch the charger cable. This will ensure an uninterrupted charging period.

Using the Machine

Charging and Charging LED display

1. When the LED display shows battery power of less than 20%, the battery indicator turns from white to red to remind the user to turn off the machine and charge.
2. When charging, the display shows the percentage of battery power and the battery indicator turns red. When the LED display shows 100% power and the battery indicator turns from red to white, it indicates charging is completed. Remind the user to unplug the power. (Figure 3, Figure 4)
3. The machine charging time is around
4. 5 hours to 5.5 hours. After charging, please unplug the charger plug from the power socket and stop charging.

ATTENTION:
On first use, please fully charge the battery pack before cleaning. For the first three uses of the product, it is recommended to charge for about 12 hours each time. After complete charging and discharging, the product can be charged normally.

Cleaning Floors

1.  Take off the floor cleaner from the stand base and press the on/off button, the LED screen shows the percentage of battery power. The machine starts and the brush roll rotates. Press the on/off button again, the machine stops and the screen is off.
2. Press and hold the water spray button to spray water. Release the water spray button and the machine stops spraying water.
3. If the buzzer sounds when pressing and holding the water spray button, and the screen shows clean water empty. It indicates the clean water tank is empty refill clean water and continue use.
4. When in use, if the buzzer sounds and the screen shows dirty water full the machine automatically turns off. It indicates the dirty water tank is full and needs to be emptied,  or dirty water tank wall is too dirty and needs to be cleaned.

ATTENTION:
When using the product for the first time, battery power is insufficient, and use time is not long. It can be used normally after being fully charged. For the first three uses of the product, it is recommended to charge for about 12 hours each time. After complete charging and discharging, the product can be charged normally.

Clean Water Tank

Disassembly and Assembly of Clean Water Tank
Disassembly: Press the clean water tank button to take out the clean water tank.
Assembly: Put the clean water tank cap into the round groove of the machine and then press from the top inward firmly. Insert a clean water tank into the main body until a “click” sound is heard. (Figure 5)

Refilling The Clean Water Tank

1. Clean water tank button position (Figure 5)
2. Turn the clean water tank cap anticlockwise to open and fill it with clean water
3. If using Rug Doctor 2 in 1 cleaner, dilute to 50 parts water, 1 part solution.
4. Fill with clean water.
5. Turn the clean water tank upside down and insert it into the main body. (Figure  6)

ATTENTION
DO NOT fill clean water above the MAX line to avoid dirty water tank overflow.
If a buzzer sounds when pressing and holding the water spray button it indicates that the clean water tank is empty. Follow the steps to refill the clean water tank to continue cleaning.

Dirty Water Tank

Disassembly and Assembly of Dirty Water Tank

Disassembly: Press the two upper lid latch buttons inward with two fingers to pull up the floorhead cover (Figure 7). Lift up the handle of the dirty water tank and remove it for cleaning  (Figure 7-2).

Assembly: After cleaning, put the dirty water tank into the floorhead slot and put the floorhead cover on. Press both sides of the brush roll cover at the same time. The button pops up to lock the upper cover until a “click” sound is heard (Figure 7-3).

Cleaning The Dirty Water Tank

1. Remove upper cover and dirty water tank to clean floorhead base by brush.
2. Lift up the dirty water tank and turn to flip the handle out to empty the dirty water.
3.  After cleaning the dirty water tank, place it back into the machine.
4. If there is debris or particles between the dirty water tank and floorhead, clean the floorhead to take off the dirty water tank. (Figure 8)

FIGURE 7
Press the buttons inward with two fingers to pull up the floorhead cover

FIGURE 7-2
Handle dirty water tank

FIGURE 7-3

Press both sides of the floorhead cover at the same time and the button pops up to lock tightly

FIGURE 8

Brushroll

Disassembly and Assembly of Brushroll
Disassembly: Press the latch button (Figure 9) on the right cover inward and pull out the right cover. Then hold the head of the brush roll and pull the brush roll out. (Figure 9- 2) Assembly: Overlap the brush roll into floorhead motor and push inward until it can’t move. Then press the right cover until a “click” sound is heard. (Figure 9)

ATTENTION
When assembling the brush roll push it all the way in before attaching the right cover.
If the brush roll is not in place there will be abnormal noises when the machine is turned on. Please switch off the machine immediately and reassemble the brush roll.
When the brush roll is rotating, if there is a large foreign object blockage or an excessive amount of entangled fibers, or if a child accidentally touches the brush roll the floorhead will stop working for personal safety and avoid damage to the floorhead.
Please resolve blockages quickly to avoid permanent damage to the machine.

Machine Stand

Use of Machine Stand Base
Take out the stand base and place it on the ground. Align the floorhead with the stand base and put it into the groove of the stand base until the machine stands upright without toppling. (Figure 10) ATTENTION
When the machine is left idle for an extended period of time, place it in a cool and dry place, and avoid direct sunlight or a wet environment to damage the hard floor.

Cleaning and Maintenance

WARNING BEFORE SELF CLEANING empty the water from the dirty water tank.

Cleaning Brushroll (Manual)
Refer to page 12 on disassembling and assembling the brush roll. After cleaning, re-assemble and continue using. (Figure 11)

Self-Cleaning Brushroll

1. Remove the clean water tank and fill with water containing cleaning shampoo to the self-cleaning water line, 260ml. (Figure 12)
2. Pour the water from the clean water tank into the stand base to ensure two slots have water.
3. Plug into the charger and put the machine on the stand base.
4. Press the on/off button and keep pressing the water spray button for 5 seconds (indicator turns green). The brush rolls rotate and the machine starts self-cleaning mode.  (Figure 13)
5.  Self-cleaning mode lasts for 2 minutes, press any button to stop self-cleaning mode.
6. If foam remains on the brush roll, restart the self-cleaning mode.
7. If the brush roll is still not clean after using the self-cleaning mode twice, it is recommended that you disassemble the brush roll for manual cleaning.

FIGURE 11
Slot cutter of the mini brush to cut tangled hair from the brush roll

FIGURE 12
Fill with a floor cleaning shampoo and clean water to the self-cleaning water line

ATTENTION
After self-cleaning, the brush roll will be soaked and must be placed in a well-ventilated place to dry to avoid affecting the cleaning capabilities on the next use.
When the roller brush is soaked the machine cannot be used in an environment below 0°C. If the brush roll freezes the increased load will cause damage to the machine.

Storing The Cordless Floor Cleaner
After using, place the Cordless Floor Cleaner into the stand base to prevent the wet brush roll from causing damage to the floor.
It is recommended to clean the brush roll before storage, and then store it in a cool place to avoid moldy bristles and odors that will affect the life of the brush roll.
Do not store in direct sunlight or in a humid environment.
To remove the handle: Use a tool like a screwdriver and insert it into the hole (Figure 14) and pull the handle upward.

Troubleshooting

heavy objects and clean brush roll
Motor failure| Replace motor
Clean water tank empty| Refill clean water tank
Object blockage| Clean the dirty nozzle, clean the dirty water tank
The full indicator lights up| Dirty water tank full or too dirty| Empty the dirty water and clean the dirty water tank
The empty indicator lights up| Clean water tank empty| Fill the clean water tank
Display battery power light turns red| Lower battery power| Charge the machine

If the above troubleshooting guide fails to provide a solution, please contact Rug Doctor Customer Services (UK) 01903 23 55 58 or (EIRE) 1800 93 20 96. Available Mon- Fri 8am-6pm / Sat 9am-5pm / Sun & Bank Hols 10 am-4 pm *Excl Easter Sunday, Christmas Day, Boxing Day & New Year’s Day.

Produoor Cleaner Technical Specification

Model
number
Rated
voltage
Rated
power
Adaptor input voltage
Adaptor output voltage
Rated power of electric floor head
Rated power of water spray pump
Battery pack capacity
Charging
time| 1093575
14.4V
60W
100-240V~
50/60Hz
17.4V 600mA
25W
5W
2500mAh
5±0.5H
---|---

Warranty Information

This product has a two-year warranty from the date of purchase.
Excluded from the guarantee are normal wear, commercial use, alterations to the appliance as purchased, cleaning activities, consequences of improper use or damage by the purchaser or a third person, and damage that can be attributed to external circumstances or caused by the batteries.

Disposal

The machine, accessories, and packaging should be sorted for environmental- friendly recycling.
Do not dispose of the machine into household waste!
Only for EC countries: According to the European Guideline 2012/19/EU, machines that are no longer usable, and according to the European Guideline 2006/66/EC,  defective or used battery packs/batteries, must be collected separately and disposed of in an environmentally correct manner.

Battery packs/batteries:
Integrated batteries may only be removed for disposal by qualified personnel. Opening the housing shell can damage or destroy the machine.
Do not dispose of battery packs/batteries into household waste, fire, or water. Battery packs/batteries should, if possible, be discharged, collected, recycled, or disposed of in an environmental-friendly manner. Subject to change without notice.

Rug Doctor Customer Service

Comprehensive FAQs, user guides, and troubleshooting tips can be found at www.rugdoctor.co.uk.

Address:
Rug Doctor Consumer Support,
Unit 29 Timberlaine Trading Estate,
Decoy Road,
Worthing,
West Sussex
BN14 8ND

Phone:

(UK) 01903 23 55 58
(EIRE) 1800 93 20 96

Opening Hours:
Monday – Friday 8am – 6pm
Saturday 9am – 5pm
Sunday 10am – 4pm
Bank Holidays 10 am -4 pm

*Excluding Easter Sunday, Christmas Day, Boxing Day & New Year’s Day.

www.rugdoctor.co.uk

References

• Rug Doctor UK | Carpet Cleaner Hire Online and In-Store

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>