TOBBI TH17Y1074 Battery Operated Car Instruction Manual

TOBBI TH17Y1074 Battery Operated Car

PRODUCT SPECIFICATIONS

• Battery: 12V7AH
• Main material: PP
• Suitable age: 8-12 years old
• Weight limit: 110 lbs
• Product size: 35.4 x 20.9 x 15.2 inches
• Speed:
  • Low speed: 1-3 km/h
  • Fast speed: 3-8 km/h
• Runtime: 1-2 hours after charging 8-12 hours, based on riding conditions
• Charger:
  • Input: AC 100-240V
  • Output: DC 12V-1000mA
• Fuse: Auto-reset fuse

Product Usage Instructions

Assembly
The product should be assembled by an adult. Please wear protective equipment during assembly.

Parts Included:

Rear Wheel Assembly:

There are 8 nuts on two sides of the rear square pipe. Removethe nuts with a 13MM wrench and attach the rear wheels on both sides. Fix them with nuts using a 13MM wrench.

Front Wheel Assembly:
Insert the steering axle into the car body. Connect the plug coming from the front wheel and the plug coming from the car body. Make sure the front wheel is in the right place and ensure both plugs are on the same side.

Steering Wheel Assembly:
Remove the screw and the nut with a screwdriver. Align the steering wheel with the steering axle, match the holes on the steering wheel and the steering axle, use a screwdriver to fix them with a 5MM*25MM screw and a 5MM nut.

Battery Connection:
Remove two screws on the seat. There are two red plugs under the seat, match them to connect the power.

Flag Assembly:
Remove the paper from adhesive tape on the flag, paste the flag on the flagpole as shown in the picture, insert the small ball on the top of the flagpole, insert the flagpole into the hole on the car body and push it into place.

Security Warning
This product is not intended for transportation purposes. It should be used under adult guidance. Parents should ensure that children have taken safety measures before use. The toy should be used with caution to avoid falls or collisions that can cause
injury to the user or third parties.

FAQ

Q: Can children under 3 years old use this product?
A: No, this product is not suitable for children under 3 years old.

Q: Can this product be used in traffic?
A: No, this product is not to be used in traffic.

Q: Are there any small parts that can be choking hazards?
A: Yes, in its unassembled state, this product contains potentially hazardous small parts. Please keep it out of the reach of small children.

Q: Can this toy be used outside of private areas?
A: Pay attention to the potential hazards of using the toy outside of private areas.

Please read the manual before using the product. The manual and carton contain important information, please keep them properly for future reference. If failure to follow the instructions in the manual, it might be dangerous for your child.
In order to improve the product and quality, we may change some parts of the structure, appearance, packing method, assembly method and function of the product without any notice. When there is any difference between the manual and the product, please subject to the actual product. We are sorry for any inconvenience.

The assembly manual of the battery-operated car

Model:SX2219 (12V)
TH17Y1074
TH17A1075

Executive standard：

• EN71-1
• EN71-2
• EN71-3
• EN62115
• ASTM F963

WARNING
Products should be assembled by an adult. Protective equipment should be worn. Not to be used in traffic. Not suitable for children under 3 years. Choking hazard- small parts. In unassembled state, contains potentially hazardous small parts. Please keep it out of the reach of small children. Pay attention to the potential hazards of using the toy outside of private areas.

PARTS

Disclaimer:
The pictures in the instructions are for assembly reference only.
Please refer to the actual product.

Warning:
This product is not the vehicle for transportation, it should be used under adult guidance. Parents should ensure that children have taken the safety measures before use.
The toy should be used with caution since skill is required to avoid falls or collisions causing injury to the user or third parties.

PRODUCT SPECIFICATIONS

ASSEMBLY INSTRUCTIONS

Car assembly should be done by adults.
Take care of small parts. To avoid choking hazards, keep away from children while assembling. Children under 36 months are prohibited to use.
Please count all the parts carefully before assembly and dispose the plastic bag properly. To avoid choking hazards, children are not allowed to play with the bag.

1. Front training wheel assembly
   Align two front training wheels 4 on the rear of the car body 1, fix them with 4 pieces 4MM X 16MM flat head screws 6 on each side.

2. Rear wheel assembly
   There are 8 nuts A on two sides B of the rear square pipe,remove 8 nuts A with a 13MM wrench and attach the rear wheels 5 on both sides bl, fix them with nuts lal with a 13MM wrench.

3. Front wheel assembly
   Insert the steering axle C into the car body 1 . Connect the plug D coming from the front wheel 2 and the plug E coming from the car body 1. Make sure the front wheel 2 is on the right place and ensure both plugs D and El are on the same side.

4. Steering wheel assembly
   Remove the screw 8 and the nut 9 with a screwdriver. Align the steering wheel 3 with the steering axle c, match the holes on the steering wheel 3 and the steering axle Ic), use a screwdriver to fix them with a 5MM*25MM screw 8 and a 5MM nut 9.

5. Battery connection
   Remove two screws on the seat. There are two red plugs (F) under the seat, match them to connect the power.

6. Flag assembly
   Remove the paper from adhesive tape on the flag, paste the flag on flagpole as shown in picture, insert the small ball on the top of the flagpole, insert the flagpole to the hole on the car body and push it into place.

SECURITY WARNING

1. The installation and charging of the vehicle should always be carried out under adult supervision.
2. This product is limited to the children from 8-12 years old, 110 Ibs weight limit.
3. This product is ideal for driving on a hard flat surface.
4. It is strictly prohibited on streets or roads, pot holes, and slopes.
5. Avoid driving on the sand or grass or uneven ground.
6. Children should be given full instructions on operation of the car. Improper operation can cause damage or accidents.
7. While children are driving, it is parents’ duty to supervise at all time to avoid accidents.
8. Avoid driving in rains or flooded pathways. By doing so it can damage the motor, circuit and other electrical equipments.
9. Battery charger should be regularly inspected by parents to insure that the wires, plugs, crusts and other components are not damaged. Please stop using if any damage is found, until it is completely restored.
10. In order to ensure the product’s service life and safety, avoid damage to the charger, battery or electric circuit. The car must use the dedicated charger and power supply with the default configuration.
11. When not using the product, please cut off the power supply, and keep all the switch to “stop” or “off” position.
12. The charger provided is not a toy. It is to be kept away from children.
13. Strictly prohibit using non-manufacturer provided parts.
14. This product is made of PP material mainly, and has a safe service life of two years.

USAGE DIRECTION

1. Before using it, make sure that all the following works are done.

   • Complete the installation of the car according to the instructions.
     The battery plug-in has been connected, the power supply has been switched on.

   • Make sure that all the positions which need the screws are fixed tightly.

   • Parents or guardian should ensure that children have taken the safety measures before using.
     To reduce the risk during using, pay attention to the followings:
     When driving the car, the child should sit on the car seat.
     When children are driving, adults or parents should take care of and guide them more, and cannot leave. Pay attention to the driving environment and drive on hard and flat surfaces, not the unsafe environment.
     For example:

   • The trenches, the riverside, slope or uneven ground;

   • Roads or other places for driving and walking;

   • The obstruction which is easily hitting and causing injury;

   • Other unsafe zones.
     To avoid accident, please use only in the daytime or in a bright place, avoid using under low visibility.
     FUSE
     This car has a auto-reset fuse, if the car stops suddenly during driving,it is mainly caused by instantaneous current exceeds ,which makes the fuse to trip. Then just stop operating for about & seconds, and this fuse can be reset. Then turn on the power switch again.In order to avoid the fuse tripping and cutting off power supply, please pay attention to the following matters.
     This product can’t be overloaded, the maximum load is 110 lbs.

   • Don’t drag anything behind the product.

   • Don’t let water or other liquid into the batteries and other electrical components.

   • Don’t change the circuit system and structure of the product.

2. Operating (function reference diagram)

CHARGING WAY

• For Safety purpose ,the charging must be done by adults.
• The first time you use it, please remove the seat, connect two plugs of red wires, use it only after charging 8-12 hours.
• Charging socket is locate on the rear of the car body, please follow the instructions to charge the battery.
• If the car has slowed down, it needs to be charged by 8-12 hours, maximum 20 hours.
  1. First insert the plug of the charger into the charging port. (The car can not be started while charging.)
  2. Then insert the charger to the power socket.

WARNING:

1. The toy is to be assembled by an adult. In unassembled state, it contains potentially hazardous sharp points & small parts, so please keep it of baby’s reach.
2. Choking hazards – Small parts.
3. Not for children under 3 yrs.
4. Always wear shoes.
5. RISK OF FIRE. Do not bypass. Replace only with circuit protection device.
6. Protective equipment should be worn. Not to be used in traffic.

Attention:

• Can only use the charger and battery according to manufacturer’s regulations.
• Do not mix old and new or different types of batteries.
• The battery terminal should not be short circuit.
• Do not open the battery or charger.
• Do not reverse the battery.
• Before charging, please check whether the charger, battery and plug are ok, if you find any broken parts, you must stop using it immediately. And do not use it until it is fully repaired.
• The battery will be little warm when being charged, it is normal. If not, it may be caused from the short circuit of charger or circuit board.
• Must use the pressing plate to fix the battery.
• Run out of battery must be handled by adults. Remove the battery which has run out from toys to recycle properly and shall not be arbitrarily discard.
• If the product is going to be stored for a long time without use, it must be fully charged, and charge it once every 3 months, so as to make sure the battery life.
• Charger and Battery are not toys. Keep them away from children.

MAINTENANCE AND SERVICE

1. Before use, parents should check whether all parts like batteries, the charger, wires, the plug, the outer body and other parts are in good condition, check whether the screws are loose and whether there are potential safety hazards. Any damaged parts founded should be repaired before using.

2. After using the product for a period of time, use a small amount of lubricating oil to the moving parts to prevent wear and tear of rust.

3. Keep the car away from fire and direct sunlight. Place it stably, not upside down. The car shall be stored indoors or outdoors under cover.

4. The car should be kept away from hot items, such as stoves or heaters, or the plastic parts will melt. When charging, the car should be kept away from inflammable materials to prevent it from catching fire.

5. Charge in time after use. Charging should be done by adults. If the product is going to be unused for a long time, it must be fully charged.
   Charge it every month so as to extend the battery lifespan.

6. A soft cloth must be used to clean the car. Do not use chemical solvents to clean the plastic parts. Do not use soap or water to clean the car. Driving in rainy or snowy weather, water can damage the motor, battery and circuit system.

7. When stopping or storing the car, please cut off the power and make sure all switches are in the ‘STOP’ or ‘OFF’ position.

8. Do not use fuses differed from the specifications of this product.

9. Do not change the product structure and circuit system. Maintenance and repair work must be done under the guidance of the professional or technical personnel in place.

10. Do not use the product for other purposes. Put the battery in the right polarity.

11. Battery negative short circuit is prohibited. Non-rechargeable batteries cannot be charged.

12. Rechargeable batteries can only be charged under the supervision of the adult.

13. Do not mix old and new batteries or different types of batteries.

14. The battery running out of power should be removed from the car properly and not allowed to be played by children.

15. Disconnect the batteries completely when not in use and do not allow children to play with them.

TROUBLESHOOTING

Car does not move or power on

| If “power” switch is in OFF position
---|---
If the fuse is not functioning properly
If the battery is not connected, check the red and black wires.
If the charger is plugged in, car will not power on. Unplug charger.
If the pedal switch is not functioning properly
If the wheels stuck and cannot move

Car moves slowly

| If the battery is not fully charged. Need to be charged in time
If there is an issue with the wheels
If rider weight exceeds specifications

Battery does not charge

| If the charger is malfunctioning
If the battery loses its capacity
If the charger and battery are connected and charged

WARNING:

• This toy contains batteries that are non-replaceable.
• It is recommended that adults supervise young children.
• To reduce risk of injury, adult supervision is required.
• Never use in roadways, near motor vehicles, on or near steep inclines of steps, swimming pools or other bodies of water, always wear shoes, and never allow more than 1 rider.
• Only use the battery specified by the manufacturer.
• Only use the charger specified by the manufacturer.

Assembly by an adult
Maximum capacity: 50kgs (110lbs)

• This toy contains batteries that are non-replaceable.
• Rechargeable batteries are only to be charged by adults.
• Instructions to be given to the child in the proper use of the toy, particularly in the use of any braking system
• A reminder that the toy should be used with caution since skill is required to avoid falls or collisions causing injury to the user or third parties.
• Battery is only to be charged by person of at least 8 years old.
• Exhausted batteries are to be removed from the toy.

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>