DOMETIC A30 HiPro Evolution Refrigeration Instruction Manual

A30 HiPro Evolution Refrigeration
Instruction Manual REFRIGERATION
HIPRO
A30, A40, C40, C60, N30, N40

A30 HiPro Evolution Refrigeration

Copyright
© 2023 Dometic Group. The visual appearance of the contents of this manual is protected by copyright and design law. The underlying technical design and the products contained herein may be protected by design, patent or be patent pending. The trademarks mentioned in this manual belong to Dometic Sweden AB. All rights are reserved.

Important notes

Please read these instructions carefully and follow all instructions, guidelines, and warnings included in this product manual in order to ensure that you install, use, and maintain the product properly at all times. These instructions MUST stay with this product.
By using the product, you hereby confirm that you have read all instructions, guidelines, and warnings carefully and that you understand and agree to abide by the terms and conditions as set forth herein. You agree to use this product only for the intended purpose and application and in accordance with the instructions, guidelines, and warnings as set forth in this product manual as well as in accordance with all applicable laws and regulations. A failure to read and follow the instructions and warnings set forth herein may result in an injury to yourself and others, damage to your product or damage to other property in the vicinity. This product manual, including the instructions, guidelines, and warnings, and related documentation, may be subject to changes and updates. For up-to-date product information, please visit documents.dometic.com.

Explanation of symbols

DANGER!
Indicates a hazardous situation that, if not avoided, will result in death or serious injury.
WARNING!
Indicates a hazardous situation that, if not avoided, will result in death or serious injury.
CAUTION!
Indicates a hazardous situation that, if not avoided, could result in minor or moderate injury.
NOTICE!
Indicates a situation that, if not avoided, can result in property damage.
Note Supplementary information for operating the product.

Safety instructions

General safety
WARNING! Electrocution hazard

• Ensure that the minibar has been installed by a qualified technician in accordance with the Dometic installation manual.
• Do not operate the minibar if it is visibly damaged.
• If this minibar’s power cable is damaged, it must be replaced by the manufacturer, a service agent or a similarly qualified person in order to prevent safety hazards.
• This minibar may only be repaired by qualified personnel. Inadequate repairs may cause serious hazards.
• When positioning the minibar, ensure the supply cord is not trapped or damaged.
• Do not locate multiple portable socket-outlets or portable power supplies at the rear of the device.
• Plug the device to sockets that ensure proper connection especially when the device needs to be grounded.

**WARNING! Fire hazard**

• The refrigerant in the refrigerant circuit is highly flammable and in the event of a leakage combustible gases could build up if the appliance is in a small room. In the event of anydamage to the refrigerant circuit:
  Keep naked flames and potential ignition sources away from the minibar.
  Ventilate the room well. Switch off the minibar.

• For minibars with R600a refrigerant:
  The refrigeration circuit contains a small quantity of an environmentally friendly but flammable refrigerant. It does not damage the ozone layer and does not increase the greenhouse effect. Any leaking refrigerant may ignite.
  Do not use or store the minibar in confined spaces with none or minimal air flow.
  Keep the installation recess for the minibar free of any electrical components and light sources which during normal or abnormal operation produce sparks or arcs (i.e. relays or fuse boxes).

• Keep the ventilation openings on the device housing or in installations free of obstructions.

• Do not use any mechanical objects or other means to speed up the defrosting process, other than those recommended by the manufacturer.

• Do not open or damage the refrigerant circuit.

• Do not use electrical devices inside the minibar unless they are recommended by the manufacturer for that purpose.

WARNING! Explosion hazard
Do not store any explosive substances, such as spray cans with propellants, in the minibar.
WARNING! Health hazard

• For versions with absorption cooling: Never open the absorber unit. It is under high pressure and can cause injury if it is opened.
• This device can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they  have been given supervision or instruction concerning use of the device in a safe way and understand the hazards involved.
• This device is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the device by a person responsible for their safety.
• Children must be supervised to ensure that they do not play with the minibar.
• Cleaning and user maintenance may not be carried out by unsupervised children.
• Children aged from 3 to 8 years are allowed to load and unload the minibar.

CAUTION! Risk of crushing
Do not put your fingers into the hinge.
CAUTION! Health hazard
Foodstuff may only be stored in its original packaging or in suitable containers.
NOTICE! Damage hazard

• Check that the voltage specification on the data plate is the same as that of the power supply.
• Insufficient air flow results in a shortened lifespan and a reduced cooling performance. Observe the minimum spacings when installing the minibar to furniture (refer to the installation manual).
• The insulation of the cooling device contains flammable cyclopentane and requires special disposal procedures. Deliver the cooling device at the end of its life-cycle to an appropriate recycling center.
• Keep the condensate drain clean at all times.
• Only carry the minibar upright.

Operating the device safely
DANGER! Electrocution hazard
Do not touch exposed cables with your bare hands.
CAUTION! Electrocution hazard
Before starting the minibar, ensure that the power supply line and the plug are dry.
CAUTION! Health hazard

• Ensure only to put items in the minibar which may be chilled at the selected temperature.
• Food may only be stored in its original packaging or in suitable containers.
• Opening the door for long periods can cause significant increase of the temperature in the compartments of the minibar.
• Clean regularly surfaces that can come in contact with food and accessible drainage systems.
• If the minibar is left empty for long periods:
  Switch off the minibar.
  Defrost the minibar.
  Clean and dry the minibar.
  Leave the door open to prevent mold developing within the minibar.

NOTICE! Damage hazard

• Do not place the minibar near naked flames or other heat sources (heaters, direct sunlight, gas  ovens etc.).
• Never immerse the minibar in water.
• Protect the minibar and the cable against heat and moisture.
• Ensure that foodstuffs do not touch the walls of the cooling area.

Accessories

Intended use

The refrigeration appliance (also referred to as minibar) is intended for cooling and storing beverages and food in closed containers.
The minibar is designed for operation on cruise liners or to be used in household and similar applications such as:

• Staff kitchens in stores, offices and other working environments
• Farmhouses
• Hotels, motels and other residential type environments
• Bed and breakfast type environments
• Catering and similar non-retail applications

The minibar is not designed for installation in caravans or motor homes.
The minibar is suitable either as a built-in appliance or as a freestanding refrigeration appliance. Refer to the installation instructions.
The minibar is not suitable for

• Storage of corrosive, caustic or solvent-containing substances
• Storage of fresh foods and medicine
• Deep-freezing of foodstuff

This product is only suitable for the intended purpose and application in accordance with these instructions.
This manual provides information that is necessary for proper installation and/or operation of the product. Poor installation and/or improper operating or maintenance will result in unsatisfactory performance and a possible failure.
The manufacturer accepts no liability for any injury or damage to the product resulting from:

• Incorrect assembly or connection, including excess voltage
• Incorrect maintenance or use of spare parts other than original spare parts provided by the manufacturer
• Alterations to the product without express permission from the manufacturer
• Use for purposes other than those described in this manual

Dometic HiPro Apollo, Evolution
Dometic reserves the right to change product appearance and product specifications.

Technical description

The minibars are available with different cooling techniques:

• Absorption cooling: A30S1, A30S2, A30P1, A30P2, A30G1, A30G2, A40S1, A40S2, A40P1, A40P2, A40G1, A40G2
• Compressor cooling: C40S1, C40S2, C40P1, C40P2, C40G1, C40G2, C60S1, C60S2, C60G1, C60G2
• Thermoelectric cooling: N30S1, N30S2, N30P1, N30P2, N30G1, N30G2, N40S1, N40S2, N40P1, N40P2, N40G1, N40G2

All materials used are compatible for use with foodstuffs. The refrigerant circuit is maintenance-free.
The minibar has depending on the version one or two shelves and one or two door racks. There is a door rack intended for bottles. A 1.5 l bottle can be stored in the door rack for bottles. If the second door rack is available it is intended for smaller bottles or snacks.
As an option, the minibar can be equipped with an integrated WiFi function hence controllable using an app.
The minibar can be featured with a lock.

Operating elements of the minibar

2 Shelves (A40S2, A40P2, A40G2, C40S2, C40P2, C40G2, C60S2, C60G2, N40S2, N40P2, N40G2)
3| Upper door rack (for A40S1, A40S2, A40P1, A40P2, C40S1, C40S2, C40P1, C40P2, C60S1, C60S2, C60G1, C60G2, N40S1, N40S2, N40P1, N40P2)
4| Lower door rack
5| Bottle holder door (optional)
6| Glass door (optional)
–| Bottom interior light (optional)

Operating panel

Switching the minibar on and off
Entering the temperature setting
Entering the silent mode (only for C40 and C60 with compressor cooling)

Indicator LED

function active)
| Flashing| An error occurred (see chapter Troubleshooting on page 14)
–| Off| Minibar is switched off or in silent mode

Operation

Before first use
Before first use, clean the minibar inside and outside with a damp cloth for hygienic reasons.
Saving energy

• Only open the minibar as often and for as long as necessary.
• Avoid unnecessarily low temperature settings.
• For optimal energy consumption, position the shelves and drawers according to their position on delivery.
• On a regularly basis, make sure the door seal still fits properly.
• Clean dust and dirt from the condenser at regular intervals.

Positioning the shelves
To position the shelfs proceed as shown in Fig. 3on page 10. Positioning the door rack
To position the door rack proceed as shown in Fig. 4 on page 11. Switching on the minibar
Note After switching on, the minibar needs several hours to reach the set cooling temperature.
Plug the power plug into the socket (Fig. 5 on page 11). Setting the temperature
To avoid food waste, note the following:

• Keep temperature fluctuation as low as possible. Only open the minibar as often and for as long as necessary. Store the foodstuff in such a way that the air can still circulate well.
• The minibar is equipped with an automatic temperature regulation function. Select the average of the possible temperature values.
• Adjust the temperature to the quantity and type of the foodstuff.

The minibar is equipped with an automatic temperature regulation function. The temperature can be adjusted to 4 °C, 7 °C or 12 °C. With each press of the button the cooling temperature switches between the possible values.
To set the temperature proceed as shown in Fig. 6 on page 12. Switching off the minibar
To switch off the minibar proceed as shown in Fig. 7 on page 12. Setting the silent mode (only for C40)
The minibar is equipped with a silent mode.
Note When the silent mode is activated, the temperature setting cannot be changed.

1. Set the desired cooling temperature (see chapter Setting the temperature on page 11).
2. To set the silent mode proceed as shown in Fig. 8 on page 13.

Defrosting
The minibar is equipped with an auto-defrost function.
Storing
If the minibar is not to be used for a longer period of time, proceed as follows:

1. Pull the power plug out of the socket.
2. Clean the minibar (see chapter Cleaning on page 13)

Cleaning

WARNING! Electrocution hazard
Always disconnect the minibar from the mains before cleaning and maintenance.
NOTICE! Damage hazard

• Do not use abrasive cleaning agents or hard objects during cleaning as these can damage the minibar.
• Never use hard or sharp tools to remove ice or to free frozen objects on the minibar.
• Do not use any mechanical tools or any other tools to speed up the defrosting process.
• Ensure that no water drips into the seals to avoid damage to the electronics.
• The light source can only be replaced by the manufacturer, a service agent or similarly qualified person to avoid hazard.

Note Condensation moisture on glass doors

1. When the ambient humidity is above 25 % in 25 °C ambient temperature, moisture will condense on the glass door.
2. Clean the minibar regularly and as soon as it becomes dirty with a damp cloth.
3. Wipe the minibar dry with a cloth after cleaning.
4. Check the condensate drain regularly.
5. Clean the condensate drain when necessary. If it is blocked, the condensate collects on the bottom of the minibar.
6. For absorber versions: Use a brush or so cloth annually to remove dust from the absorber unit.

Troubleshooting

into socket.
No voltage at the socket.| Check circuit breaker.
Electronics or sensors defective| Contact an authorized service agent.
Service agent only: Install new electronics or sensor.
For versions with absorber cool- ing: Heating cartridge defective| Contact an authorized service agent.
Service agent only: Install new heating cartridge.
Auto-defrost function is active.| No action required (see chapter De frosting on page 13).
Minibar was recently switched on.| Check cooling again after 5 h … 6 h.
Cooling unit is defective.| Contact an authorized service agent.
Service agent only: Replace the minibar.
Minibar is in silent mode.| No action required (Setting the silent mode (only for C40) on page 12).
Minibar is not cooling. Indicator LED is continuously flashing.| Cooling unit is blocked. Cooling unit is not water-tight. Heating element is defective. Error during self-test| Contact an authorized service agent.
Poor cooling performance| Cooling unit is not sufficiently ventilat- ed.| Provide sufficient ventilation (see Instal- lation Manual).
Minibar is exposed to direct sunlight.| Remove the minibar out of direct sun- light.
| Door of minibar is not closed with a tight seal.| Check distances (see Installation Manual).
Contact an authorized service agent.
Service agent only: Replace door seal
---|---|---
Minibar recently filled.| Check cooling again after 5 h … 6 h.
For versions with absorber cool- ing: The input voltage is too low or too high.| Check input voltage.
Frost formation in the minibar com- partment| Door of minibar is not closed with a tight seal.| Check distances (see Installation Manual).
Contact an authorized service agent.
Service agent only: Replace door seal
Interior lighting is not working| Power plug is not plugged in.| Insert the power plug into the socket.
Interior lighting is defective.| Contact an authorized service agent.
Service agent only: Change interior lighting
Surface of infrared door sensor is cov- ered by condensation.| Clean the surface of the infrared door sensor.

Disposal

WARNING! Fire hazard

• The refrigerant is highly flammable. Do not open or damage the refrigerant circuit.
• The insulation of the device contains an insulating gas (see data plate). Do not damage the insulation.

Recycling packaging material: Place the packaging material in the appropriate recycling waste bins wherever possible.
Recycling products with non-replaceable batteries, rechargeable batteries or light sources:

• If the product contains any non-replaceable batteries, rechargeable batteries or light sources, you don’t have to remove them before disposal.
• If you wish to finally dispose of the product, ask your local recycling center or specialist dealer for details about how to do this in accordance with the applicable disposal regulations.
• The product can be disposed free of charge.

Warranty

The statutory warranty period applies. If the product is defective, please contact the manufacturer’s branch in your country (see dometic.com/dealer) or your retailer.
For repair and warranty processing, please include the following documents when you send in the device:

• A copy of the receipt with purchasing date
• A reason for the claim or description of the fault

Note that self-repair or nonprofessional repair can have safety consequences and might void the warranty.

Technical data

For the current EU declaration of conformity for your device please refer to the respective product page on dometic.com or contact the manufacturer directly (see dometic.com/dealer).
This product contains a light source of energy efficiency class F.
Further product information can be accessed via QR code on the energy label on the product or via eprel.ec.europa.eu.

 | HiPro
A 30S1, A 30S2, A 30P1, A 30P2, A 30G1, A 30G2| HiPro
A 40S1, A 40S2, A 40P1, A 40P2, A 40G1, A 40G2
---|---|---
Input voltage| 220 … 240 V
50 / 60 Hz
Total volume| 26 L| 33 L
Rated input power| 60 … 70 W
Climate class and intended ambient tem- perature use| N: 16 °C … 32 °C
T: 16 °C … 43 °C
Noise emission| 0 dB(A)
Refrigerant| R717
Dimensions (WxHxD)| 384 × 520 × 446 mm| 405 × 550 × 466 mm
Weight:
With solid door With panel door With glass door| 13.7 kg
15 kg
15.9 kg| 15.3 kg
16.7 kg
17.9 kg
 | HiPro
C 40S1, C 40S2, C 40P1, C 40P2, C 40G1, C 40G2| HiPro
C60S1, C60S2, C60G1, C60G2
---|---|---
Input voltage| 220 … 240 V
50 / 60 Hz
Total volume| 33 L| 49 L
Rated input power| 45 W
Climate class and intended ambient tem- perature use| N: 16 °C … 32 °C
T: 16 °C … 43 °C
Noise emission| 33 dB(A)| 38 dB(A)
Refrigerant| R600a
Dimensions (WxHxD)| 405 × 550 × 481 mm| 490 × 565 × 510 mm
Weight:
With solid door With panel door With glass door| 17.5 kg
18.9 kg
20.1 kg| 19.5 kg
–
22.5 kg
Test/ certificates|
 | HiPro
N 30S1, N 30S2, N 30P1,N 30P2, N 30G1, N 30G2| HiPro
N 40S1, N 40S2, N 40P1, N 40P2, N 40G1, N 40G2
---|---|---
Climate class and intended ambient tem- perature use| N: 16 °C … 32 °C
T: 16 °C … 43 °C
Noise emission| 0 dB(A)
Refrigerant| R600a
Dimensions (WxHxD)| 384 × 520 × 415 mm| 405 × 550 × 435 mm
Weight:
With solid door With panel door With glass door| 10.7 kg
12 kg
12.9 kg| 12.5 kg
13.9 kg
15.1 kg
Test/ certificates|

YOUR LOCAL DEALER
dometic.com/dealer
dometic.com
YOUR LOCAL SUPPORT
dometic.com/contact
YOUR LOCAL SALES OFFICE
dometic.com/sales-offices
A complete list of Dometic companies, which comprise the Dometic Group, can be found in the public filings of:
DOMETIC GROUP AB
Hemvarnsgatan 15
SE-17154 Solna . Sweden
4445103226 2023-06-29

References

• Dometic | Dometic Australia
• Find a Dealer | Dometic USA
• Telepathy - Powering Successful Brands
• neue Internetpräsenz - powered by ropa GmbH & Co. KG

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>