fillauer Motion E2 Elbow Small Lightweight Electric Elbow Instruction Manual

: June 13, 2024
: fillauer

Table of Contents

Introduction
Special Precautions
Technical Specifications
Customer Support
References
Read User Manual Online (PDF format)
Download This Manual (PDF format)

fillauer Motion E2 Elbow Small Lightweight Electric Elbow

Introduction

The Motion E2 Elbow is a lightweight electric elbow for individuals with transhumeral level or higher, upper limb amputation. It can be operated with simple switch control, or proportional myoelectric control. Its small size makes it perfect for adolescents or small individuals. Forearms can either be prefabricated or custom fabricated.

Special Precautions

Risk Management
To minimize the risk of device damage or injury to the user while maximizing the functions of this device, follow the instructions for installation, and use this device as described in this manual.

The E2 elbow should not be exposed to water.

Because of the lightweight nature of the elbow, it should not be used to support forearm loads greater than 19 ft-lbs/25.8 N-m.

The E2 elbow should not be used in environments where volatile, explosive agents may be present.

There are no field serviceable parts inside the elbow. Removal of the elbow cap may void the warranty.

Serious Incidents
In the unlikely event a serious incident occurs in relation to the use of the device, users should seek immediate medical help and contact their prosthetist at the earliest possible convenience. Clinicians should contact Motion Control immediately in the event of any device failure.

Forearm Options

Several options are available for the forearm section of the elbow. Prefabricated forearms are available in 4 colors and may be ordered with the elbow (Chart 14). Forearms may also be custom fabricated by Fillauer.

Control Configurations

The Motion E2 Elbow can be operated with many different switches and myoelectric inputs. Additionally, multiple terminal devices including in-hand controller TDs may be used such as Motion Control ProPlus devices, Taska®, i-limb®, and bebionic® hands. The result is a range of systems from low cost simplicity to complex, multi-digit hands, operated with or without an electric wrist rotator.

The versatility of the Motion E2 Elbow allows placement of the batteries and switches throughout the prosthesis, whether in the forearm, within the humeral section of the prosthesis, or switches placed on a shoulder disarticulation socket. As such, the splitter and adaptor cables have been purposely made short, and extension cables may then be used where indicated. The diagrams on pages 6-12 depict extension cables in every place they might be used. It is strongly suggested to order all cables that may be necessary, then return any unused components. Refer to Charts 1-14 (pages 13-14) for lengths and part numbers.

Single Patient Use

Each amputee is unique. The shape of their residual limb, the control signals each generates and the tasks an amputee performs during the day require specialized design and adjustment of the prosthesis. Motion Control products are manufactured to be fit to one individual.

Disposal/Waste Handling

This device, including any associated electronics and batteries should be disposed of in accordance with applicable local laws and regulations. This includes laws and regulations regarding bacterial or infectious agents, if necessary.

Limited Warranty

Seller warrants to Buyer that the equipment delivered hereunder will be free from defects in materials and manufacturing workmanship, that it will be of the kind and quality described and that it will perform as specified in Seller’s written quotation. The preceding limited warranties shall apply only to failures to meet said warranties that appear within the effective period of this Agreement. The effective period shall be two years (24 months) from the date of delivery to the fitting center that has purchased the components. Refer to the shipping receipt for the date of shipment.
For more information regarding the Limited Warranty, see the MC FACT SHEET – Limited Warranty at www.UtahArm.com.

Return Policy

Returns are accepted for a full refund (not including any repairs that may be required) for up to 30 days from date of shipment. Returns 31-60 days from date of shipment will be accepted, subject to a 10% restocking fee. Returns 61-90 days from date of shipment will be accepted, subject to a 15% restocking fee. Returns must be in re-saleable condition. Beyond 90 days, returns are not accepted.

f you have any questions, please do not hesitate to call Motion Control, 801.326.3434

Declaration of Conformity: The product herewith complies with Medical Device Regulation 2017/745 and is registered with the United States Food and Drug Administration. (Registration No. 1723997

Technical Specifications

| Large| Medium
---|---|---
Excursion Range| 135 degrees| 135 degrees
Height Elbow center to Lamination Collar| 2½ in/6.4 cm| 2½ in/6.4 cm
Diameter| 2-13/16 in/7.1 cm| 2-3/8 in/6 cm
Weight| 16 oz/454 gm| 15.5 oz/439 gm
Live Lift| 2.2 ft-lbs/3 N-m| 2.2 ft-lbs/3 N-m
Lift Time| 1.3 – 4.9 seconds| 1.3 – 4.9 seconds
Static Load| 19 ft-lbs/25.8 N-m| 19 ft-lbs/25.8 N-m

System Selection

To determine the correct components for a Motion E2 System, first determine the control system desired for the elbow (simple switch operation or myoelectric, including a linear potentiometer), what type of terminal device, (either Motion Control Standard (motor direct) or an in-hand controller TD such as Motion Control ProPlus, TASKA™, i-limb®, Bebionic® etc., and if it is to be switch operated or controlled with myoelectrics (including linear potentiometer). The last choice is if an electric wrist rotator is to be used and how it is to be controlled.

Next, follow down the list of options until a system matches the chosen components. The corresponding chart then gives you the choices for switches and inputs.

If at any point you need assistance, please contact Motion Control, 801-326-3434.

Switch Elbow / Switch TD
Switch Operated Motion E2 Elbow – Switch Operated Terminal Device (Page 6)
a. Simplest low cost system
b. Simple operation
Myo Elbow / Myo TD – ProControl 2
ProControl 2 – Myoelectric Control of Motion E2 Elbow – Myoelectric Control of Terminal Device (Page 7)
a. Proportional Myoelectric Control of Elbow and Terminal Device
b. Utilizes simpler MC Standard Terminal Devices (blue coaxial plug)
c. Input options
i. EMG
ii. Linear Potentiometer
iii. Touch Pad
d. NOT interchangeable with in-hand controller terminal devices, (MC ProPlus, Taska®, i-limb®, bebionic®)
Myo Elbow / Switch Wrist / Myo TD
Three Degree of Freedom System – Myoelectric Control of Motion E2 Elbow – Switch Operated Standard Wrist – Myoelectric Control of Terminal Device
a. Proportional Myoelectric Control of Elbow and Terminal Device
b. Utilizes simpler MC Standard Terminal Devices (blue coaxial plug)
c. Input options
i. EMG
ii. Linear Potentiometer
iii. Touch Pad
d. NOT interchangeable with in-hand controller terminal devices, (MC ProPlus, Taska®, i-limb®, bebionic®)
e. Allows use of a Standard Electric Wrist Rotator operated with a simple switch
Switch Elbow / Myo TD
Switch Operated Motion E2 Elbow – ProPlus Terminal Device
a. Simple switch operated Motion E2 Elbow
b. Utilizes MC ProPlus Terminal Devices (green coaxial plug)
c. Allows interchangeability with other in-hand controller terminal devices (MC ProPlus, Taska®, i-limb®, bebionic®
Switch Elbow / Myo Wrist / Myo TD
Switch Operated Motion E2 Elbow – ProWrist Electric Wrist Rotator – ProPlus Terminal Devices (Page 10)
a. Simple switch operated Motion E2 Elbow
b. Utilizes MC ProPlus Terminal Devices (green coaxial plug)
c. Allows interchangeability with other in-hand controller terminal devices (MC ProPlus, Taska®, i-limb®, bebionic®)
d. Allows use of MC ProWrist Electric Wrist Rotator
Myo Elbow / Myo TD – ProPlus
ProControl 2 – Motion E2 Elbow Control – ProPlus Terminal Device Control
a. Allows Simultaneous, Myoelectric Control of Elbow and Terminal Device
b. Input options for both Elbow and Terminal Device
i. EMG
ii. Linear Potentiometer
iii. Touch Pad
c. Allows interchangeability with other in-hand controller terminal devices (MC ProPlus, Taska®, i-limb®, bebionic®)
Myo Elbow / Myo Wrist / Myo TD
ProControl 2 – Motion E2 Elbow Control – ProWrist Electric Wrist Rotator, ProPlus Terminal Devices (Page 12)
a. Allows Simultaneous, Myoelectric Control of Elbow and Terminal Device
b. Input options for Elbow, ProWrist, and Terminal Device
i. EMG
ii. Linear Potentiometer

iii. Touch Pad

*Shown with optional Flexion Wrist
c. Allows interchangeability with other in-hand controller terminal devices (MC ProPlus, Taska®, i-limb®, bebionic®)

d. Allows use of MC ProWrist Electric Wrist Rotator

NOT TO SCALE

Switch Elbow / Switch TD – Switch Operated Motion E2 Elbow – Switch Operated Terminal Device

Chart 1 – Switch Options

| Description| | | Cable Length| Part No.
A| Otto Bock Harness Pull Switch| | | 20 in/ 51 cm| 1701022
B| Otto Bock Rocker Switch 9X25| | | 1.5 in/8 cm| 1701021
C| Motion 2 Button 2 Position Push Switch MC 4 pin| | | 20 in/51 cm| 3050015
D| Motion 2 Position Pull Switch MC 4 pin| | | 14 in/36 cm| 3050013
E| Otto Bock Cable Pull Switch| | | N/A| | 1701023
Chart 2 – Proportional Input Options
| Description| Cable Length| Tan| Brown| Black| | Part No.
A| Triad Preamp Set (Grey), Dual Channel, ProControl/ProHand (Chart 2a)| 24 in/61 cm| –| –| –| | 3010784
| Triad Preamp Set (Grey), Single Channel, ProControl/ProHand (Chart 2a)| 24 in/61 cm| –| –| –| | 3010785
| Triad Preamp Set (Grey), Dual Channel, 3-pin Connector (Chart 2b)| 24 in/61 cm| | | | | 3010968
| Triad Preamp Set (Grey), Single Channel, 3-pin Connector (Chart 2b)| 24 in/61 cm| | | | | 3010969
B| Linear Potentiometer| 22 in/56 cm| –| –| –| | 3010546
| Linear Potentiometer, 3-pin Halfmoon Connector| 22 in/56 cm| –| –| –| | 3010988
C| Touch Pad| 1 in/2.5 cm| 3010669| 3010670| 3010721| –
D| Touch Pad Cable, Single Channel| 20 in/51 cm| –| –| –| | 3010548
| Touch Pad Cable, Dual Channel| 20 in/51 cm| –| –| –| | 3010549
Chart 3 – Adapter Cables| | | | | | |
---|---|---|---|---|---|---|---
Description| | | | Cable Length| Part No.
5-Pin to 9-Pin Adapter for Alternate Input to ProC2/ProPlus for non-EMG inputs| | | | 8 in/20 cm| | 3010794
Cable Adapter Switch Control w/ Batt. Input| | | | 2.25 in/6 cm| 3010945
Battery Splitter Cable, 2 Pin Connectors| | | | 4 in/8 cm| | 3010946
Battery Splitter Cable, 4 Pin and 2 pin Connectors| | | | 4 in/8 cm| | 3010950
Chart 4 – 2-Pin Extension Cables| | | | | | |
Description| | Cable Length 12 in/30 cm| Cable Length 18 in/46 cm| Cable Length 24 in/60 cm
Extension Cable 2-Pin Halfmoon| | 3010951| | 3010842| 3010952
Chart 5 – 3-Pin Extension Cables| | | | | | |
Description| | Cable Length 12 in/30 cm| Cable Length 18 in/46 cm| Cable Length 24 in/60 cm
Extension Cable 3-pin| | 3010989| | 3010990| 3010991
Chart 6 – 4-Pin Extension Cables| | | | | | |
Description| | Cable Length 12 in/30 cm| Cable Length 18 in/46 cm| Cable Length 24 in/60 cm
Extension Cable 4-pin 3010304| | 3010325| | 3010326| 3010304
Chart 7 – Battery Kits| | | | | | |
Description| | | | Long/thin| Split-cell
Battery/Charger Set – Internal, 7.2V, Li Ion, (incl. wiring harness)| | | | 3010467| 3010596
Battery/Charger Set – Int. 7.2V, Li Ion, 2 Pin (incl. wiring harness)| | | | 3010954| 3010953
Chart 8 – Motion E2 Elbows & Humeral Lamination Collars| | | | | | |
Description| Tan| Lt. Brown| Brown| Black| | Part No.
Motion E2 Elbow, Medium, 2-3/8 in/6 cm diam| 5010094| 5010100| 5010095| 5010096| –
Motion E2 Elbow, Large, 2-13/16 in/7.1 cm diam| 5010097| 5010101| 5010098| 5010099| –
Motion E2 Elbow, Humeral Lamination Collar, Medium| –| –| –| | –| | 1072006
Motion E2 Elbow, Humeral Lamination Collar, Large| –| –| –| | –| | 1072007
Chart 9 – MC Standard Wrist Rotators| | |
---|---|---|---
Description| Tan| Brown| Black
MC Standard Wrist Rotator| 5010054| 5010055| 5010045
Chart 10 – MC ProWrist Rotators| | |
---|---|---|---
Description| Tan| Brown| Black
MC – ProWrist Rotator| 5010057| 5010058| 5010056
Chart 11 – QD Wrist Parts| | | |
---|---|---|---|---
Description| Tan| Brown| Black| Part No.
Lamination Collar for MC Wrist, 7 1/4 Hand| 1100292| 1100296| 1100288| –
Lamination Collar for MC Wrist, 7 3/4 Hand, ETD| 1100293| 1100297| 1100289| –
Lamination Collar for MC Wrist, 8 1/4 Hand| 1100294| 1100298| 1100290| –
Lamination Collar for MC Wrist for Hosmer Prefab (LRG), Boston or AFB| 1100295| 1100299| 1100291| –
Forearm Endcap| 3010804| 3010805| 3010758| –
Wrist Lamination Dummy Kit| –| –| –| 3010886
Otto Bock style Coaxial Plug| –| –| –| 1701009
Chart 12 – Standard Terminal Devices| | | |
---|---|---|---|---
Description| 7 1/4| 7 3/4| 8 1/4| Part No.
Motion Control Hand – Standard Left| 5010022| 5010024| 5010028| –
Motion Control Hand – Standard Right| 5010023| 5010025| 5010029| –
Heavy Duty Stainless Steel Fingers Option MC Hand| –| –| –| 3010878
Description| Left| Right| |
ETD – Standard| 5010032| 5010033| –| –
ETD – Standard, with Titanium Hook Fingers| 5010059| 5010060| –| –
ETD – Standard, with Black Anodize Hook Fingers| 5010073| 5010074| –| –
Chart 13 – MC ProPlus Terminal Devices| | | |
---|---|---|---|---
Description| 7 1/4| 7 3/4| 8 1/4| Part No.
ProPlus Hand – Left| 5010046| 5010048| 5010050| –
ProPlus Hand – Right| 5010047| 5010049| 5010051| –
Heavy Duty Stainless Steel Fingers Option MC Hand| –| –| –| 3010878
Description| Left| Right| |
ProPlus ETD| 5010052| 5010053| –| –
ProPlus ETD, with Titanium Hook Fingers| 5010061| 5010062| –| –
ProPlus ETD, with Black Anodize Hook Fingers| 5010071| 5010072| –| –
ProPlus ETD2| 5010084| 5010082| |
ProPlus ETD2, Heavy-Duty Fingers| 5010106| 5010107| |
Chart 14 – Prefabricated Forearm Options| | | | |
---|---|---|---|---|---
Description| Tan| Lt. Brown| Brown| Black| Part No.
Prefabricated Forearm, Motion E2 Elbow, Medium| 1702104| 1702106| 1702105| 1702107| –
Prefabricated Forearm, Motion E2 Elbow, Large| 1702108| 1702110| 1702109| 1702111| –
External Cable Housing for Motion E2 Elbow| –| –| –| –| 3050022
Chart 15 – ProControl 2| | | | |
---|---|---|---|---|---
Description| System| Base| Basic| Long Wires| Full H/W
ProControl 2 Package| 5010020| 5010031| –| –| –
Wrist Feature for ProControl 2 (Hand/Wrist Switching)| 4010000| –| –| –| –
Wire Harness – ProControl 2| –| –| 3010295| 3010331| 3010425