ANTIGRAVITY BATTERIES H6-30-16 Lithium Car Battery User Manual

ANTIGRAVITY-BATTERIES-H6-30-16-Lithium-Car-Battery-LOGO

DANGER! IMPORTANT SAFETY INSTRUCTIONS.
PRIOR TO USE, READ AND UNDERSTAND PRODUCT SAFETY INFORMATION AND THIS USER MANUAL. Failure to follow these safety instructions may result in ELECTRICAL SHOCK, EXPLOSION, or FIRE, which may result in a SERIOUS INJURY, DEATH, DAMAGE TO VEHICLE or PROPERTY. DO NOT DISCARD YOUR USER MANUAL.

Introduction

THANK YOU
Thank you for purchasing the Antigravity 16-Volt Lithium-Ion Battery. This is a state of the art 16v Lithium-Ion Battery with a full Battery Management System (BMS) on board. It will provide years of solid performace and protections for safe operation.

Please note: This battery is intended for Race Use only, and must be charged with a 16-Volt approved LITHIUM Charger, and be used in a vehicle with a charging system specifically for 16V Lifepo4 Lithium Batteries. Please read the following information carefully. Please contact us with any questions.

GUIDELINES
Antigravity Batteries Lithium-Ion Starter Batteries offer great performance benefits such as massive weight reduction, much higher cranking power, and longer service life than Lead/Acid batteries. They can improve the performance of your vehicle due to the weight reduction, stable voltage and better starting performance. But they are different from Lead/Acid in a few key areas. So please adhere to the following Guidelines carefully.

1. Do not use a Lead/Acid Charger/Maintainer on a Lithium-Ion Battery. Only use a Lithium (Lifepo4 16v) specific charger.
2. Make sure your Electrical System and Voltage Regulator are charging and operating correctly and are specific for a 16-Volt System. Over-Charging due to a bad/old voltage regulator/rectifier or improper voltage or current output could damage your battery, cause fire, or explosion! Your system must be in good working order and be SPECIFICALLY FOR 16-Volts!
3. This Battery is equipped with a Battery Management System that will automatically shut-off the battery before Over-Discharge can occur. This will save your battery from Damage due to over discharge. In the event the battery turns off, it is necesary to put it on a charger and recharge fully.
4. Keep all connections protected from metals or areas that could cause a short-circuit on the battery terminals.
5. Check your vehicle for parasitic drains. A parasitic drain is a condition where an accessory, instrument cluster, ignition module, cooling fan or other items are drawing energy from the battery while the vehicle is not running. This can create frequent over-discharge conditions to the battery and result in poor performance; be sure to eliminate Parasitic drains on the battery.
6. In very cold weather your lithium battery may seem sluggish on the first start attempt. If you leave a light on or do a short bump of the starter a few times it will self warm and get to full power again. The battery self warms on use.
7. If you plan to store your vehicle for long periods just disconnect your Antigravity Battery from your vehicle and put in a cool dry place; check state of charge once every 3 months.

Important Safety Warnings

PERSONAL PRECAUTION
Only use product as intended. When working on or around this battery, use caution. It can produce extremely high discharge currents when short- circuited. Someone should be within range of your voice or close enough to come to your aid in case of emergency. Wear complete eye protection and protective clothing while working near a battery. Always wash hands after handling batteries and related materials. Do not handle or wear any metal objects when working with batteries including tools, watches or jewelry. If metal is dropped onto battery, it may spark or create a short-circuit resulting in electrical shock, fire, or explosion which may result in injury, death or property damage.

HANDLING
Handle product with care. The product can become damaged if impacted. Do not use a damaged product, including, but not limited to, cracks to the casing or other physical damage. Do not handle product or any electrical components near any liquid. Store and operate product in dry locations.

MODIFICATIONS
Do not attempt to alter, modify or repair any part of the product. Disassembling product may cause injury, death or damage to property. If product becomes damaged, malfunctions or is submerged, discontinue use, and contact Antigravity Batteries. Any modifications to the product will void your warranty.

ACCESSORIES
This product is only approved for use with Antigravity Batteries accessories.

LOCATION
Make sure product is installed correctly. Position cable leads to avoid accidental damage from vehicle parts (including hoods and metal parts), moving engine parts (including fan blades, belts, and pulleys), or what could become a hazard that may cause injury or death. Do not install next to metal objects that could cause a short-circuit. Failure to follow guidelines could result in fire, death, personal injury, or property damage.

HIGH CONSEQUENCE/RISK ACTIVITIES
This product is not intended for use where the failure of the product could lead to injury, death or severe environmental damage.

CLEANING
Use a soft, lint-free (micro fiber) cloth. Avoid getting moisture in openings. Use only mild cleaners on product and no solvents or harsh chemicals.

OPERATION TEMPERATURE

This product is designed to work in ambient temperatures between -10°C to 60°C (14°F to 140°F). Do not operate outside of temperature ranges. Do not jump- start a frozen battery or battery with voltage below 12v. Do not charge a frozen battery. Only charge within the range of 0°C to 45°C (32°F to 113°F) Discontinue use of product immediately if the battery becomes excessively warm.

STORAGE
Store your product on a flat, secure surface so it’s not prone to falling. Store your product in a dry location. The storage temperature is -20°C to 25°C (-4°F to 77°F), average temperature. Never exceed 80°C (176°F) under any condition.

COMPATIBILITY
The product is only compatible with 16-volt type systems in vehicles. Do not attempt to use product with any other types of batteries, or in series or parallel with another battery; the interior electronics could be damaged. Use with other battery chemistries may result in fire, explosion, injury, death or property damage. Contact Antigravity Batteries prior to attempting to jump- start the battery. Do not jump-start a battery if you are unsure of the battery’s specific chemistry or voltage.

THE BATTERY
The built-in lithium-ion battery in the product should be replaced or serviced only by Antigravity Batteries, and must be recycled or disposed of separately from household waste. Do not attempt to service or replace the battery yourself and do not handle a damaged or leaking lithium-ion battery. Never dispose of battery in household trash. Disposal of batteries in household trash is unlawful under state and federal environmental laws and regulations. Always take used batteries to your local battery recycling center. If the battery is excessively hot, emitting an odor, deformed, cut, or is demonstrating an abnormal occurrence, immediately stop all use and contact Antigravity Batteries (info@antigravitybatteries.com).

BATTERY CHARGING
Use only approved Lithium-Iron Phosphate specific chargers for 16-Volt LifePo4 Lithium Chemistries with this 16-Volt battery. Using damaged cables or chargers, or charging with other than intended battery chargers, could result in damage to battery, fire, or explosion which may result in injury, death or property damage. Never leave any battery being charged unattended.

IMPORTANT NOTICE ON CHARGING
The charging system in your vehicle may go bad or be charging at excessively high voltages if not operating correctly. This occurs most often in older vehicles, or vehicles with modified or aftermarket charging systems. This could result in damage to battery, fire, or explosion which may result in injury, death or property damage. It is important you check your vehicle’s charging system BEFORE installing this battery. Make sure it is operating correctly and not charging above 17.5v.

Specifications

• BATTERY TYPE: Lithium Iron-Phosphate (LifePo4)
• CASE FORMAT: H6/Group48
• VOLTAGE: 16.5V (nominal/resting)
• CAPACITY and CRANKING AMPS: see battery label
• DIMENSIONS: 10.75 x 7 x 7.5 inches
• WEIGHT: 16.5 lbs (approx)
• MAX CHARGING RATE: 20 Amps
• MAX CHARGING VOLTAGE: 18V

APPROVED CHARGER TYPE:
Lithium-Iron Phosphate for 16V Starter Batteries at 20-Amps MAXIMUM. Charging voltage not to exceeed 18v. Please contact us if you need assistance in choosing the correct charger: info@antigravitybatteries.com

Charging

CHARGING WARNINGS

1. Do NOT use Lead/Acid Chargers/Maintainers on this Antigravity Battery or Lithium Batteries.
2. Do NOT use a 12-Volt Charger on a 16-Volt Battery.
3. Use only APPROVED LIFEPO4 Chargers for your Battery’s specific Voltage, Chemistry and Maximum Charge Rate.
4. Check Vehicle for proper Charging System Operation. You may have a bad Voltage Regulator.
5. IF YOUR BATTERY HAS BEEN OVER-DISCHARGED BELOW 14-Volts, DO NOT ATTEMPT TO JUMP-START. CHARGE IT UP TO A MINIMUM OF 14.5v FIRST WITH THE PROPER CHARGER.

CHARGING ANTIGRAVITY 16-VOLT BATTERY
The Antigravity Batteries AG-H6-30-16v batteries operate and are recharged correctly with the proper 16-Volt Lithium-Iron-Phosphate Charger rated not to exeed 18-Volts and 20-Amps MAXIMUM Charge Rate. If you are not sure check with the manufacturer. DO NOT CHARGE THIS BATTERY IF YOU ARE UNSURE OF THE CORRECT CHARGER. THERE IS A POTENTIAL FOR FIRE, AND EXPLOSION. To Charge or Maintain your Antigravity Battery: Only use a Lithium-Ion Charger designed specifically for 16-Volt LiFePo4 Lithium-Iron-Phosphate Starter Batteries. Follow all Manufacturer’s Instruction on Charger use. Contact Antigravity Batteries for suggestions on a Charger for your use, or visit our website. Antigravity Batteries 16-Volt Batteries are only for Race Use. Antigravity Batteries will not warranty the use of 16-Volt batteries in Custom Race and/or Total Loss systems. 16-Volt Antigravity Batteries are not to be used in 12-Volt vehicle systems.

CHARGING SYSTEMS WARNING
An Antigravity Battery can be over-charged if the vehicle’s charging system is defective or is not providing the proper charging voltage and amperage. 16v Charging systems are rare and for race use only; often the Alternators and Chargers for these systems can vary. Please make sure any alternators or chargers that are used with this lithium-ion battery meet the charging guidelines noted in the “SPECIFICATIONS” section above. Failure to check system could result in fire, explosion and damage to personal property.

Installation

INSTALLING THE BATTERY
Before Installation make sure the location of the battery will be free from areas of potential short-circuiting of the cables, terminals and other electrical connections. Be aware of other potentially dangerous situations such as moving parts, metal parts or extremely hot parts such as headers. Make sure your Charging System is in good operating condition, and not charging above 17.5v for typical use and not above 18v MAX for this 16v Lithium Battery.

1. Remove the Negative Cable then the Positive Cable from your old battery, and remove the battery.
2. Securely install the battery in a tray or other method that does not allow battery movement. Ensure the area is free from high-heat parts and areas of potential short-circuits. The battery can be installed in any orientation without issue.
3. After secure fitment of the battery, replace Positive then Negative cables and tighten the nuts.

PLEASE USE SAFETY! FOLLOW THESE PRECAUTIONS

1. Battery MUST be securely mounted into vehicle to prevent movement.
2. Be careful not to directly short-circuit the Battery connections on the frame, or other metal parts.
3. Battery and Cables should not be installed near hot pipes, sharp objects, or metal parts.
4. Battery Cables should have some slack and not be tightly stretched.
5. Do not install close to Carbon Fiber… Carbon Fiber can conduct electricity!
6. Test for Parasitic Drains on vehicle after battery installation (VERY IMPORTANT, see “Troubleshooting” section).
7. Put heat shield around battery if expected to run in
8. high-temperature environments for extended periods of time.

Battery Care & Maintenance

CHECKING THE BATTERY
Antigravity Batteries do not require maintenance for the most part if they are kept in a good state of charge, but as with any battery, they should be checked once every few months, or weeks as a precaution. Visually inspect the product for any cracks, check the mounting is secure, and check the voltage.

CLEANING
To clean the Antigravity Battery, use a clean dry cloth. Do not use harsh chemicals or solvents, DO NOT directly spray the battery with a Pressure Washer or Hose.

STORING
The Antigravity Battery can hold a charge for many months provided there are no parasitic drains taking the battery’s energy. If you are going to be storing your vehicle it is best to disconnect the battery completely, and it will maintain its charge up to and over 8 months. Check state of charge every 3-4 months.

Troubleshooting

SLUGGISH PERFORMANCE ON INITIAL START IN VERY COLD WEATHER
This is a normal effect of Lithium-Ion due to increased “resistance” in very cold weather. The battery is not damaged. A Lithium battery can be self warmed by either a couple quick engagements of the starter, such as a short blip on the starter button, or a short turn of the key to engage the starter for a second only, or by leaving the vehicle lights on for 1-3 minutes. This gets current to flow from the battery and it will self-warm and have more power available for starting in low temperatures. Once warmed, the battery’s full power is available. For freezing weather, we recommend a battery warmer. Do not try to charge, or jump-start any frozen battery.

BATTERY LOSING VOLTAGE WHILE IN VEHICLE (PARASITIC DRAIN)
A Parasitic Drain is a condition where the battery’s energy is used up by the electronics, or accessories on the vehicle. For example, when the vehicle is not being driven enough to recharge the battery items like accessories, then instrument panels, cooling fans and ignition modules will continue to draw the energy from the battery even with the key off. Even a shorted wire on the vehicle can cause this condition. If the battery is drained below 14v, it can damage your 16v battery. This is why it is important to check your voltage after racing or before storing the vehicle. We suggest a Lithium-Battery Maintainer, or best is to disconnect the the Antigravity Battery from the vehicle if you will not be riding/driving enough to keep the battery charged up. It will hold a charge for up to a year and a half when not connected.

A mistake such as leaving the ignition “on”, or not disconnecting the battery before storing it can drain your battery and damage it. Most vehicles do have a mild parasitic drain that will not pose a problem in the short term, but adding accessories is usually where excessive parasitic drains occur. Be sure to keep the battery charged or drive enough to keep the battery in a fully charged state to get the longest life from your battery. You battery has a limited supply of energy to give before being over-discharged. Over-Discharge is not the fault of the battery. We understand many Race Cars use Total Loss systems, a system where there is no alternator to recharge the Battery. It is imperative to make sure you keep the battery fully charged as often as possible to get the best results. We do not warranty for Over-Discharged issues. This is not a fault of the battery, it is required maintenance for the Battery.

Continually Over-Discharging the battery: If you are not driving enough to recharge the battery the vehicle’s electronics will be taking energy from the battery and discharging it. Maybe you left the lights or ignition on accidently. These circumstances would normally over-discharge a battery. The Antigravity Battery has protections against this, but frequent over-discharge conditions to the battery can result in poor performance.

Over-Charging the battery: Using the incorrect charger that is charging above the Maximum Charge Voltage of 17.5 Volts. This will damage the battery rapidly and could cause fire or explosion. So you MUST make sure you are using the proper charger. And also that if your vehicle has a charging system for 16v Batteries, that it is regulated to not exceed the maximum charge voltage.

Warranty (Non-Transferable)

WARRANTY PERIOD
For full Warranty terms and information visit our Warranty page. All warranty claims are handled by Antigravity Batteries directly. All warranty claims must be accompanied by the original receipt from your retailer or your Antigravity Batteries Invoice. Antigravity Batteries LLC warrants to the original purchaser that our batteries are free of defects in material and workmanship for the term of 6 months. Race use is a 6 month warranty, but not covering Total-Loss Systems. All batteries must be registered within the first 30 days from the original purchase date or original purchaser must provide copy of original receipt in order to be eligible for a warranty claim. Warranties are non-transferable. Returns will only be accepted from the original Purchaser.

WARRANTY DOES NOT COVER

1. Any physical damage caused by abuse, negligence, improper installations, or lack of general maintenance.
2. Any modification to any part of the battery or its parts, any disassembly of the battery.
3. Damage from direct ”short-circuiting” of the battery caused by improper use or installations, grounding problems or accidents. Use of any Chargers intended for
4. Lead/Acid batteries: Trickle chargers, Battery Tenders, etc. DO NOT USE LEAD ACID CHARGERS. Use of Chargers NOT intended specifically for Lifepo4 Lithium
5. Batteries, or with a maximum charge voltage over 18 volts.
6. Overcharging due to a defect with vehicle’s voltage regulator or defective charging system, or performance
7. charging systems. Overcharging battery above 18 volts, or Overdischarge of battery below 14 volts.
8. Excessive over-cranking, or using the incorrect size battery (too small a battery where a larger battery is needed).
9. Any systems outside of typical intended uses.
10. Parasitic drains that discharge the battery to below 14v (please check your electrical system and accessories for parasitic drains).

REPLACEMENT
Antigravity Batteries are only eligible for one warranty replacement of a battery. Once a battery has been repaired or replaced under warranty, the replacement item only holds the remainder of the warranty period from the date of the original purchase of the battery, and covers only physical defects. The prorated discount toward the purchase of a new battery will be applied. Antigravity Batteries LLC reserves the right to deny any and all claims if all conditions and terms are not met.

REGISTERING YOUR BATTERY
You must register your Antigravity Battery product in order to validate the Limited Warranty. You can register the product Online at our Registration page. Complete the requested information and click “send”.

Contact Us
When you need help or have questions, our knowledgeable support team is here for you! Please feel free to call us during our Office Hours 7:30am-4pm Pacific Time, Monday-Friday; or you can write to us any time! 310 527 2330 Info@AntigravityBatteries.com 15622 Broadway Center St. Gardena CA 90248 VISIT OUR WEBSITES FOR MORE COOL PRODUCTS, ACCESSORIES AND INFO

References

• LITHIUM BATTERIES, MICRO-STARTS – Antigravity Batteries
• MICRO-START POWER SUPPLY JUMP-STARTER | by ANTIGRAVITY

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>