ViandPRO VP-WH60SSB 90cm Cooker Hood Installation Guide

Viand Pro Cooker Hood
Installation And User’s Manual

VP-WH60SSB 90cm Cooker Hood

VP-WH60SSB VP-WH90SSB
VP-WHR60B VP-WHR90B

|
---|---
VP-WH60SSB| VP-WH90SSB
|
VP-WHR60B| VP-WHR90B

SAFETY INSTRUCTIONS

• Thank you for purchasing this cooker hood. Please read the instruction manual carefully before you use the cooker hood, and keep it in a safe place.
• The installation work must be carried out by a qualified electrician or competent person. Before you use the cooker hood, make sure that the voltage (V) and the frequency (Hz) indicated on the cooker hood are exactly the same as the voltage and the frequency in your home.
• The manufacturer and the agent will not bear any responsibility for the damage caused by inappropriate installation and usage.
• Children under the age of 8 must not use the cooker hood.
• The appliance is not intended for commercial use, but only for household and similar environments.
• The cooker hood and its filter mesh should be cleaned regularly in order to keep it in good working order.
• Before cleaning, switch the power off at the main supply.
• Clean the cooker hood according to the instruction manual and keep the cooker hood from the danger of burning.
• Prohibit putting the cooker hood by fire.
• If the appliance does not function normally, contact the manufacturer or a specialist company.
• This device may be only used by children 8 years old or older and persons with limited physical, sensory and mental capabilities and / or lack of experience and knowledge, provided that they have been instructed in use of the device by a responsible person who understands the associated risks.
• If the supply cord is damaged, it must be replaced by the manufacturer, its service agent or similarly qualified persons in order to avoid a hazard.
• If the range hood is used at the same time as appliances burning gas or other fuels, the room must be adequately ventilated.
• Do not flambé under the range hood. Accessible parts may become hot when used with cooking appliances.

Important hints on installation

• The air must not be discharged into a flue that is used for exhausting fumes from appliances burning gas or other fuels (not applicable to appliances that only discharge the air back into the room).
• Regulations concerning the discharge of air have to be fulfilled.

Important notes about the extraction mode

WARNING
Risk of poisoning from exhaust gases sucked back. Never operate the device in extraction mode simultaneously with an open flue appliance when there is not adequate airflow guaranteed.
Open flue combustion equipment (for example, gas, oil, wood or coal-fi red heaters, tankless water heaters, water heaters) pulls combustion air from the room and runs it through an exhaust pipe or chimney to the outside. In the extraction mode, indoor air is removed from the kitchen and the adjacent rooms – without sufficient air intake this creates a vacuum. Toxic gases from the chimney or extraction flue can thereby be sucked back into the living spaces.

• Always ensure that a sufficient supply of fresh air is guaranteed and that the air can circulate.
• An air supply / extractor box alone does not ensure compliance with the limit value.

Safe operation is only possible when the negative pressure in the room where the appliance is located does not exceed 4 Pa (0.04 mbar). This can be achieved when the air required for combustion can flow through openings that are not  closable, for example in doors, windows, in conjunction with an air supply / extractor box or through other technical measures. In any case, consult a qualified chimney sweep who can assess the entire ventilation of your house and  propose appropriate measures for adequate ventilation. If the hood is used exclusively in the recirculation mode, unrestricted operation is possible.
Important note on disassembly of the device

• Disassembly is similar to installation/assembly in reverse order.
• Take a second person to help you during disassembly to avoid injuries.

INSTALLATION

Preparation

If you have an outlet to the outside, your cooker hood can be connected as below picture by means of an extraction duct (enamel, aluminium, flexible pipe or inflammable material with an interior diameter of 150 mm).

• Before installation, turn the unit off and unplug it from the outlet.
• The cooker hood should be placed at a distance of 65~75 cm above the cooking plane for best effect.

Installation (Vent outside)
Note: When the range hood and appliance supplied with energy other than electricity are simultaneously in operation, the negative pressure in the room must be not exceed 4 Pa (4 x 10 -5 Bar).

Drill 3 x 8 mm holes to accommodate the bracket. Screw and tighten the bracket onto the wall with the screws & screw plugs provided.| Offer up the cooker hood and hang onto the wall bracket hook.

Chimney Installation

Put the upper chimney into lower chimney .Then pulling out the upper  chimney upwards. Adjust to reach the height required.| Sliding the chimney to adjust the chimney height. When the height you  required is reached, then hang the fixing hole to the fixing screws as showed in picture.

Installation (Vent inside)
If you do not have an outlet to the outside, exhaust pipe is not required and the installation is similar to the one show in section “Installation (Vent outside)”.
Installing the Carbon Filter
Note: Carbon filter is not standard accessory, these can be purchased as an accessory.

activated carbon filter, the grease filter should be detached  first. Press the lock and pull it downward.
3| 4
|
Plug the activated carbon filter into the unit and turn it in clockwise direction. Repeat the same on the other side. Make sure the filter is securely locked. Otherwise, it would loosen and cause dangerous. When activated  carbon filter attached, the suction power will be lower.| Remove all blue protective film on chimney and cooker hood, the installation is now finished.

BUTTON FUNCTIONS

Control for VP-WH60SSB & VP-WH90SSB

| Depress this button to turn off the motor.
---|---
1| First speed
2| Second speed
3| Third speed
| Turn on/off light.

Booster setting:
Long press the Third speed button, the hood will into booster setting.
(Remark: the booster setting just can ran 5 mins, after 5 mins, the hood will return back to the third speed.
Control forVP-WHR60B & VP-WHR90B

| Depress this button to turn off the motor.
---|---
| First speed
| Second speed
| Third speed
| Turn on/off light.

BULB AND LAMP REPLACEMENT

Replacing Bulbs

• Switch the unit off and unplug the appliance. Remove the lamp cover by unscrewing the 2 screws.
• Unscrew the incandescent bulb. Replace with the same type and rated bulb:

Replacing LED Lamps

• Disconnect the light wiring point which is located within the hood, (behind the grease filer).
• Then use a screw driver remove the bulb holders and wiring from the hood. Replace with the same type and rated lamp: LED Lamp: max 1.5 W

CLEANING AND MAINTENANCE

Turn off the cooker hood before cleaning and maintenance and unplug the appliance from the wall outlet. The exterior surfaces are susceptible to scratches and stains. Therefore, do not use abrasive cleaners and wipe away any alkaline  or acidic residue (lemon juice, vinegar) immediately after cleaning.
Stainless Steel Surfaces
The stainless steel must be cleaned regularly to ensure a long service life. Use stainless steel cleaner. Always wipe along the grain of the stainless steel to prevent scratching.
Control Panel
The control panel can be cleaned with a damp cloth and a mild dishwashing detergent. Before cleaning, make sure the cloth is clean and well wrung. Use a dry, soft cloth to remove excess moisture after cleaning.
Monthly Cleaning for Grease Filter
Clean the filter every month can prevent any risk of fire. The filter collects grease, smoke and dust, so the filter is directly affecting the efficiency of the cooker hood. If not cleaned, the grease residue (potential flammable) will saturate on  the filter. Clean it with household cleaning detergent.

TROUBLESHOOTING

and repair by qualified service personnel only.
The motor is damaged.
Both light and fan do not work| light bulb burn.| Replace the bulb with correct rating.
Power cord looses.| Plug in to the power supply again.
Serious vibration of the unit| The fan blade is damaged.| Switch of the unit and repair by qualified service personnel only.
The fan motor is not fixed tightly.
The unit is not hung properly on the bracket.| Take down the unit and check whether the bracket is in proper location.
Suction performance not good| Too long distance between the unit and the cooking plane| Readjust the distance to 65-75 cm

PRODUCT DATA SHEET

Information according to Regulation (EU) No. 65/2014
Measurement and calculation methods according to EN 61591:1997+A1:2006
+A2:20 11+A11:2014+A12:2015

**VP-WH60SSB TECHNICAL DATA***

Type| Cooker hood Stainless
Material| steel + Glass
Installation-width in cm| 60
Island installation| ×
Touch control| Touch
Recirculation|
Annual energy consumption (AE Chood)| 42.3kW/h
Energy efficiency category| A
Fluid dynamical efficiency (Foehoods) Fluid| 30.1
dynamical efficiency category Lighting| A
efficiency (LaHood)| 34 lux/W
Lighting efficiency category| A
Grease separation| 83.60%
Grease separation category| C
Air flow | 327.3m³ /h 470m³ /h
Maximum air flow Smax| 470 m³/h
Air flow at boost setting| 628m³/h
A-rated noise emission | 52 dB 63dB
Power consumption off (Po)| 0.49W
Power consumption standby (Ps)| 0.46W
Power consumption lighting system (Wl)| 3.0 W
Connected load| 253W
Illuminant| / LED
Power consumption per illuminant unit| 2*1.5W
Voltage / frequency| 220 – 240 V AC / 50-60 Hz
Height adjustment in cm| 50-100
Grease filter / material / dishwasher-proof| 2 aluminium
Carbon filter | 2CF02 / optional
Installation material|
Instruction manual|
VP-WH90SSB TECHNICAL DATA***

Type| Cooker hood
Material| Stainless steel + Glass
Installation-width in cm| 90
Island installation| ×
Touch control| Touch
Recirculation|
Annual energy consumption (AEChood)| 42.3kW/h
Energy efficiency category| A
Fluid dynamical efficiency (FDEhood)| 30.1
Fluid dynamical efficiency category| A
Lighting efficiency (LEhood)| 34 lux/W
Lighting efficiency category| A
Grease separation| 83.60%
Grease separation category| C
Air flow | 327.3m³ /h 470m³ /h
Maximum air flow Qmax| 470 m
Air flow at boost setting| 628m³/h
A-rated noise emission | 52 dB 63dB
Power consumption off (Po)| 0.49W
Power consumption standby (Ps)| 0.46W
Power consumption lighting system (Wl)| 3.0 W
Connected load| 253W
Illuminant| / LED
Power consumption per illuminant unit| 2*1.5W
Voltage / frequency| 220 – 240 V AC / 50-60 Hz
Height adjustment in cm| 50-100
Grease filter / material / dishwasher-proof| aluminium
Carbon filter | 2CF02 / optional
Installation material|
Instruction manual|
VP-WHR60B TECHNICAL DATA***

Type| Cooker hood
Material| Black stainless steel
Installation-width in cm| 60
Island installation|             ×
Touch control| Touch on SS panel
Recirculation|
Annual energy consumption (AEChood)| 27kW/h
Energy efficiency category| A++
Fluid dynamical efficiency (FDEhood)| 39.4
Fluid dynamical efficiency category| A
Lighting efficiency (LEhood) Lighting| 22.7 lux/W
efficiency category| B
Grease separation| 69.40%
Grease separation category| D
Air flow | 312.1m³ /h  602.5 m³ /h
Maximum air flow Qmax| 649.9 m³ /h
Air flow at boost setting| 721.4³/h
A-rated noise emission | 52dB/66 dB
Power consumption off (Po)| –
Power consumption standby (Ps)| 0.43W
Power consumption lighting system (Wl)| 3.0 W
Connected load| 123W
Illuminant| / LED
Power consumption per illuminant unit| 1*3 W
Voltage / frequency| 220 – 240 V AC / 50-60 Hz
Height adjustment in cm| 50-100
Grease filter / material / dishwasher-proof| 2 aluminium
Carbon filter | 2CF02 / optional
Installation material|
Instruction manual|
VP-WHR60B TECHNICAL DATA***

Type| Cooker hood
Material| Black stainless steel
Installation-width in cm| 90
Island installation|             ×
Touch control| Touch on SS panel
Recirculation|
Annual energy consumption (AEChood)| 27.8kW/h
Energy efficiency category| A++
Fluid dynamical efficiency (FDEhood)| 39.4
Fluid dynamical efficiency category| A
Lighting efficiency (LEhood) Lighting| 24.8 lux/W
efficiency category| B
Grease separation| 71.9 %
Grease separation category| D
Air flow | 312.1m³ /h  602.5 m³ /h
Maximum air flow Qmax| 649.9 m³ /h
Air flow at boost setting| 721.4³/h
A-rated noise emission | 52dB/66 dB
Power consumption off (Po)| –
Power consumption standby (Ps)| 0.43W
Power consumption lighting system (Wl)| 4.0 W
Connected load| 124W
Illuminant| / LED
Power consumption per illuminant unit| 1*4 W
Voltage / frequency| 220 – 240 V AC / 50-60 Hz
Height adjustment in cm| 50-100
Grease filter / material / dishwasher-proof| aluminium 3
Carbon filter **| 2CF02 / optional
Installation material|
Instruction manual|

NOTES ON ENVIRONMENTAL PROTECTION

• During cooking, make sure that there is sufficient air supply so that the cooker hood can operate efficiently and with low operating noise.
• Adjust the fan speed to the amount of steam produced during cooking. Use the intensive mode only when necessary. The lower the fan speed, the less energy is consumed.
• If large amounts of steam are produced during cooking, select a higher fan speed in good time. If the cooking steam has already dispersed in the kitchen, the cooker hood must be operated longer.
• Switch off the cooker hood when you no longer need it.
• Switch off the lighting when you no longer need it.
• Clean the filter at regular intervals and replace it if necessary to increase the effectiveness of the ventilation system and prevent fire hazards.
• Always put the lid on when cooking to reduce cooking steam and condensation.

DISPOSAL CONSIDERATIONS

If there is a legal regulation for the disposal of electrical and electronic devices in your country, this symbol on the product or on the packaging indicates that this product must not be disposed of with household waste. Instead, it must be taken to a collection point for the recycling of electrical and electronic equipment. By disposing of it in accordance with the rules, you are protecting the environment and the health of your fellow human beings from negative  consequences. For information about the recycling and disposal of this product, please contact your local authority or your household waste disposal service.

Notes

Viand Pro Cooker Hood Fitting
Instructions and Operation

Documents / Resources

| ViandPRO VP-WH60SSB 90cm Cooker Hood [pdf] Installation Guide
VP-WH60SSB, VP-WH90SSB, VP-WHR60B, VP-WHR90B, VP-WH60SSB 90cm Cooker Hood, 90cm Cooker Hood, Cooker Hood, Hood
---|---

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>