DEL ozone Spa Eclipse Ozone Generator Installation Guide
- June 12, 2024
- DEL ozone
Table of Contents
Ozone Generator
Installation Guide
IMPORTANT SAFETY INSTRUCTIONS
When installing and operating the Spa Eclipse ozone generator, basic
precautions should always be followed:
READ AND FOLLOW All INSTRUCTIONS
- Read this manual completely before attempting installation.
- All permanent electrical connections should be made by a qualified electrician.
- Follow all applicable electrical codes.
- Be sure the electrical power is shut OFF at the main circuit breaker before installing the Spa Eclipse.
- If the Spa Eclipse electrical connection is to be attached to the spa controls, be sure the spa controls are protected by a Ground Fault Circuit Interrupter (G.F.C.I.). If the Spa Eclipse is connected to an independent electrical supply, then a G.F.C.I. must be installed between the Spa Eclipse and the electrical supply.
- WARNING – To reduce the risk of electrical shock, if the power cord is damaged, replace the entire unit immediately.
- The Spa Eclipse must be mounted indoors or sheltered, under a cover, from natural elements (rain, sun, sprinklers).
- Mount the Spa Eclipse so that it is inaccessible to anyone in the spa.
- Install a check valve in the tubing between the Spa Eclipse and the vacuum source.
- Plastic ozone supply tubing is available with the Spa Eclipse. Never replace this tubing with metal tubing.
- Do not operate the Spa Eclipse unless sufficient air flow is being drawn through the unit.
- WARNING: Short term inhalation of high concentrations of ozone and long term inhalations of low concentrations of ozone can cause harmful physiological effects. Do not inhale ozone gas produced by this device.
SAVE THESE INSTRUCTIONS!
Mounting
a. The Spa Eclipse must be mounted horizontally with ozone tubing connection
pointing down. Use both mounting flanges.
b. Mount as high as possible within the protected equipment area.
Plumbing – dEl Mixing System
a. For optimal dissolution of ozone into the water, install the DEL Mixing
System in the water circulation line as generally shown in Figure 2.
b. For other circulation systems or vacuum sources, DEL Industries provides a
wide range of installation kits. Contact DEL Customer Service for assistance.
Plumbing – Ozone Generator
a. Connect ozone compatible tubing (1/4” internal diameter) to the open hose
barb on the Spa Eclipse.
b. Run tubing to the ozone injector or appropriate vacuum source.
i. If the ozone generator is mounted above the water line, tubing may be run
directly to the vacuum source.
ii. If ozone generator is mounted below the water line, run tubing to a point
above the water line and back down to the vacuum source.
c. Install the check valve in the tubing above the water line. Ensure flow
direction is from the Spa Eclipse to the vacuum source.
d. Secure all tubing connections with hose clamps.
Electrical **
**
a. Verify that there is no power to the spa and connect the Spa Eclipse cord
into the mating connector(s) on the spa control box.
b. Where possible, route the Spa Eclipse power cord away from other electrical
lines. Avoid routing the power cord parallel to any low-voltage signal wires.
Operation **
**
a. With the spa filled to the proper level, run the spa controller through
several cycles.
i. Verify that the green light on the Spa Eclipse turns on and off as required
by the controller.
ii. Verify that gas is flowing into the injector (there should be no water in
the tubing and very small bubbles at the return).
iii. Verify that water does not push past the check valve during any spa
cycle.
iv. Check for and correct any leaks in the ozone tubing.
System Maintenance
a. Ordering Information:
To locate the dealer nearest you call 1.800.676.1335 ext. 232
Be prepared with the following information:
- Name
- Date Purchased
- Address
- Dealer Name
- Model #
b. Standard Replacement Parts List:
i. Ozone Check Valve ………………………………………7-1140-01
ii. Ozone Tubing……………………………………………….7-0075
iii. Inlet Filter Assembly ………………………………………9-0858-01
The Ozone Check Valve (Item i) should be replaced annually.
c. Regularly inspect ozone supply tubing for cracks or wear. Also check to
make sure no water is present between the Check Valve and the Ozone Generator.
This indicates Check Valve failure.
Replace the Ozone Check Valve and tubing immediately.
d. Regularly inspect the inlet filter for dirt build-up. If the cotton filter
element is clogged, remove the filter assembly and clean the filter or replace
the filter assembly.
**WARNING: Trace amounts of nitric acid may be present in the check
valve or tubing and could be mildly corrosive. If condensation is present shut
off the ozone generator and allow the moisture to be drawn out or dried up
prior to servicing.**
DEL OZONE LIMITED ONE YEAR WARRANTY
The limited warranty set forth below applies to products manufactured by DEL
OZONE – 3580 Sueldo Street, San Luis Obispo, California 93401, and sold by DEL
OZONE or its authorized dealers. This limited warranty is given only to the
first retail purchaser of such products and is not transferable to any
subsequent owners or purchasers of such products.
DEL Ozone warrants that it or its authorized dealers will repair or replace,
at its option, any part of such products proven to be defective in materials
or workmanship within ONE (1) year from the date of retail purchase of such
products. (All parts) ANY REPAIR OR REPLACEMENT WILL BE WARRANTED ONLY FOR THE
BALANCE OF THE ORIGINAL WARRANTY PERIOD OR NINETY (90) DAYS, Whichever is
greater.
NOTE: USE ONLY DEL AUTHORIZED DEL REPLACEMENT PARTS. USE OF ANY OTHER
PART(S) WILL VOID THIS WARRANTY.
Any replaced parts must be returned to DEL OZONE for warranty evaluation.
THIS LIMITED WARRANTY DOES NOT INCLUDE ANY OF THE FOLLOWING:
(a) Any labor charges for troubleshooting, removal, or installation of such
parts.
(b) Any repair or replacement of such parts necessitated by faulty
installation, improper maintenance, improper operation, misuse, abuse,
negligence, accident, fire, flood, repair materials, and/or unauthorized
accessories.
(c) Any such products installed without regard to required local codes and
accepted trade practices.
(d) Damage to unit caused by water backflow.
(e) Any implied warranty of merchantability or implied warranty of fitness for
particular purpose, and such warranties are hereby disclaimed.
(f) DEL Ozone shall not be liable under any circumstances for loss of use of
such product, loss of profits, direct damages, indirect damages, consequential
damages, and / or incidental damages.
This warranty gives you specific legal rights. You may have other rights which
vary from state to state.
TO OBTAIN WARRANTY SERVICE:
DEL OZONE
3580 Sueldo, San Luis Obispo, CA 93401
Customer Service
Number:800-676-1335
Fax Number: 805-541-8459
E-mail:
warrantysupport@delozone.com
(residential)
service@delozone.com (commercial)
PROVIDE:
- Customer name, mailing address, and telephone.
- Installer/Mechanical Contractor or Dealer name.
- Unit Part Number, Serial Number or Manufacture Date, and date of purchase.
- The date of failure.
- A description of the failure.
After this information is provided, DEL Ozone may release a RETURN GOODS AUTHORIZATION (RGA) NUMBER. After receiving the RGA number the part in question must be returned to DEL Ozone, freight prepaid, with the RGA number clearly marked on the outside of the package. All preauthorized defective parts must be returned to DEL Ozone within thirty (30) days. Under no circumstances may any product be returned to DEL Ozone without prior authorization. Returns without the assigned RGA number on the outside of the package will be refused and shipped back to the sender at their expense. Upon receipt of preauthorized returned goods, DEL Ozone will repair or replace, at DEL Ozone’s option, the defective product(s) and return them (freight prepaid for products under warranty). Buyer’s acceptance of the product and use thereof constitutes acceptance of these terms.
DO NOT FORGET TO CUT OUT, PLACE IN ENVELOPE AND MAIL TO THE FOLLOWING
ADDRESS FOR INSTANT WARRANTY COVERAGE!
DEL Ozone
ATTN: Warranty Dept.
3580 Sueldo Street
San Luis Obispo, CA 93401
3580 Sueldo Street, San Luis Obispo, CA 93401
800-676-1335
o3info@delozone.com
www.delozone.com
EPA Estab. No. 071472-CA-001
4-2122-01 Rev.A
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>