JVC CS-AW7020 Car Stereo Speaker Instruction Manual
- June 17, 2024
- JVC
Table of Contents
CS-AW7020 Car Stereo Speaker
Instruction Manual
CS-AW7020 Car Stereo Speaker
SUBWOOFER
CS-AW7020 CS-AW7040
CS-AW7220 CS-AW7240
INSTRUCTION MANUAL
For Customer Use:
Enter below the Model No, and Serial No, which is located either on the rear
or bottom of the speaker unit. Retain this information for future reference.
Model No.
Serial No.
Thank you for purchasing the ARSENAL Car Stereo Speaker. These Speakers can be
mounted in the trunk of your vehicle. For the secure installation and perfect
operation of your speakers, please read the following carefully.
Parts
For proper installation and use
- Before connecting the speakers to the amplifier, confirm that the power has been turned off. The click noise generated by the connection if the power is on may damage the speakers.
- The amplifier and speakers should be connected between corresponding terminals, i.e. left to left, and right to right, as well as “+” to “+”, and “–” to “–”. Connection with reversed polarity will degrade the quality of stereo reproduction.
- Do not subject the speakers to excessive input. The power handling capacity of the CS-AW7020/CS-AW7040/CS-AW7220/CS-AW7240 is 600 watts (R.M.S. MUSIC POWER). Any excessive input may damage the speakers.
- The CS-AW7020/CS-AW7040/CS-AW7220/CS-AW7240 has an impedance of 2Ω ,4Ω,8Ω. Make sure that the output impedance of the amplifier’s speaker terminal is rated at 2Ω,4Ω,8Ω.
- When cleaning the speakers, use a soft cloth and wipe the surface gently. Do not apply thinner or solvent.
- Be sure to carefully follow the instructions for:
Cable Connections
Fuse Replacement
Switching the Impedance Selector
Subwoofer Mounting and Smart Trim Ring Installation
Consult Page 19 of this Instruction Manual for details on these procedures.
Dual 4 Ω Application Diagrams
Dual 2 Ω Application Diagrams
To install the sealed enclosure
When the speaker cannot be attached in the car, make the sealed enclosure as
recommended in the table below—20 mm (3/4 inch) MDF is also recommended for
the enclosure materials.
| CS-AW7020 / CS-AW7040| CS-AW7220 / CS-AW7240
---|---|---
A| 15-13/32 inch (391.7 mm)| 16-13/32 inch (417.1 mm)
B| 15-13/32 inch (391.7 mm)| 16-13/32 inch (417.1 mm)
C| 11-13/32 inch (290.1 mm)| 13-29/32 inch (353.6 mm)
D| 9-4/32 inch (232 mm)| 10-14/32 inch (275.9 mm)
E| 9-23/32 inch (247 mm)| 11-10/32 inch (295 mm)
F| 4/32 inch (3 mm)| 4/32 inch (3 mm)
G| 1.57 ft3 (0.045 m3)| 2.17 ft3 (0.062 m3)
To install the ported enclosure
When the speaker cannot be attached in the car, make the sealed enclosure as
recommended in the table below—20 mm (3/4 inch) MDF is also recommended for
the enclosure materials.
| Parameters | CS-AW7020 | CS-AW7040 | NOTES |
|---|---|---|---|
| parallel | series | parallel | series |
| Nominal Impedance (Ω) | 2Ω + 2Ω | 4Ω + 4Ω | |
| SPL (dB,1W/1M) | 83.49 dB | 83.54 dB | 84.02 dB |
level
Displacement (Liter)| 0.123 ft3|
Hole Cutout Diameter (inch) (mm)| Dia. 9 – 6/32 inch ( 233 mm )|
Mounting Depth (inch) (mm)| 6 – 14/32 inch ( 163.5 mm )|
Re (Ω)| 0.98 Ω| 3.83 Ω| 1.92 Ω| 7.6 Ω| Re : DC voice coil resistance
BL (T.M)| 6.85| 13.75| 8.68| 17.21| BL : Product of Flux density and Effective
Voice coil-wire length
Vas (Liter)| 17.08 L| 16.98 L| 18.08 L| 18.28 L| Vas : Volume of air equal to
the driver
compliance
Vas (CuFt)| 0.6 ft3| 0.599 ft3| 0.64 ft3| 0.65 ft3|
Me (g)| 145.986 g| 147.109 g| 124.084 g| 122.443 g| Me : Effective mass
D (mm)| Dia. 202 mm| D : Effective cone diameter
Fs (Hz)| 39.6 Hz| 39.5 Hz| 41.7 Hz| 41.8 Hz| Fs : Driver free air resonance
Qms| 10.261| 10.282| 9.021| 9.169| Qms : Q of driver at Fs considering
only non-electrical resistance
Qes| 0.756| 0.74| 0.83| 0.824| Qes : Q of driver at Fs considering
only electrical resistance
Qts| 0.704| 0.691| 0.76| 0.756| Qts : Total Q of driver at Fs
Pe [max.] (W)| 600 W| Pea[max.] : Maximum continuous input power
Xmax.(mm)| 14.95 mm| 14.8 mm| Xmax. : Maximum effective voice coil travel
without distortion
Freq. Response (Hz)| 25 ~500 Hz|
Magnet Mass (oz) (g)| 65.4 oz ( 1854.1 g )|
Voice Coil(Aluminum)Dia.(inch) (mm)| Dia. 2 – 5/32 inch 54.5 mm| Dia. 2 – 4/32
inch 53.59 mm|
Hc (mm)| 39.9 mm| 39.6 mm| Hc : Voice coil Height
Hag (mm)| 10 mm| Hag : Gap Height
Parameters| CS-AW7220| CS-AW7240| NOTES
---|---|---|---
parallel| series| parallel| series
Nominal Impedance (Ω)| 2Ω + 2Ω| 4Ω + 4Ω|
SPL (dB,1W/1M)| 85.13 dB| 85.2 dB| 85.87 dB| 85.65 dB| SPL : Sound pressure
level
Displacement (Liter)| 0.18 ft3|
Hole Cutout Diameter (inch) (mm)| Dia. 10 – 29/32 inch ( 277 mm )|
Mounting Depth (inch) (mm)| 7 – 6/32 inch|
Re (Ω)| 0.98 Ω| 3.84 Ω| 1.94 Ω| 7.61 Ω| Re : DC voice coil resistance
BL (T.M)| 6.84| 13.72| 9.56| 19.14| BL : Product of Flux density and Effective
Voice coil-wire length
Vas (Liter)| 38.7 L| 38.76 L| 35.23 L| 35.05 L| Vas : Volume of air equal to
the driver compliance
Vas (CuFt)| 1.37 ft3| 1.37 ft3| 1.24 ft3| 1.24 ft3|
Me (g)| 171.854 g| 172.934 g| 157.028 g| 157.336 g| Me : Effective mass
D (cm)| Dia. 246 mm| D : Effective cone diameter
Fs (Hz)| 34.6 Hz| 34.5 Hz| 37.9 Hz| 38 Hz| Fs : Driver free air resonance
Qms| 10.277| 10.089| 8.931| 9.014| Qms : Q of driver at Fs considering
only non-electrical resistance
Qes| 0.786| 0.765| 0.794| 0.781| Qes : Q of driver at Fs considering only
electrical resistance
Qts| 0.73| 0.711| 0.73| 0.719| Qts : Total Q of driver at Fs
Pe [max.] (W)| 600 W| Pe[max.] : Maximum continuous input power
Xmax.(mm)| 14.95 mm| 14.8 mm| Xmax. : Maximum effective voice coil travel
without distortion
Freq. Response (Hz)| 23 ~500 Hz|
Magnet Mass (oz) (g)| 86.2 oz ( 2443.7 g )|
Voice Coil(Aluminum)Dia.(inch) (mm)| Dia. 2 – 5/32 inch ( 54.5 mm )| Dia. 2 –
4/32 inch ( 53.59 mm )|
Hvc (mm)| 39.9 mm| 39.6 mm| Hvc : Voice coil Height
Hag (mm)| 10 mm| Hag : Gap Height
TO OUR VALUED CUSTOMER
THANK YOU FOR PURCHASING THIS JVC PRODUCT.
WE WANT TO HELP YOU ACHIEVE A PERFECT EXPERIENCE.
NEED HELP ON HOW TO HOOK UP?
NEED ASSISTANCE ON HOW TO OPERATE?
NEED TO LOCATE A JVC SERVICE CENTER?
LIKE TO PURCHASE ACCESSORIES?
JVC® IS HERE TO HELP!
TOLL FREE: 1(800)252-5722
http://www.jvc.com
Remember to retain your Bill of Sale for Warranty Service.
Do not attempt to service the product yourself
Caution
To prevent electrical shock, do not open the cabinet.
There are no user serviceable parts inside.
Please refer to qualified service personnel for repairs.
© 2007 Victor Company of Japan, Limited
Printed in China
Documents / Resources
| JVC
CS-AW7020 Car Stereo
Speaker
[pdf] Instruction Manual
CS-AW7020, CS-AW7040, CS-AW7220, CS-AW7240, CS-AW7020 Car Stereo Speaker, CS-
AW7020, Car Stereo Speaker, Stereo Speaker, Speaker
---|---
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>