Mr Outdoor COOKOUT MOCG15SS Portable Stainless Steel Charcoal Grill Instruction Manual
- June 3, 2024
- Mr Outdoor COOKOUT
Table of Contents
Mr Outdoor COOKOUT MOCG15SS Portable Stainless Steel Charcoal Grill
DANGER: CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide which has no odor.Using it in an
enclosed space can kill you.Never use this appliance in an enclosed space such
as a camper, tent, car or home.
WARNING
- This is an ATTENDED product. Do NOT leave this product unattended while the product is in use. Monitor the product when hot after use. Heated equipment can remain at high temperatures which can cause burns long after operation. Use heat resistant gloves to handle hot tools.
- This product is for OUTDOOR use only. Do NOT use in a building, garage, tent or any other enclosed area. Do NOT use in or on a recreational vehicle or boat. NEVER use this product as a heater.
- Do NOT locate this product under ANY overhead construction, overhanging trees and shrubs. Keep aminimum clearance of 10 ft. (3.05m) from the sides, front and back of the product to ANY construction. Keep the area clear of ANY combustible materials, gasoline and other flammable vapors and liquids. Do NOT use on or under ANY apartment or condo balcony or deck. Never use in high winds.
- Do NOT use under a canopy. Do NOT obstruct flow of combustion air and/or ventilation air for grill.
- When in use the product must be on a level, stable, noncombustible surface such as brick, concrete,stone, or dirt. Not suitable are surfaces such as wood, asphalt or plastic which may burn, blister ormelt.
- Children and pets should be kept away from the product and should be carefully supervised at alltimes. Children and adults should be alerted to the hazards of high surface temperatures and flames and should stay away to avoid burns or clothing ignition.
- The use of alcohol, prescription or non-prescription drugs may impair your ability to properly assembleor safely operate this product. Do NOT assemble or operate this product if using alcohol, prescriptionor non-prescription drugs.
- This product gets dangerously hot in use. Do NOT move the product when in use. Allow the product to coolcompletely before moving or storing. Avoid bumping of or impact with the product. Prevent all contact withthe hot product.
- Burn ONLY charcoal briquettes in your grill.
- Do NOT use gas or kerosene to start the fire in your grill. Never add lighting fluid to hot or warm coalsas a flash back may occur causing serious injury or damage to property.
- ALWAYS use long handled tools to safely handle food and wear oven mitts or gloves to protect yourhands from burns while handling. ALWAYS wear shoes while cooking. Keep hair and clothing fromcoming into contact with the grill while in use or still hot. Ashes can remain warm for a long time afterextinguishing.
- Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this product. An LP-cylinder shall not be stored near this product.
- When operating, have a Type BC or ABC fire extinguisher readily available and adequate fireextinguishing material. Do NOT use water to extinguish a grease fire. This can cause splatter whichcan result in serious burns or damage to property.
- This grill is not intended for commercial use. Use Mr. Outdoors® Cookout products in accordance withstate and local ordinances.
CACALIFORNIA PROPOSITION 65 WARNING: Fuels used in wood or charcoal
burning appl
iances, and the products of combusion of such fuels, can expose you to
chemicals including carbon black, which is known to the state of California to
cause cancer, and carbon monoxide, which is known to the state of California
to cause birth defects or other reproductive harm.
For more information go to:
www.P65Wanings.ca.gov
ASSEMBLY INSTRUCTIONS
- Pay attention to sharp edges of parts while you assemble the grill. It is advisable to wear protective work gloves during the assembly. Before assembling, check that all product components are included in the shipping carton. Identify these product parts from the assembly drawing: Grill Main Cavity with (2) Fold Down Legs, Grill Grate Frame, and Grill Grate. If any of the above parts or the fabric pouch are missing, contact Metal Fusion, Inc. at 1-800-783-3885 between the hours of 7:30 a.m. and 3:00 p.m. CST Monday through Friday for replacements.
- Take the grill main cavity and fabric pouch out of the box. All other components above are stored in the grill main cavity. Remove the grill grate and the grill grate frame from the grill main cavity. Place the grill main cavity upside down on a level surface with the folded legs facing up. Gently unfold the top set of folded legs by carefully lifting the hinged fold down leg set upward and outward as far as it goes until it rests in place (approximately at a 15 degree angle as shown in figure 4). Do the same to open the other set of legs.
- Turn the grill main cavity over with the legs fully opened in place as shown in figure 4.
- Align the edges of the grill grate frame with the sleeve of the grill. Slide the grill grate frame edges into the sleeve until it is completely inserted into place in the grill main cavity as in Figure 3. Make sure the edges of the grill grate frame are inside of the grill grate sleeve to prevent sliding.
- Add charcoal briquettes for grilling (approximately an 8 lb. bag). When adding briquettes make sure not to mound them up. The grill grate should sit flat on the grill frame once briquettes are added. If not adjust briquettes or remove some so that the grill grate sits flat.
- Place the grill on top of the grill grate frame with the prongs pointed down to hold it inside of the grill grate frame and to prevent sliding.
- Follow the charcoal briquette manufacturers lighting and cooking directions for using their product in the grill.
MAINTENANCE & STORAGE
- Make sure ashes have cooled before moving. Ashes should be placed in a non-combustible container after use. Clean ashes out of grill after each use.
- Wash the grill grate with mild soapy water. Do not use strong solvents or scouring pads as they can damage the surface of your grill and leave abrasive marks.
- Dry the product with a non-abrasive rag to make sure the product is free of moisture.
- Place all clean, dry, grill components back into grill main cavity after use. Fold up the fold down legs for storage and store inside of the fabric pouch. Store in dry cool area. To reassemble, follow the assembly instructions.
WARNING: FAILURE TO FOLLOW THESE INSTRUCTIONS AND WARNINGS COULD RESULT IN FIRE, EXPLOSION, BURN HAZARD OR CARBON MONOXIDE POISONING WHICH COULD CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
METAL FUSION, INC. – LIMITED ONE-YEAR WARRANTY
WHAT THIS WARRANTY COVERS
This warranty covers all components of this product to be free from defects in
materials and workmanship, with the exceptions stated below.
HOW LONG COVERAGE LASTS
This warranty runs for one year from the date of purchase. Please keep your
receipt with this manual for future reference.
WHAT IS NOT COVERED
This warranty does not cover the following:
Incidental and Consequential Damages. This warranty does not cover
incidental and consequential damages arising in any way out of the use of this
product. The liability of Metal Fusion, Inc. is, in any event, limited to the
amount of the original purchase price of this product and remains in force
only as long as the product remains in its original, as-built configuration.
Some states do not allow the exclusion or limitation of incidental or
consequential damages, so the above limitation or exclusion may not apply to
you.
Neglectful Operation. This warranty does not cover any loss or damage
arising in any way due to the negligent operation of this product.
Altered, Repaired or Misused Equipment. This warranty does not cover any
loss or damage arising in any way out of the use of this product when it has
been altered, repaired by persons other than Metal Fusion, Inc., or when it
has been abused or misused, or when it has been used other than in accordance
with the manufacturer’s operating instructions.
Other Assumed Responsibilities. Unless otherwise provided by law, this
warranty does not cover any responsibility or liability arising in any way out
of the use of this product where that responsibility or liability was
purportedly assumed by any other person or agent.
Paint, Discoloration, and Rust. This warranty does not cover the paint on
this product, as in a normal use of the product, the paint will be burned off.
Nor does this warranty cover discoloration or rust as these occurrences are
part of the products normal wear and tear.
WHAT METAL FUSION, INC. WILL DO
Metal Fusion, Inc. will repair or replace any product that proves to be
defective in materials or workmanship. In the event repair is not possible or
economically feasible, Metal Fusion, Inc. will replace your product with an
identical or substantially equivalent product. Metal Fusion, Inc. will perform
this service at no charge to you, except for the actual cost of shipping and
handling the outdoor cooker or replacement parts.
HOW TO GET SERVICE
In the event you have a problem or malfunction with your product, simply call
Metal Fusion, Inc. at 800-783-3885.
HOW STATE LAW APPLIES
This warranty gives you specific rights, and you may have other rights which
vary from state to state.
OWNER’S REGISTRATION
Dear Customer,
Thank you for purchasing a Mr. Outdoors® Cookout product! Please take a moment
to fill out your registration form and return it to us. We are always happy to
hear suggestions and comments from our customers about our products.
Completion of this registration allows us to contact you if the need arises.
Please keep your receipt with your instruction manual. It will be necessary as
a proof of purchase for us to help you if there is a problem with your Mr.
Outdoors® Cookout product.
Name:_____
E-Mail:
Address:
Telephone:____
Model#
Date of
Purchase__
Place of
Purchase__
Price Paid____Was this a gift or
did you _____ purchase it yourself?
Comments:
A SATISFIED CUSTOMER IS OUR MAIN GOAL. If you have any questions or problems, please call us at 1-800-783-3885 before returning the product to the point of purchase. Please have your receipt available when calling.
DISTRIBUTED BY: METAL FUSION, INC.
ADDRESS: 712 ST. GEORGE AVE. JEFFERSON, LA 70121
800-783-3885 M-F 7:30-3:00 CST
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>