earthwise 210131 21 Inch Lawn Sweeper Installation Guide

earthwise 210131 21 Inch Lawn Sweeper

Information

Estimated assembly time

Parts List

Hardware Included

• For replacement parts list…

PARTS DIAGRAM

ASSEMBLY INSTRUCTIONS

INSTRUCTIONAL VIDEO

Scan QR code

• Visit https://americanlawnmower.com/howto/sweeperassembly
• Call 844-531-3064 if further instruction is needed.

INSTALLATION

• Insert the beveled hook on the left side support leg into the slot positioned on the top of the side housing. Slide the bottom beveled hook into the groove on housing. Secure the bottom hook by clicking the buckle into the hole positioned on the housing as pointed by the arrow.
• Push the assembled handle into the connecting tubes located on the sides of main Sweeper body. Then insert the bolt C through the slot from side and secure the handle with washer n and wing nut s to lock in place.
• Follow the wire frame assembly sequences (1-5) in Fig. 4.
  • Step 1: Starting with the upper frame rod, insert (A) end on upper rods into sleeve where arrow points on upper edge of hopper bagg. Push rod all the way around until the end clears the sleeve on the upper edge of the hopper bag.
  • Step 2: Insert and push both sides of threaded upper rod into grooves on hopper handle connectors d) until the notches on the upper rod snap in position.
  • Step 3: Insert the left side of bottom rod i through the sleeve and repeat same for the right side. Leave the cross bar (B) on the bottom rod disregarded for now.
  • Step 4: Push the threaded bottom rod into grooves on hopper handle connectors d until the notches on the bottom rod snap in position.
  • Step 5: Position the bottom cross bar (B) into the bottom sleeve (C) on the hopper bag until it clicks in position.

ATTENTION!

• Make sure the height of the brushes are adjusted to your lawn for optimum sweeping performance.
• Set Brushes 25″(6.35mm) deep into your grass.

CAUTION:

• Use proper lifting techniques when emptying the hopper.
• Keep away from small children.
• Hopper is not intended for carrying heavy loads.
• It is recommended to wear proper eye protection while operating the Sweepit!.

OPERATING INSTRUCTIONS:

• Inspect brushes prior to use. Brushes are removable for cleaning or replacement.
• For best results, the distance between the Sweepit! brushes and top of grass or ground surface should be 1/4″-1/2″. To set the height, use the yellow adjustment knob on the front of the hood to position the brush height between MIN and MAX. If brushes jam frequently or if sweeping performance is poor, readjust brush height.
• Walk at a steady pace and in a straight line while pushing the sweeper in front of you.
• Control of brush height during use for clearing uneven ground is accomplished manually by simply pushing down on or lifting the handle
• Empty hopper regularly by lifting straight up on the hopper handle. Empty contents into a yard waste container or paper bag.
• Replace the hopper by positioning it on the frame and snapping it into place.
• In order to get best product performance, it is recommended to use it over grass surfaces which do not exceed 2 1/2″ length.

REPLACEMENT PARTS LIST

• a= 025012100100885
• b= 025012100200885
• c= 010000000020004
• d= 025012190500885
• g =035012100000808
• h =035012100403000
• i =035012100408000
• n= 010000000090003
• m =LSW70021-1
• S =020040090200801
• p (Right)=005012101500801
• q (Left)=005012101400801

Customer Service

For assistance with your Sweepit!, or to order replacement parts, call our Consumer Hotline at: 844-531-3064, 7444 Shadeland Station Way, Indianapolis, IN 46256, americanlawnmower.com

TROUBLESHOOTING

• If brushes jam during operation, adjust the height of the brushes to a higher setting.
• If brushes continue to jam while pushing the sweeper, lift the handle higher during operation for optimum performance.
• If sweeper is not collecting enough debris as preferred, lower the handle during operation or adjust the height of the brushes to a lower setting.
• If brushes jam while using on uneven ground or on lawns with various heights of grass, control the brush height manually by lifting up or pushing down on the handle for ease of operation.
• If handle is difficult to lift and sweeper is difficult to push because of the weight of the hopper, stop more frequently to empty.

MAINTENANCE

• If brushes become full of debris, brushes can be cleared by hand while sweeper rotor is not turning.
• Brushes can also be removed for cleaning or replacement.
• To clean sweeper, spray with water hose and let dry.
• Tighten screws if any parts become loose after operation.

STORAGE

• Store sweeper and hopper bag dry.
• Push bottom of hopper bag up and lean complete sweeper vertically against a wall for compact, space saving storage.

WARRANTY

There are no warranties that extend beyond the product description except that the sweeper sold thereunder is warranted as follows:

1-YEAR LIMITED WARRANTY

For 1 year from purchase, The Great States Corporation/ American Lawn Mower Company will replace free of charge to the original buyer, any part(s) found defective in material and/ or workmanship upon exami- nation by our factory or a factory authorized service center. Parts sent to the factory for replacement must be shipped prepaid by the buyer.

THERE IS NO OTHER EXPRESS WARRANTY. ALL IMPLIED WARRANTIES, INCLUDING THOSE OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED TO 1 YEARS FROM THE PURCHASE AND TO THE EXTENT PERMITTED BY LAW, AND ALL IMPLIED WARRANTIES ARE EXCLUDED. THIS IS THE EXCLUSIVE REMEDY AND LIABILITY FOR CONSEQUENTIAL DAMAGES UNDER ANY AND ALL WARRANTIES

Warranty is limited to manual push walk-behind applications and specifically excludes any non-manual powered propulsion of any kind or any commecial/ non- residential applications. ANY NON- RESIDENTIAL USE OF THIS PRODUCT VOIDS ALL WARRANTY. Consumer Hotline: 844-531-3064

This warranty is not transferable and only applies to product sold directly from an authorized retailer.
Proof of purchase, original dated sales receipt must accompany all warranty claims.

California Proposition 65 Warning

This product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.

WARNING: Some dust and debris created by the use of this tool could contain chemicals known to the State of California to cause cancer and birth

• defects or other reproductive harm. chemicals in fertilizers
• compounds in insecticides, herbicides and pesticides
• arsenic and chromium from chemically treated lumber.

Your risk from exposure to these chemicals varies, depending on how often you do this type of work. To reduce your exposure, work in a well-ventilated area and with approved safety equipment, such as dust masks that are specifically designed to filter out microscopic particles.

WARNING: Cancer and Reproductive Harm – www.P65Warnings.ca.gov

CONTACT

• americanlawnmower.com
• CALL US BEFORE RETURNING: 844-531-3064

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>