DOMETIC Drawer Minibar DM50NTE Installation Guide

DOMETIC Drawer Minibar DM50NTE Installation

© 2021 Dometic Group. The visual appearance of the contents of this manual is protected by copyright and design law. The underlying technical design and the products contained herein may be protected by design, patent or be patent pending. The trademarks mentioned in this manual belong to Dometic Sweden AB.
All rights are reserved.

Please read these instructions carefully and follow all instructions, guidelines, and warnings included in this product manual in order to ensure that you install, use, and maintain the product properly at all times. These instructions MUST stay with this product.

By using the product, you hereby confirm that you have read all instructions, guidelines, and warnings carefully and that you understand and agree to abide by the terms and conditions as set forth herein. You agree to use this product only for the intended purpose and application and in accordance with the instructions, guidelines, and warnings as set forth in this product manual as well as in accordance with all applicable laws and regulations. A failure to read and follow the instructions and warnings set forth herein may result in an injury to yourself and others, damage to your product or damage to other property in the vicinity. This product manual, including the instructions, guidelines, and warnings, and related documentation, may be subject to changes and updates. For up-to-date product information, please visit dometic.com.

Explanation of symbols

Safety instructions

General safety
WARNING! Failure to obey these warnings could result in death or serious injury.
Electrocution hazard

• Ensure that the minibar has been installed by a qualified technician in accordance with the Dometic installation manual.
• Do not operate the minibar if it is visibly damaged.
• If this minibar’s power cable is damaged, it must be replaced by the manufacturer, service agent or a similarly qualified person in order to prevent safety hazards.
• This minibar may only be repaired by qualified personnel. Inadequate repairs may cause serious hazards.
• When positioning the minibar, ensure the supply cord is not trapped or damaged.
• Do not locate multiple portable socket-outlets or portable power sup-plies at the rear of the appliance.

Fire hazard

• The refrigerant in the refrigerant circuit is highly flammable.
  In the event of any damage to the refrigerant circuit:

  • Switch off the minibar.
  • Avoid naked flames and sparks.
  • Air the room well.

• Keep ventilation openings, in the minibar enclosure or in the built-in structure, clear of obstruction.

• Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.

• Do not open the refrigerant circuit under any circumstances.

• Do not use electrical devices inside the minibar unless they are recommended by the manufacturer for that purpose.

Explosion hazard

• Do not store any explosive substances, such as spray cans with propellants, in the minibar.

Health hazard

• This minibar can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the minibar in a safe way and understand the hazards involved.
• Children shall not play with the minibar.
• Cleaning and user maintenance shall not be made by children without supervision.
• Children aged from 3 to 8 years are allowed to load and unload the minibar.

CAUTION! Failure to obey these cautions could result in minor or moderate injury.
Risk of crushing

• Do not put your fingers into the hinge.

Health hazard

• Foodstuff may only be stored in its original packaging or in suitable containers.

NOTICE! Damage hazard

• Check that the voltage specification on the type plate is the same as that of the power supply.
• The minibar is not suitable for storing substances which are caustic or contain solvents.
• The insulation of the cooling device contains flammable cyclopentane and requires special disposal procedures. Deliver the cooling device at the end of its life-cycle to an appropriate recycling center.
• Keep the drainage outlet clean at all times.
• Only carry the minibar upright.

Operating the minibar safely

DANGER! Failure to obey these warnings will result in death or serious injury.

Electrocution hazard

• Do not touch exposed cables with your bare hands.

C AUTION Failure to obey these cautions could result in minor or moderate injury.
Electrocution hazard

• Before starting the minibar, ensure that the power supply line and the plug are dry.

Health hazard

• Make sure that you only put items in the minibar which may be chilled at the selected temperature.
• Food may only be stored in its original packaging or in suitable containers.
• Opening the door for long periods can cause significant increase of the temperature in the compartments of the minibar.
• Clean regularly surfaces that can come in contact with food and accessible drainage systems.
• If the minibar is left empty for long periods:
  • Switch off the minibar.
  • Defrost the minibar.
  • Clean and dry the minibar.
  • Leave the door open to prevent mould developing within the minibar.

NOTICE! Damage hazard

• Do not place it near naked flames or other heat sources (heaters, direct sunlight, gas ovens etc.).
• Never immerse the minibar in water.
• Protect the minibar and the cable against heat and moisture.
• Make sure that foodstuffs do not touch the walls of the cooling area.

Scope of delivery

The following main alternatives are obtainable:

• Minibar DM50NTE D with door panel, without lock
• Minibar DM50NTE D with door panel, with lock
• Minibar DM50NTE F without door panel, without lock
• Minibar DM50NTE F without door panel, with lock

Quantity| Description|
---|---|---
1| Minibar|
1| Cable for 230 Vw connection|
4| Screw ø4 x 45 mm (Installation)|
4| Plug (Installation)|
1| Handle| DM50NTE D only
2| Plug (Handle installation)| DM50NTE D only
1| Inlet filter|
6| Screw ø3 x 12 mm (Filter installation)|
2| Plug (Wooden panel)| DM50NTE F wooden version only
1| Lock decor (Wooden panel)| DM50NTE F wooden version with lock only
2| Key| Lock version only
1| Installation and Operating manual|

Intended use

The refrigeration appliance (also referred to as minibar) is intended to be used in household and similar applications such as:

• Staff kitchens in stores, offices and other work areas
• Farmhouses
• By clients in hotels, motels and other residential type environments
• Bed and breakfast type environments
• Catering and similar non-retail applications

Technical description

The minibar is not suitable for installation in caravans or mobile homes.
The minibar is intended for installation in a piece of cabinetry or an installation niche.
The minibar is designed exclusively for cooling and storing of beverages and foods in closed containers.
The minibar is not suitable for storing fresh foods and medicine or freezing food-stuffs.
This minibar is only suitable for the intended purpose and application in accordance with these instructions.
This manual provides information that is necessary for proper installation and/or operation of the minibar. Poor installation and/or improper operating or mainte-nance will result in unsatisfactory performance and a possible failure.
The manufacturer accepts no liability for any injury or damage to the product resulting from:

• Incorrect assembly or connection, including excess voltage
• Incorrect maintenance or use of spare parts other than original spare parts provided by the manufacturer
• Alterations to the product without express permission from the manufacturer
• Use for purposes other than those described in this manual
  Dometic reserves the right to change product appearance and product specifications.

The minibar has a main drawer for bottles and cans as well as a mini drawer for miniatures and snacks. The main drawer has room for 33 bottles with a maximum height of 28 cm.

The minibar DM50NTE D comes with a anthracite panel and pull handle.

The minibar DM50NTE F is delivered without panel and is prepared for fitting the hotel’s own door decor.
A lock is optionally available.

Description of the device

Installation

CAUTION! Health hazard
To avoid a hazard due to instability of the device, it must be fixed in accordance with the instructions.
Notes on mounting into furniture
You can mount the minibar in four ways into furniture. Choose your favoured alternative according to fig. 6, page 6.
Observe the following:

• The cut-out dimensions H x W x D are:
  • DM50NTED: 438x570x504mm
  • DM50NTE F: 438 x 570 x (502 + d) mm d is the thickness of the hotel‘s own decor
• The clearance between the minibar‘s back and the furniture wall should be approx. 15 mm.
• The ventilation openings for the chosen alternative have to be produced as shown in fig. 6, page 6.
• Air passing through the inlet air duct must not be heated by any heat sources (heaters, direct sunlight, gas ovens etc.).

Pressing out the ventilation opening
fig. 7, page 7, fig. 8, page 7

Produce a ventilation opening of 75 x 550 mm in the bottom of the furniture into which you place the minibar.
Measure the distance of 504 mm from the minibar‘s door front excluding any own decor.

Mounting the minibar into a piece of furniture

➤ Fasten the minibar with the four screws ø4 x 45 mm (fig. 9 1, page 7).
➤ Insert the four plugs (fig. 9 2, page 7) into the boring.

Connecting the minibar electrically

Plug the 230 V connection cable into the AC voltage socket and connect it to the 230 V AC mains supply.
✔ The Power Status LED lights up.
✔ The lamp lights up and the minibar starts cooling the interior.

Mounting hotel’s own door decor (DM50NTE F only)
The hotel’s own door decor has to comply with the following requirements:

• Maximum weight: 4 kg
• Maximum thickness: 18 mm (lock version only)
  ➤ Fasten the decor with four screws.

Mounting the lock (lock version only)
➤ Drill a hole with a diameter of 35 mm into the decor.
➤ Mount the lock together with the lock decor.

Mounting the lock (no lock version only)
Disassembling the drawer (fig. 0, page 8)
➤ Open the drawer completely (A).
➤ Press the rail lock (A1).
➤ Pull the drawer out of the cabinet (B).

Only for DM50NTE D:
➤ Remove the two plugs (C1) from the screws (C2) of the door handle (C3).
➤ Unscrew the two screws (C2) of the door handle.
➤ Remove the door handle (C3).
➤ Remove the gasket.
➤ Remove the lock cover.

Drilling the holes (fig.11, page 8)
➤ Drill a hole (A1) with a diameter of 23.6 mm through the decor (only DM50NTE D) and the door.
➤ Unscrew the twelve screws (B1) of the decor frame (B2) (only DM50NTE D).
➤ Remove the decor frame (only DM50NTE D).

Assembling the lock (fig. b, page 9)
➤ Put the new lock cover (A1) into place.
➤ Put the decor (B1) into the decor frame.
➤ Screw (B2) the decor frame (B3) onto the door.
➤ Install the door lock (C1).
➤ Install the lock catch (D1) in the cabinet.

Assembling the drawer (fig. c, page 9)
➤ Push the gasket (1) on the decor frame (2).
➤ Screw the door handle (4) onto the door.
➤ Push the plugs (3) on the screws of the door handle (4).
➤ Push the drawer into the cabinet.

Operation

WARNING! Fire hazard

• When positioning the device, ensure the supply cord is not trapped or damaged.
• Do not locate multiple portable socket-outlets or portable power supplies at the rear of the device.

NOTICE Damage hazard
The lamp can only be replaced by the manufacturer, a service agent or similarly qualified person to avoid hazard.

Saving energy

• Only open the minibar as often and for as long as necessary.
• Avoid unnecessarily low temperature settings.
• For optimal energy consumption, position the shelves and drawers according to their position on delivery.
• On a regularly basis, make sure the door seal still fits properly.
• Clean dust and dirt from the condenser at regular intervals.

Using the minibar
The minibar starts cooling when connected to power. During normal operation the Power Status LED is glowing. If an error occurs the Error LED is blinking (see chapter “Troubleshooting” on page 22).

Using the temperature setting function
To avoid food waste, note the following:

• Keep temperature fluctuation as low as possible. Only open the minibar as often and for as long as necessary. Store the foodstuff in such a way that the air can still circulate well.
• The minibar is equipped with an automatic temperature regulation function. Select the average of the possible temperature values.
• Adjust the temperature to the quantity and type of the foodstuff.
  The minibar is set by default to a cooling temperature of 7 °C at an ambient temperature of 25 °C.

You can use the setting button (fig. 3 4, page 4) to set the cooling temperature to one of three values (5 °C, 12 °C and 7 °C).
Thereby the temperature will be changed in the order 5 °C … 12 °C … 7 °C … 5 °C etc.

➤ Press the setting button (fig. 3 4, page 4) and keep it pressed for 5 s, until the internal lamp (fig. 3 1, page 4) starts to blink.
➤ Press immediately the setting button (fig. 3 4, page 4) again.

✔ The internal lamp (fig. 3 1, page 4) indicates the setting temperature:
– 5 °C: the lamp flashes five times in three intervals
– 12 °C: the lamp flashes once in three intervals
– 7 °C: the lamp flashes three times in three intervals

NOTE
The minibar sets the cooling temperature automatically to 7 °C, when it is connected to a power source.

Troubleshooting

Cleaning and maintenance

NOTICE! Damage hazard

• Never clean the cooler under running water or in dish water.
• Do not use abrasive cleaning agents or hard objects during cleaning as these can damage the cooler.

➤ Occasionally clean the device interior and exterior with a damp cloth.
➤ Make sure that the air inlet and outlet vents on the device are free of any dust and dirt, so that heat can be released and the device is not damaged.
➤ Occasionally clean the inlet filter.
➤ If you find water in the drip tray (fig. 2 3, page 3) check whether the drainage system is blocked.

Warranty

The statutory warranty period applies. If the product is defective, please contact your retailer or the manufacturer’s branch in your country (see dometic.com/dealer).
For repair and warranty processing, please include the following documents when you send in the product:

• A copy of the receipt with purchasing date
• A reason for the claim or description of the fault

Disposal

Place the packaging material in the appropriate recycling waste bins, wherever possible.
If you wish to finally dispose of the product, ask your local recycling center or specialist dealer for details about how to do this in accordance with the applicable disposal regulations.

Technical data

| DM50NTE D| DM50NTE F
---|---|---
Voltage:| 100 – 240 Vw, 50 – 60 Hz
Cooling capacity:| max. 21 °C below ambient temperature (adjustable in three steps: 5 °C, 7 °C, 12 °C)
Category:| 2 (Cellar)
Total volume:| 49 l
Energy efficiency class:| G
Power consumption:| 158 kWh/annum
Climatic class:| N
Refrigerant quantity:| 28 g (R600a)
Dimensions main drawer W x D x H:| 430 x 330 x 302 mm
Dimensions mini drawer W x D x H:| 159 x 285 x 88 mm
Dimensions W x D x H (see also fig. 7, page 7):| 550 x 517 x 418 mm| 550 x 487 x 418 mm
Maximum internal storage load:| 31 kg
Weight:| 23.5 kg| 23.0 kg
Inspection/certification:| ****

The cooling unit is hermetically sealed.
Further product information can be accessed via QR code on the energy label in the figures or via eprel.ec.europa.eu.

dometic.com
YOUR LOCAL DEALER                        YOUR LOCAL SUPPORT YOUR LOCAL SALES OFFICE
dometic.com/dealer dometic.com/contact      domestic.com/sales-offices

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>