justanswer AR54.21 converter control unit User Manual
- June 5, 2024
- justanswer
Table of Contents
justanswer AR54.21 converter control unit
Remove and install DC/AC converter control unit
Model 205.0/1/2, 253 with code U67 (230 V socket in rear passenger
compartment)
Shown on model 205.0
- Electrical connector
- Bracket
- Electrical connector
- Nut
N24/3 DC/AC converter control unit
Shown on model 253.9 with code 810 (Sound system)
- Bracket 4 Nuts
- Electrical connector N24/3 DC/AC converter control unit
Warning| Risk of injury caused by fingers being jammed or pinched when removing, installing or aligning hoods, doors, trunk lid/rear-end
door or sliding roof.
| No parts of the body or limbs should be within the operating area when the
components are moving.| AS00.00-Z-0011-01A
---|---|---|---
Danger| Risk of death when working on component parts and systems with U
= 30 V alternating voltage (AC) or U >= 60 V direct voltage (DC)| Do not touch damaged or defective live component parts and lines or non-insulated electrical connections and lines.| AS00.00-Z-0035-01A
Topical note| Information on preventing damage to electronic components due to electrostatic discharge| | AH54.00-P-0001-01A
| Notes on safety-relevant components| | AH00.00-Z-0019-01A
| Notes on HANDS-FREE ACCESS| | AH80.61-P-0001-01A
| Remove/install| |
1.1| Remove right luggage compartment lining.| Model 205.0/1 with code U67 (230 V socket in rear passenger compartment)| AR68.30-P-4600LW
1.2| Release load compartment trim at right in rear| Model 205.2, 253 with code U67 (230 V socket in rear passenger compartment) Model 205.2 with code U67 (230 V socket in rear passenger compartment) Model 253 (except 253.992/993) with code U67 (230 V socket in rear passenger compartment) Model 253.992/993 with code U67 (230 V socket in rear passenger compartment)|
| area far enough to gain access to the DC/AC converter control unit (N24/3).| |
| | | AR68.30-P-1180LWS
| | |
AR68.30-P-1180LWG
| | |
AR68.30-P-1180RFW
2| Detach ground line of on-board electrical system battery.| |
AR54.10-P-0003LW
3| Unclip electrical connector (1) from holder (2).| Model 205.0/1 up to model
year 2019 with code U67 (230 V socket in rear passenger compartment)|
4| Disconnect electrical connector (3) from DC/ AC converter control unit
(N24/3).| Model 205.0/1/2 as of model year 2019 with code U67 (230 V socket
in rear passenger compartment There are two electrical connectors on the DC/
AC converter control unit (N24/3).|
5| Unscrew nuts (4) and remove DC/AC converter control unit (N24/3).| |
6| Remove DC/AC converter control unit (N24/3) from holder (2).| When
replacing DC/AC converter control unit (N24/3).|
7| Install in the reverse order.| |