ROSCOE Ultra-5 Ultraviolet Disinfector User Guide

ROSCOE Ultra-5 Ultraviolet Disinfector

The Power of UVC Light is up to 99.99% effective against common bacteria and viruses.

DISCLAIMER
The Ultra-5™ is not intended for use to sanitize or disinfect medical devices or for any medical purpose. The Ultra-5™ is also not intended for use with kitchenware or other food contact surfaces. No medical claims are implied or intended with the sale of this device. Purchaser accepts responsibility for the correct and proper use of the device.

Foreword
Thank you for choosing the Ultra-5™ Disinfector by Roscoe. Using a specialized, high-powered UVC light, the Ultra-5™ can kill up to 99.99% of harmful bacteria and viruses on surfaces treated. UVC light is the preferable disinfection option since it produces NO HARMFUL OZONE. The EPA has shown that ozone can irritate the lungs and the respiratory system, especially for those with respiratory illnesses. Please read and follow all directions in this user manual.

EXPLANATION OF SYMBOLS USED
Equipment protected throughout by double insulation or reinforced insulation

Medical Device
Refer to the instruction manual

Medical Device
Important information concerning your safety or the operation of your device

Contains mercury
LAMP(S) INSIDE THIS PRODUCT CONTAIN MERCURY AND MUST BE RECYCLED OR DISPOSED OF ACCORDING TO LOCAL, STATE OR FEDERAL LAWS.

Indications for Use
The Ultra-5™ is intended for home use and is a multi-purpose disinfecting device for personal use products (i.e., toys, cell phones, etc.). When using electrical products, especially when children are present, basic safety precautions should always be followed, including the following:

IMPORTANT SAFEGUARDS READ ALL INSTRUCTIONS

BEFORE USING Medical Device
DANGER– To reduce the risk of electrocution:

1. ALWAYS unplug this product immediately after using it.
2. DO NOT use it while bathing.
3. DO NOT place or store product where it can fall or be pulled into a tub or sink.
4. DO NOT place in or drop into water or other liquid.
5. DO NOT reach for a product that has fallen into the water. Unplug immediately.

Medical Device
WARNING – To reduce the risk of burns, electrocution, fire, or injury to persons.

1. Close supervision is necessary when this product is used near children or invalids.
2. Use this product only for its intended use as described in this manual. DO NOT use attachments not recommended by the manufacturer.
3. NEVER operate this product if it has a damaged cord or plug if it is not working properly, if it has been dropped or damaged, or dropped into water.
4. Return the product to a service centre for examination and repair.
5. KEEP the cord away from heated surfaces.
6. NEVER block the air openings of the product or place it on a soft surface, such as a bed or couch, where the air openings may be blocked. KEEP the air openings free of lint, hair, and the like.
7. NEVER use it while sleeping or drowsy.
8. NEVER drop or insert any object into any opening or hose.
9. DO NOT use outdoors or operate where aerosol (spray) products are being used or where oxygen is being administered.

Medical Device

• WARNING – the Ultra-5™ is not a toy and is not intended to be used by children.
• WARNING – the Ultra-5™ has a powerful UV light bulb included, handles with care and discontinues use in the event of a broken or damaged bulb.
• WARNING – DO NOT use in or around sinks, tubs, pools or any bodies of water.
• WARNING – the UV that is emitted in the closed chamber is not compatible with life, never place living creatures in the Ultra-5™.
• WARNING – DO NOT stack objects on top of your Ultra-5™.
• WARNING – use this device only for its intended use as described in this manual. If the equipment is not used in the manner specified, the protection provided by the equipment may be impaired.
• WARNING – DO NOT attempt to operate this device with the drawer open. The device was designed to shut off automatically when the drawer is open. It is important not to defeat or tamper with this safety feature as UVC light can cause damage to eyesight.
• WARNING – NEVER insert any object other than an Ultra-5™ replacement bulb into the UVC bulb socket.
• WARNING – DO NOT unplug by pulling on the cord. To unplug, grasp the plug, not the cord.
• WARNING – DO NOT handle the plug or appliance with wet hands.
• WARNING – ALWAYS turn off all controls before unplugging.
• WARNING – ONLY use Ultra-5™ replacement bulbs in this device.
• WARNING – The Ultra-5™ plugs into a standard 120V power outlet. ALWAYS disconnect the device by unplugging it. DO NOT plug the device into an outlet that is difficult to access.
• WARNING – DO NOT look directly into the door window during use.

Product Specifications

• EPA Est. No. 99106-CHN-1
• Model: Ultra-5™ (ref. SE2028)
• Product Name: Ultra-5™ Ultraviolet Disinfector
• Product Weight: 6.8 lbs
• Cycle Time: 5 minutes (300 seconds)
• 10 minutes (600 seconds)
• Completion Indicator: 3 beeps
• Product Dimensions: 9.25” x 11.75” x 11.75”
• Voltage: AC 120 V 60Hz, AC 240 V 50Hz
• Power Rating: 8W
• Bulb: LB6W 42V 6W, 253.7nm (rated – 8,000 hrs)
• Window Material: Chi Mei Acryrex CM-11, 100% UV blocked
• Storage Temperature: 0° to 120° F / -18° to 49° C
• Operating Temperature: 20° to 100° F / 7° to 38° C
• Humidity: Up to 93%, non-condensing
• Clinical Efficacy (5 minute treatment):
• Pathogen Kill Rate
• E. Coli (8099) >99.99%
• Staphylococcus aureus (ATCC 6538) >99.99%
• Influenza A Virus (H1N1) >99.99%
• Coronavirus HcoV-229E >99.99%

ULTRA-5™ FEATURES

• The healthy choice in disinfection…with simple one-touch operation.

Getting to Know Your Ultra-5™
The Ultra-5™ uses a specialized, high-powered germicidal UVC light bulb. The polished aluminium drawer interior reflects the UVC light throughout the disinfection chamber to improve sanitization.

Did you Know?
The Ultra-5™ Disinfector is very versatile! You can sanitize and disinfect a variety of household items safely with the power of light including cell phones, keys, hair care items and small toys!

How to Use Your Ultra-5™

1. Connect the included DC power cord to the DC power input socket on the back of the Ultra-5™.
2. Plug the Ultra-5™ power cord into a working 120V wall outlet.
3. Place your Ultra-5™ on a level counter or tabletopOpen the disinfection compartment and if necessary, place the rack in the chamber.
4. Place the item(s) to be disinfected on the rack.
5. Close the chamber drawer.
6. Press the power button, then press the timer button to select 5 minutes (press once) or 10 minutes (press twice). To begin the disinfection cycle, press the UV button.
7. There will be a soft glow of UV Light visible through the tinted disinfection chamber window during the disinfection cycle.
8. Upon completion of the disinfection cycle, the Ultra-5™ will beep 3 times and the UV light will no longer be visible through the disinfection chamber window.
9. You may now remove your disinfected equipment. No waiting period is necessary before use.

NOTE
The cycle may be stopped or paused by pressing the UV button. The cycle time may be restarted by pressing the timer button during a disinfection cycle.

Using Your Disinfection Rack
When disinfecting with your Ultra-5™ use of the rack is suggested to improve disinfection. The rack lifts the object(s) being disinfected and permits the UVC light to reach the maximum surface area. Set accessories on the rack to permit greater penetration of the underside of the article being disinfected. If your item is large, the rack may be removed, but the UVC light may not reach all surface areas. In this case, repositioning the object to expose the untreated area to the UVC light and conducting another disinfection cycle may be done.

Caring for your Ultra-5™ – Changing the UVC Germicidal Bulb Your Ultra-5™ has been designed to provide years of dependable service and the UVC germicidal bulb has a life expectancy that should exceed the life of your device, so changing the bulb should not be necessary. However, should a bulb break, ALWAYS disconnect the power cord from the electrical outlet BEFORE proceeding to the steps below:

WARNING
ALWAYS wear protective gloves in the event of broken glass to avoid injury. If the Ultra-5™ has been recently operated, DO NOT begin the bulb replacement until the Ultra-5™ has cooled to the touch.

1. Pull the adapter out of the socket.
2. Flip the disinfection box.
3. Keep the Fluorescent tube horizontally and remove it upwards.
4. Rotate the Fluorescent tube 90°.
5. To install a Fluorescent tube lamp, keep the lamp horizontal and insert it downwards into the socket.
6. Pull the door out of the disinfection box.
7. Rotate the Fluorescent tube lamp 90° to fix the lamp in place.
8. Push the door into the disinfection box and fix the door in place.
9. Flip the disinfection box.
10. Plug the adapter into the socket.

Cleaning Your Ultra-5™
The disinfection drawer is lined with polished aluminium. Please adhere to the following guidelines when cleaning the device.

WARNING
ALWAYS disconnect the power cord from the power outlet BEFORE cleaning. If the Ultra-5™ has been recently operated, DO NOT begin cleaning until the Ultra-5™ has cooled to the touch. DO NOT use your Ultra-5™ until any cleaning solution has fully dried and the disinfection drawer has been installed.

INTERIOR

• DO NOT use baking soda or other alkali-based cleaners on aluminium as this may cause permanent discolouration.
• The interior can scratch easily, NEVER use abrasive cleaners and/or scrubbers when cleaning your device.
• For the aluminium areas, if using a gentle metal or glass cleaner, ALWAYS test the cleaner on a small portion of the aluminium to ensure suitability.
• ALWAYS polish the aluminium with a soft lint-free cloth.

EXTERIOR

• Should the casing of your Ultra-5™ become soiled you may wipe it down with a soft, non-abrasive moist cloth.
• DO NOT immerse your Ultra-5™ in water.
• DO NOT use any cleaning solvents.

Ultra-5™ Maintenance
Your Ultra-5™ Disinfector has been developed to require little maintenance during normal use. The bulb should last the lifetime of the device and periodic cleaning will keep your Ultra-5™ ready to use anytime. Every 6 months, check the Ultra-5™ reusable foam air filter to ensure it is clean and free of dust and debris. Open the plastic door located on the bottom of the device to access the filter. If necessary, wash the filter in a solution of mild soap and warm water. Rinse well and use an absorbent towel to gently squeeze out excess water. Allow the filter to fully air dry before reinstalling in the Ultra-5™.

Frequently Asked Questions (FAQS)

How do I use the Sanitizer?
The Ultra-5™ is a single-button device and as easy as 1,2,3!

1. Wipe the item to remove any physical residue.
2. Open the chamber and place the item in the drawer face up, then close the drawer.
3. Press the button and in 5 minutes the cycle is complete and your item is ready to use.

How does the Ultra-5™ work?

The Ultra-5™ works by emitting high energy light within a narrow light spectrum referred to as UV-C. The Ultra-5™ uses a low-pressure, mercury-arc germicidal lamp (bulb) to produce high amounts of UV energy. Approximately 90% of the light energy generated is around the 254nm wavelength. This wavelength of light is near the peak of the germicidal effectiveness zone of 265nm (the most lethal to microorganisms).

Why doesn’t the Ultra-5™ use Ozone, like some other devices?

Simple – safety. There are safety concerns about the use of ozone in the home with the EPA stating the following: “When inhaled, ozone can damage the lungs. Relatively low amounts can cause chest pain, coughing, shortness of breath and throat irritation. Ozone may also worsen chronic respiratory diseases such as asthma and compromise the ability of the body…”

What are the other benefits of the Ultra-5™?

Speed – ozone-based devices take up to 2 hours to work. In addition to the safety of the ozone for users, many may not want to wait 2 hours to use their equipment. With a 5-minute cycle time, the Ultra-5™ has your equipment disinfected quickly

Are there any supplies that need to be reordered?

No. The Ultra-5™ is easy to use and easy to own since it requires no replacement supplies at all! The device relies on a special germicidal UV-C bulb that is rated to outlast the life of the device and should never require changing. In the rare event that the bulb is damaged or does require replacement, a single low-cost replacement bulb is readily available from your local distributor or Compass Health Brands.

Do I need to disinfect some items twice?

Yes, since UV-C disinfection uses light waves, the disinfection function operates in a “line-of-sight” manner and only irradiates surfaces within the light rays. If an object is large or opaque, a second disinfection cycle may be necessary. For example, items should be periodically disinfected when fully disassembled or an item may need to be turned over after the first cycle. In these cases, you may set the unit to 10 minutes by pressing the cycle button twice. For larger or opaque items, it may be necessary to disinfect the item twice on each side. Upon completion of the first 5-minute cycle, openthe chamber, turn the item being disinfected over and re-insert the chamber for a second 5-minute disinfection cycle. For general daily use and most items, only one cycle is necessary.

Compass Health Brands warrants this product to be free from defects in workmanship and materials, under normal residential use and conditions, for one year (12 months) from the original invoice date. Shipping and handling fees are to be paid for by the customer. The manufacturer agrees, at its option during the warranty period, to repair any defect in material or workmanship or to furnish a repaired or refurbished product of equal value in exchange without charge (except for a fee for shipping, handling, packing, return postage, and insurance which will be incurred by the customer). Such repair or replacement is subject to verification of the defect or malfunction and proof of purchase as confirmed by showing the model number on the original dated sales receipt.

WARRANTY LIMITATIONS

This warranty does not include:

• Any condition resulting from other than ordinary wear or any use for which the product was not intended, such as use in rental or for commercial use
• Any condition resulting from incorrect or inadequate maintenance or care of the product
• Damage resulting from misuse, abuse, negligence, accidents or shipping damage
• Dissatisfaction due to buyer’s remorse
• Normal wear and tear
• Damages incurred during transportation
• Damages incurred during assembly or maintenance

Compass Health Brands (the Company) makes no express warranty or condition whether written or oral and the Company expressly disclaims all warranties and conditions not stated in this limited warranty. To the extent allowed by the local law of jurisdictions outside the United States, the Company disclaims all implied warranties or conditions, including any implied warranties of merchantability and fitness for a particular purpose. For all transactions occurring in the United States, any implied warranty of condition of merchantability, satisfactory quality, or fitness for a particular purpose is limited to the duration of the express warranty set forth above. Some states or countries do not allow a limitation on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages for consumer products.In such states or countries, some exclusions or limitations of this limited warranty may not apply to the Purchaser.

For consumer transactions, the limited warranty terms contained in this statement, except to the extent lawfully permitted, do not exclude, restrict, or modify but are in addition to the mandatory statutory rights applicable to the sale of this product to the Purchaser. All warranty claims must be filed by the consumer to the retailer of this product, who in turn is to contact the Company regarding any warranty return or replacement. Where the retailer will not provide warranty support, the Company should be contacted for warranty support. Please retain invoices for a minimum of two years for warranty purposes.

CLAIM PROCEDURES

• Claims for defective merchandise must be made within ONE year from invoice date
• Any claim for defective merchandise returns must be packed in original packaging
• We reserve the right to specify that items be returned to the original warehouse for inspection or be inspected by our representatives
• Pictures are required to claim defective merchandise, along with a copy of the original invoice
• If the claim is justified, the item(s) or part(s) will be repaired or replaced or a credit will be issued.
• It is our policy to replace parts whenever possible
• This warranty gives you specific legal rights. You may have other rights, which vary from state to state.

ULTRA-5™ DISINFECTOR BOX
Model No.: Ultra-5™ (ref: SE2028) This device complies with part 15, subpart B requirements of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.

• Part 15.107: Conducted disturbance at mains terminals
• Part 15.109: Radiated Spurious Emissions

Please note that changes or modifications of this product not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:

• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and the receiver.
• Connect the equipment to an outlet on a circuit different from that to which the receiver is connected.
• Consult the dealer or an experienced radio/TV technician for help.

Manufactured for: Compass Health Brands
6753 Engle Road
Middleburg Heights, OH 44130
Tel.: 1-800-947-1728
www.compasshealthbrands.com
Made in China
ULTRA-5_UserGuide_03_231220_ROS ©2023

References

• Home Medical Products For Seniors, Elderly, Surgery Patients
• Ozone Generators that are Sold as Air Cleaners | US EPA

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>