Jaycar New Zealand GH2038 Brass Monkey Portable Low Profile Dual Zone Fridge Freezer Instruction Manual

Jaycar New Zealand GH2038 Brass Monkey Portable Low Profile Dual Zone

Fridge Freezer

FAQs

• Q: Can I use the fridge with both AC and DC power sources simultaneously?
  • A: No, it is not recommended to use both power sources at the same time to avoid potential damage.

WARNINGS & SAFETY INFORMATION

WARNING: The manufacturer is not responsible for any potential injury from misuse

Warnings

• Do not operate the appliance if it is visibly damaged.
• Do not block the gaps in the fridge with things like pins or wires, etc.
• Do not expose the appliance to rain or immerse it in water.
• Do not place the appliance near naked flames or other heat sources (heaters, direct sunlight, gas ovens, etc.)
• Do not store any explosive substances like spray cans with a flammable propellant.
• Ensure the supply cord is dry and not trapped or damaged. Do not locate multiple portable socket outlets or portable power supplies at the rear of the appliance.
• Check the voltage specification on the type plate corresponds to that of the energy supply. The appliance is only to be used with the power supply unit provided with the appliance.
• Do not use electrical appliances inside the food storage compartments of the appliance, unless they are of the type recommended by the manufacturer.
• Once unpacked and before turning on, the appliance must be placed on a level surface for more than 6 hours.
• Make sure that the appliance stays horizontal when it is running. The tilt angle must be less than 5° for long-time running and less than 45° for short-time running.
• Keep the ventilation openings in the unit casing or the built-in structure free of obstacles.
• Keep the appliance stable on the ground or in the car; Do not drain upside down.

Caution

• Repairs may only be carried out by qualified personnel. Incorrect repair may cause danger. The lamp and supply cord must be replaced by the manufacturer or qualified persons.
• The installation of DC power in a boat must be handled by qualified electricians.
• Children shall not play with the appliance. Cleaning and user maintenance shall not be done by children without supervision.
• The appliance can be used by children aged 8 years and above and persons with reduced physical, sensory, or mental capabilities or lack of experience and knowledge if they’ve been given supervision or instruction concerning the use of the device in a safe way and understand the hazards.

Notice

• Disconnect the power supply before each cleaning and maintenance and after every use.
• Do not use sharp tools to defrost; Do not damage the refrigerant circuit.
• Risk of child entrapment. Before you throw away your old refrigerator or freezer: take off the doors: and leave the shelves in place so that children may not easily climb inside.
• Check if the cooling capacity of the appliance is suitable for storing food or medicine. Food may only be stored in its original packaging or suitable containers.
• If the appliance is left empty for long periods, switch it off, defrost, clean, dry, and leave the door open to prevent mold from developing within the appliance.
• The appliance is intended to be used in household and similar applications such as:
• Staff kitchen areas in shops, offices, and other working environments;
• Camping, Farmhouses and by clients in hotels, motels, and other residential environments;
• Bed and breakfast type environments;
• Catering and similar non-retail applications.
• Information, illustrations, and specifications in this manual reflect the most current available at the time of publication, are subject to change without prior notice.
• Due to the flammable refrigerant and blowing gas contained in the device, comply with local regulations for disposal.

BEFORE FIRST USE

• Before using your product, please read all the safety and operating instructions thoroughly. Please ensure you follow the steps below before using the product. We recommend you keep the original packaging for storing the product when not in use.
• Please pay close attention to the section entitled Warnings & Safety Information. Find a safe and convenient place to keep this instruction manual for future reference.
• Unpack the product but retain all packaging materials until you are satisfied that your new product is undamaged and in working order. Ensure you have all accessories listed in this manual.

FEATURES

• Dual Zone – Fridge / Freezer operation.
• Optional removable 15.6AH or 7.8AH battery
• Solar charging interface
• Detachable lids – pivot point reversible
• With wheels and telescopic handle
• DC power connections
• Powered by AC using the AC to DC power adapter
• High-efficiency DC compressor and conversion module
• Dual mode operation (Max & Economy)
• Digital temperature display with adjustable control
• 3 Year Warranty
• 3-stage low voltage battery protection
• APP control Via Bluetooth

BOX CONTENTS

• 1 x 95L Portable Dual Zone Fridge/Freezer
• 1 x 240V Mains Power Adaptor
• 1 x 12/24V Cigarette Lighter/Merit Car Charger

PRODUCT DIAGRAM

PRODUCT DIMENSIONS

OPERATION

How to Turn on the Fridge

1. Connect to power
2. Press to switch ON, and long press for three seconds to switch OFF.
3. The internal temperature will display and the compressor will start
4. SET: Press the button to enter different modes, ECO (Energy Saving Mode), and MAX (Fast Cooling Mode). Factory setting is Max
5. When the power is on and the dual temperature zone is set to valid, press the “+” or “-” button to enter the left zone temperature setting, and then press the button to switch the left or right box temperature setting. Press “+” or “-” to adjust the temperature.
6. In the power-on state, long press the buttons “+” button for 3 seconds to turn the left zone on or off, note: the setting temperature of the left compartment must not be lower than that of the right compartment and the right compartment cannot be turned off separately.

POWER SUPPLY AND CHARGING

• Power Supply: The refrigerator can be powered by 12V / 24V DC power
• 100-240V AC (adapter included)
• Optional removable Lithium battery if there is no connection of DC/ AC power. DC/ AC power will run the refrigerator, and charge the optional removable battery simultaneously.
• Battery Charging: There are three types of charging methods. 12V/24V DC power, 100-240V AC with adapter, or solar panel (12V-50V).

WARNING: Do not open or disassemble the battery. Only use approved chargers with the fridge battery, incorrect chargers may result in fire, damage, and a shortened battery life. Do not disassemble, impact, squeeze, crush, or throw, or misuse the fridge battery, do not dispose of it in fire, any of which may result in a short circuit and fire or explosion. If there is swelling and heating of the fridge battery do not continue to use it, it may result in fire or explosion, do not use the battery if it is wet.

Battery Operation

Long press on the battery to switch ON/OFF the battery

Tips to make the battery last longer:

1. Switch to ECO mode by pressing on the fridge panel;
2. Set the battery protection to “L” mode (very important setting to make the battery work longer time)
3. Pre-chill the fridge to your ideal temperature in advance;
4. Do not open the door frequently;
5. Do not set the temperature too low if not necessary.

Solar Panel Charge Connection

Insert the solar charge cable into the refrigerator’s Solar charge interface

• Max Solar Input Voltage: 50V
• Max Solar input Current: 10A

Checking Charge Status: When the refrigerator is powered

• ON and DC / AC power is connected, and the battery icon on the display screen will flash to show charging.
• To charge the fridge/freezer battery without running the compressor, simply connect the adapters without power “ON” the fridge.
• To view the charging status please press and hold the button for 3 seconds.
• The fridge’s battery status and voltage will be displayed.
• When the voltage reaches 12.6V and the battery icon stops flashing, the unit has been fully charged and the wiring should be disconnected to prevent the internal components from being damaged.

WARNING: Do not charge fridge/freezer with DC 12V and Solar Panel at the same time! The fridge could be seriously damaged and pose a potential hazard to you.

AC Charging Management

• If the fridge has not been used for a long time, the battery may be discharged, and the fridge will not power on. Please use the AC adapter to charge the fridge battery and run the fridge.
• After the fridge battery has charged up to 30%, you can switch to other methods for charging.

Car Cigarette Lighter Charging Management

• The product has a three-level battery protection function, which not only guarantees the normal operation of the product but also protects the battery of the vehicle.

• When in the power-on state, long press the SET button for 3 seconds, and the display screen flashes H, select low voltage production L(ow), M(medium), and High) by clicking button . The factory default is set to L(ow) protection.

• H should be set when the product is connected to car power, and M or L should be set when it is connected to a portable battery or other backup battery.

• Because of the different output voltages between vehicles, the battery protection level can be set from H to M or from M to L if there is a voltage protection code F1 shown on the panel.

• The battery protection level should be set to H if the product will keep working after turning off the car engine, or if the product may drain the battery.

Solar Charging Management

• To make sure your fridge is being charged by a solar panel, please turn the fridge on first. The battery icon will flash on the display screen to show the charging status.
• The fridge can be turned off while it is being charged. Press and hold the button for over 3 seconds to check the battery status and voltage.
• An extension cable may be required to keep the fridge in a cool place (to avoid overheating) while the solar panel is in the sun.
• Input power for charging should be higher than the refrigerator power draw (about 40-45w), otherwise the optional battery will not charge at the same time.
• To ensure that solar charging power is higher than refrigerator working power, a 100-watt solar panel is advised.

BATTERY USAGE

Optional Removable Battery: The lithium battery is backup power to keep the refrigerator working for short periods while off the grid.
Notice: When not using the battery power or fridge for a long time, please turn off the battery output. (Hold the setting button for 3 Sec).

Maintain Battery Charge:

1. Home / Hotel: Use an AC adapter to charge the unit from AC outlet.
2. Car / Boat: Use a DC port to power the fridge and charge the battery.
3. Off Grid: Put the optional battery inside the battery compartment of the fridge, and connect the optional solar panel to the fridge. Or use a portable 12V power system / solar system. Do NOT connect the solar panel directly to the battery.

Extended battery usage:

1. Cool down the fridge before your journey: It is always suggested to charge the fridge battery and cool the fridge down in advance with the mains to DC adapter from the wall outlet the day before the trip. To prepare for off-grid fridge usage, place food and beverages inside the fridge for cooling the day before. This will not only keep the optional battery more durable but also save energy for outdoor activities once in battery mode.
2. Disconnecting the Battery: The battery can be removed or disconnected with the side button. This prevents the battery from discharging. The product will work from the AC adapter or car outlet without the optional battery installed. Note: Please charge fully the optional battery before it is put into storage 1 month or more.

FOOD STORAGE

• Freezer (-4° F~32° F)(-20°C~0°C):
  • Meat should be cut and packed properly when placed in the fridge.
  • Do not put the fresh food and frozen food together.
  • Do not store glass containers or other containers which seal in liquid in the freezer, to avoid explosion.
• Refrigerator (32° F~50° F)(0°C~10°C):
  • Egg, butter, milk, and bottled drinks can be stored.
  • All food should be packed appropriately before being stored in the fridge.
  • Place food in the refrigerator after it gets cool to save energy.

TROUBLESHOOTING

•    Check if the plug and socket are connected well.

•    Check if the fuse has been burnt.

•    Check if the power supply is malfunctioned.

•    Switch on/off the fridge frequently may cause a start delay in the compressor

Refrigerator compartments are too warm| •    The lid is opened frequently.

•    A large amount of warm or hot food was stored recently.

•    The refrigerator has been disconnected for a long time.

Food is frozen| The temperature was set too low
There is a “water flow” noise from inside the refrigerator| It’s a normal phenomenon, caused by the flow of refrigerant.
There are waterdrops around the refrigerator casing or door gap| It’s a normal phenomenon, the moisture will condense to water when it touches the cold surface of the refrigerator.
The compressor is slightly noisy when starting| It’s a normal phenomenon, the noise will be reduced after the compressor works stably.
Code Fl displayed| Possible cause: low voltage to the fridge. Adjust the battery protection from High to Medium or from Medium to Low.
Code F2 displayed| Possible cause: The condenser fan is overloaded. Disconnect power to fridge for 5 minutes & re-start. If the code shows again, contact the manufacturer for service.
Code F3 displayed| Possible cause: the compressor starts too frequently. Disconnect power to fridge for 5 minutes & re-start. If the code shows again, contact the manufacturer for service.
Code F4 displayed| Possible cause: compressor not kicking in. Disconnect power to fridge for 5 minutes & re-start. If the code shows again, contact the manufacturer for service
Code F5 displayed| Possible cause: overheating of the compressor & electronics. Disconnect power to fridge for 5 minutes & re-start. If the code shows again, contact the manufacturer for service.
Code F6 displayed| Possible cause: no parameter can be detected by the controller. Disconnect power to fridge for 5 minutes & re-start. If the code shows again, contact the manufacturer for service.
Code F7 or F8 displayed| Possible cause: temperature sensor is faulty. Contact manufacturer for service.

SPECIFICATIONS

temperature)
Rated Current for AC (Adaptor):| 1.5A – 0.7A
Rated Current for DC:| 6.0A(12V)/3.0A(24V)
Power Supply| 12/24VDC (Car Charger) 240VAC to 12VDC (Mains Power Adaptor)
Net Weight| 26.5 kg
Gross Weight| 29.3 kg
Dimensions| 896(L) x 462(H) × 571(D)mm

CLEANING, CARE, STORAGE & MAINTENANCE

WARNING: Never use hard or sharp tools to remove ice or to loosen objects frozen in place.

Cleaning

• Unplug the device first to avoid electric shock.
• Use a wet cloth to clean the device and dry it.
• Remove the cover and drain from the hole at the bottom of the device.
• Do not soak the device in water and do not wash it directly.
• Do not use abrasive cleaning agents as these can damage the device.

Storage

• If the device will not be in use for a long time, please follow the steps:
• Turn off the power and remove the plug.
• Remove all the items stored in the device.
• Remove the cover and drain from the hole, wipe off excess water with a soft rag.
• Leave the lid slightly open to prevent odor formation.
• Put the device in a cool and dry place.

Defrosting

• Humidity can form frost in the interior of the cooling device or on the evaporator, which will affect the cooling performance. Defrost the device regularly to avoid this.
• Switch off the device.
• Take out the contents of the device.
• Keep the lid open.
• Remove the cover and drain from the hole.
• Wipe off the defrosted water.

SMART CONTROL – FRIDGE APP INSTRUCTIONS Downloading the “BRASS MONKEY” Application

• Downloading the “BRASS MONKEY” Application
• Using a pre-installed QR reader on your handheld smart device scan the QR code in the manual or on the carton, or search for the “BRASS MONKEY” APP in the iTunes”App Store (for Apple” devices) or Google store (Android Devices)
• Start the application and select the Search function.
• The application will prompt you to pair the fridge by pressing the set button to on the fridge’s control panel. Once the set button has been activated, the fridge will be paired with your smart device and the application will switch to a control panel allowing you to control the fridge’s functions.

1. SET
2. Freezer zone current temperature
3. Refrigerator zone current temperature
4. Battery protection model: High/Medium/Low
5. Turn ON/OFF the fridge
6. Current-voltage
7. Battery capacity (Battery is not supported on this model)
8. Freezer zone temperature setting
9. Refrigerator zone temperature setting
10. DECO ( Energy-saving) / MAX(Fast cooling) mode switch
11. Children’s Lock/ Unlock
12. Celsisus / Fahrenheit switch
13. Unpair the device and return to Search

Note: Click the lock icon on the APP to lock/unlock the control panel on the fridge, if locked, the fridge can only be controlled by the APP. Please scan the QR code to download APP.

WARRANTY INFORMATION

• Our product is guaranteed to be free from manufacturing defects for 3 years.
• If your product becomes defective during this period, Electus Distribution will repair, replace, or refund where a product is faulty; or not fit for the intended purpose.
• This warranty will not cover modified products; misuse or abuse of the product contrary to user instructions or packaging label; change of mind and normal wear and tear.
• Our goods come with guarantees that cannot be excluded under the Australian Consumer Law. You are entitled to a replacement or refund for a major failure and compensation for any other reasonably foreseeable loss or damage.
• You are also entitled to have the goods repaired or replaced if the goods fail to be of acceptable quality and failure does not amount to a major failure.
• To claim a warranty, please contact the place of purchase. You will need to show a receipt or other proof of purchase. Additional information may be required to process your claim.
• Any expenses relating to the return of your product to the store will normally have to be paid by you.
• The benefits to the customer given by this warranty are in addition to other rights and remedies of the Australian Consumer Law concerning the goods or services to which this warranty relates.

CONTACT INFORMATION

• Electus Distribution
• Address 46 Eastern Creek Drive, Eastern Creek NSW 2766
• Ph. 1300 738 555

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>