Char-Broil 24308840 4 Burner Gas Grill Instruction Manual

Char-Broil 24308840 4 Burner Gas Grill

FAQ

• Q: Can I use the barbecue indoors?
  • A: No, it is dangerous to use the barbecue in confined or habitable spaces due to the risk of carbon monoxide poisoning. Always use it outdoors in a well-ventilated area.
• Q: How should I clean the barbecue after use?
  • A: Allow the barbecue to cool down completely before cleaning. Use a grill brush to clean the grates and interior surfaces. Wipe down the exterior with a damp cloth and mild detergent.

Warning

Do not use the barbecue in a confined space and/or habitable space e.g. houses, tent, caravans, motor homes, boats. Danger of carbon monoxide poisoning fatality.

WARNING

• WARNING! This barbecue will become very hot, do not move it during operation.
• Do not use indoors! This grill is for outdoor use only. Use the grill in a well-ventilated area.
• WARNING! Do not use spirit or petrol for lighting or re-lighting! Use only firelighters complying to EN 1860-3!
• WARNING! Keep children and pets away.
• The grill has to be installed on a secure level base prior to use.
• Do not use within 1 m of any flammable structure or under any combustible surface.
• Ash catcher pan must be fully installed during operation. Failure to properly install could result in hot embers falling from grill.
• Burning of solid fuels produces carbon monoxide, which has no odor and can kill! Therefore, never use this appliance indoors or bring indoors if not fully extinguished.
• After a charcoal fire appears extinguished, unconsumed embers can retain heat for up to 24 hours, and if exposed to fresh air, can burst into flame unexpectedly.
• Any such embers outside the firebox of the grill pose a fire hazard and can ignite combustible surfaces such as wooden decks.
• Failure to read and follow instructions for lighting charcoal may result in serious personal injury and/or property damage.
• Always use caution when handling hot coals to prevent injury.
• Always light the fire with the grill lid open.

CAUTION

• Some parts may contain sharp edges! Wear protective gloves if necessary.
• Most surfaces on this unit are hot when in use. Use extreme caution. Do not touch metal parts of the grill until it has completely cooled to avoid burns, unless you are wearing protective gloves.
• THIS UNIT IS HEAVY! DO NOT attempt to assemble without a helper.

WARNING

Please read this entire manual before installation and use of this appliance.
Failure to follow these instructions could result in property damage, bodily injury, or even death. Contact local building or fire officials about restrictions and installation inspection requirements in your area. Save these instructions.

SEE OWNERS MANUAL FOR IMPORTANT SAFETY INFORMATION

• Most surfaces on this unit are hot when in use.Use extreme caution.
• Keep others away from unit.
• Always wear protective clothing to prevent injury during use.
• Keep children and pets away.
• Do not move this unit during operation.
• Never substitute gasoline, kerosene or alcohol for charcoal starter. In some states, the use of charcoal starter is prohibited by law. In this case, paraffin-based starter cubes can be substituted for charcoal starter.
• Never use charcoal starter fluid with an electric starter. After a charcoal fire appears extinguished, unconsumed embers can retain heat for up to 24 hours, and if exposed to fresh air, can burst into flame unexpectedly. Any such embers outside the firebox of the grill pose a fire hazard and can ignite combustible surfaces such as wooden decks.

FAILURE TO READ AND FOLLOW INSTRUCTIONS FOR LIGHTING CHARCOAL MAY RESULT IN SERIOUS PERSONAL INJURY AND OR PROPERTY DAMAGE.
ALWAYS USE CAUTION WHEN HANDLING HOT COALS TO PREVENT INJURY.

ALWAYS LIGHT THE FIRE WITH THE GRILL LID OPEN

After a charcoal fire appears extinguished, unconsumed embers can retain heat for up to 24 hours, and if exposed to fresh air, can burst into flame unexpectedly. Any such embers outside the firebox of the grill pose a fire hazard and can ignite combustible surfaces such as wooden decks.

Safety and Care Advice

• Please read the instruction manual before using the grill!
• Follow all warnings and instructions when using the grill. Failure to read and follow the instructions could result in serious personal injury and/or property damage.
• Keep this manual for future reference.
• If you have any queries regarding these instructions, contact your local dealer.
• Do not use the grill unless it’s completely assembled and all parts are securely fastened and tightened.
• For residential use only. Do not use for commercial cooking.

Operation and Lighting Procedure

• Set up or place grill in a safe location.
• The grill shall be heated up and the fuel kept red hot for at least 30 minutes prior to the first cooking.
• Prior to cooking with your grill the first time:
  1. Brush all interior surfaces, including grills and grates, with vegetable oil.
  2. Build a small fire in the charcoal pan.
  3. Close lid after flames subside, position dampers at approximately ¼ turn open. This burn should be sustained for at least 30 minutes.
• Place charcoal into a pyramid-shaped pile in the center of the charcoal pan.
• Light charcoal. Always light the fire with the lid open. Keep lid open for as long as the charcoal burns with flames.
• Never add charcoal lighter fluid to hot or warm coals as flashbacks may occur causing injury.
• After charcoal appears to have a coating of ash and flames have subsided (12-15 minutes), spread coals evenly across charcoal pan. Replace cooking grids and close lid to pre-heat the cooking surface.
• Do not cook before the fuel has a coating of ash.

MAINTENANCE

• Rust can appear on the inside of your grill. Maintaining a light coat of vegetable oil on the interior surfaces will aid in the protection of your grill.Exterior surfaces of the grill may need occasional touch up. We recommend the use of commercially available black high temperature spray paint. NEVER PAINT THE INTERIOR OF THE GRILL!
• Make sure coals are completely extinguished before cleaning inside of the unit. Thoroughly rinse with water and allow to air dry before using again. Wipe out the interior of the unit with a cloth or paper towels. When finished cooking, and the unit has adequately cooled, clean out all remaining ashes. Ashes collect moisture, which can lead to premature rusting and decay.
• If a bristle brush is used to clean any of the cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

HARDWARE LIST

REPLACEMENT PARTS LIST

NOT Shown

…| 1| HARDWARE PACK
…| 1| PRODUCT GUIDE
…| 1| KIT, SPRING, NUT F/ SMOKE- STACK

REPLACEMENT PARTS DIAGRAM

ASSEMBLY

CAUTION:  THIS UNIT IS HEAVY! DO NOT attempt to assemble without a helper.

Some parts may contain sharp edges – especially as noted in each assembly step! Wear protective gloves if necessary.

Tools required for assembly (Not included)

ASSEMBLY

Finish

Warranty Statement

Char-Broil Europe GmbH Paul-Dessau-Straße 8, Quartier O – 4.OG D-22761 Hamburg, (Char-Broil) warrants to the PURCHASER of this Char-Broil product that it will be free of defects in material and workmanship from the date of purchase as follows:

Char-Broil or the seller of the product may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN YOUR SALES RECEIPT OR INVOICE.

[ France only: All products sold by the Seller are covered by the legal warranties provided in Articles 1641 and followings of the Civil Code (warranty against hidden defects) and Articles L. 217-1 to L. 217-14 and L. 411-1 to L. 411-2 of the Consumer Code (warranty of conformity.]

This Warranty includes the right of repair or replacement of the product or parts of the product that prove defective under normal use and service. Before returning any parts, you should promptly contact Char-Broil using the contact information on our website. In case of a defect, Char-Broil will elect to replace or repair the product or such parts without charge. . Char-Broil will return the product or parts of the product to the purchaser, freight or postage prepaid. If Char-Broil elects to repair the product or such defective parts of the product and this repair fails, you are entitled, pursuant to your statutory legal rights, to reduce the purchase price or to withdraw from the contract and receive a refund.

This Warranty does not cover any failures or operating difficulties due to accident, abuse, misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner’s manual. Exceptions may apply, so please contact Char-Broil or your seller in case you have any questions on whether this Warranty applies to your specific case or not. Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes or tornadoes, discoloration due to exposure to chemicals either directly or in the atmosphere, is not covered by this Warranty, and are not normally covered by your statutory legal rights.

Char-Broil is not liable for any unforeseeable losses (i.e. loss or damage that neither you nor Char-Broil or the seller contemplated at the time of purchase), or any damage caused by you, save for that Char-Broil’s liability for fraud or death or personal injury caused by its negligence is not limited. Char-Broil does not authorize any person or company to assume for it any other obligation or liability in connection with the sale, installation, use, removal, return, or replacement of its equipment; and no such representations are binding on Char- Broil. This Warranty applies only to products sold at retail to individuals (as opposed to businesses) within the European Union.

This Warranty does not affect any of your statutory legal rights under the applicable consumer laws of your resident country.
For warranty service, contact Char-Broil at info-eu@charbroil.com.

NOTE: This information is a guide only. Items included in your BBQ specification may differ depending on region or specific dealer specifications.

All specifications are subject to change without notice.

©2023 Char-Broil Europe GmbH

• Paul-Dessau-Straße 8 Quartier O – 4.OG
• D-22761 Hamburg

Printed in China.

CHARBROIL.EU

Scan

Documents / Resources

| Char-Broil 24308840 4 Burner Gas Grill [pdf] Instruction Manual
24308840 4 Burner Gas Grill, 4 Burner Gas Grill, Gas Grill, Grill
---|---

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>