GARDENA 11130 Pressure Sprayer User Manual

5L Comfort Art. 11130

Operator’s manual
Pressure Sprayer

GARDENA Pressure Sprayer 5L Comfort

Translation of the original instructions. Please read the operating instructions carefully and observe the notes given. Use the instructions to familiarise yourself with the Pressure Sprayer, its proper use, and the notes on safety. For safety reasons, children under 16 as well as persons not familiar with these operating instructions must not use the Pressure Sprayer. Never operate the product when you are tired, ill, or under the influence of alcohol, drugs, or medicine. Read the operator’s manual carefully before use and keep for future reference.
Intended use:
The GARDENA Pressure Sprayer is intended for distributing solvent-free liquid pesticides 1), herbicides 1), fertilizers 1), window cleaners 1), and car wax

1. in domestic gardens and allotments. It must not be used in public places, parks, sports arenas, or in agriculture or forestry. Compliance with the specifications in this operating manual is a requirement for the proper use of the Pressure Sprayer. 1) According to the Plant Protection Law as well as the Detergents and Cleaning Agents Law, only approved agents may be used (authorized specialist dealers).
   Please note:
   Due to the risk of physical injury, the GARDENA Pressure Sprayer must not be used for spraying substances other than those specified by GARDENA. Also, no acids, disinfectants, or impregnators, aggressive and solvent-containing cleaning agents, petrol or spray oil may be sprayed.

SAFETY

The danger of physical injuries:
Never open the Pressure Sprayer or unscrew the nozzle when the Pressure Sprayer is still pressurized. To prevent injury, never connect the Pressure Sprayer to an air compressor. Always hold the Pressure Sprayer upright before the safety relief valve (9) (Fig. O1) is pulled. When spraying insecticides, herbicides and fungicides, or other liquid plant protection products, you must comply with all special precautionary measures specified by the manufacturer of the product you are using. Before each opening of the Pressure Sprayer, thoroughly release pressure by pulling the safety relief valve (9). DANGER! Small parts can be easily swallowed. There is also a risk that the polybag can suffocate toddlers. Keep toddlers away when you assemble the product.
Operation:
CAUTION: The tank may only be filled with a maximum of 5 liters of liquid. Inspect the Pressure Sprayer visually before each use. Never leave your Pressure Sprayer unattended or for long periods when full and pressurized. Keep the unit out of the reach of children. You are responsible for the safety of others. Keep your Pressure Sprayer away from heat sources and hot environments. Screw on the pump handle (10) tightly by hand (do not use tools) and ensure that the O-ring (15) (Fig. O1) is positioned correctly.
Cleaning:
Release the pressure after each use, empty the container, clean it carefully and rinse with clear water. Then leave the pressure sprayer open and allow it to dry. Do not dispose of residual fluids in the sewerage system (local disposal systems). Always clean the Pressure Sprayer before using a different product to avoid chemical reactions. When using several Pressure Sprayers, the tanks and spray nozzle may not be exchanged between them. We recommend that you have your Pressure Sprayer thoroughly inspected (preferably at a GARDENA Service Centre) after using it for 5 years. Storage:
Before storing, loosen the tank cap and always empty your Pressure Sprayer completely (also after cleaning with water). Store away from frost. If you use the permanent lock (13) (Fig. O3) pay attention that you work very carefully. Carry the pressure sprayer only by the locked pump handle (10). Make sure that the product is protected from direct sunlight. The product may heat up.

ASSEMBLY

1. Fig. A1: Slide the spray lance (1) into the hand valve (2) and screw on the union nut (3).
2. Fig. A2: Slide the spray hose (4) into the hand valve and screw on the union nut (5).
3. Fig. A3: Slide the spray hose (4) into the container and screw on the union nut (7).
4. Fig. A4: Attach the carrying strap (8) to the container (6).

OPERATION

Please observe the safety and proportioning instructions provided by the manufacturer of the product you are going to spray.

To spray the liquid [Fig. O1/O2/O3 ]:

1. Pull the safety relief valve (9).
2. Unscrew the pump handle (10) counterclockwise and fill the container.
3. Screw the pump handle (10) clockwise again firmly into the container.
4. Release the locking device (17) until it is between the two stops of the thread (15).
5. Pump with the pump handle (10).
6. Adjust the spray jet via the nozzle (11) (clockwise rotation v spray mist; counterclockwise rotation v spray jet).
7. Push the button (12) to spray the liquid. If necessary, you can lock the button (12) with the permanent lock (13).

MAINTENANCE

To clean the pressure sprayer:
Always clean your Pressure Sprayer after spraying. Use the Pressure Sprayer only with clear water (possibly with the addition of dish detergent) and spray empty. The valves, the spray lance (1), the nozzle (11), and the filter (14) are cleaned. In the case of outer dirtying of cover and tank, thoroughly clean the area thread and thread-O-ring (15). Check the safety relief valve (9) for smooth running.

STORAGE

To put into storage:

1. Clean the pressure sprayer (see 4. MAINTENANCE).
2. Store the pressure sprayer in a frost-free place.

TROUBLESHOOTING

To clean the filter [ Fig. T1 ]:
v Unscrew the spray lance (1), remove the filter (14), and clean it.

→Screw on a pump handle (10) tighter.
The hose connection at the container and hand valve is not tight.| →Tighten the hose connections at the container and hand valve.
The permanent lock (13) on the handle is locked.| →Release the permanent lock (13) on the handle.
Sealing cap (16) is dirty/ defective.| →Clean/exchange sealing cap (16).
Pressure Sprayer does not spray although there is sufficient pressure or only sprays with a weak spray jet| Nozzle (11) is blocked.→| Unscrew nozzle (11)and clean.
Filter (14) is clogged.| →Remove filter (14)from the
spray lance and clean it.
It is difficult to open and close the container| Container pressure too high.| →Release the container pressure completely by means of the safety relief valve (9).

NOTE: For any other malfunctions please contact the GARDENA service department.

TECHNICAL DATA

SERVICE / WARRANTY

In the event of a warranty claim, no charge is levied to you for the services provided.
GARDENA Manufacturing GmbH offers a two-year warranty (effective as of the date of purchase) for this product. This warranty includes all significant defects of the product that can be proved to be material or manufacturing faults. This warranty is fulfilled by supplying a fully functional replacement product or by repairing the faulty product sent to us free of charge; we reserve the right to choose between these options. This service is subject to the following provisions: The product was used for its intended purpose as per the recommendations in the operating instructions. Neither the purchaser nor a third party has attempted to repair the product. This manufacturer’s warranty does not affect warranty entitlements against the dealer/retailer. If problems arise with this product, please contact our Service department or send the defective product along with a brief description of the fault to GARDENA Manufacturing GmbH, making sure to have sufficiently covered any shipping costs and to have followed the relevant postage and packaging guidelines. A warranty claim must be accompanied by a copy of the proof of purchase.

Canada / USA
GARDENA Canada Ltd.
100 Summerlea Road
Brampton, Ontario L6T 4X3
Phone: (+1) 905 792 93 30
info@gardenacanada.co

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>