KARCHER BC 18 V 2 18V Battery Fast Charger Instruction Manual

KARCHER BC 18 V 2 18V Battery Fast Charger

General notes
Read these original instructions and the original instructions and safety instructions supplied with the battery pack and device before using the device for the first time.

Hazard levels

• DANGER
  •  Indication of an imminent threat of danger that will lead to severe injuries or even death.
• WARNING
  •  Indication of a potentially dangerous situation that may lead to severe injuries or even death.
• CAUTION
  •  Indication of a potentially dangerous situation that may lead to minor injuries.
• ATTENTION
  •  Indication of a potentially dangerous situation that may lead to damage to property

Safety instructions

•  The danger of explosion. Do not charge non-rechargeable batteries.
•  Only use the charger for charging approved battery packs.
•  Inspect the charger and battery mount for damage every time before use. Do not use any damaged devices. Replace any damaged devices.
•  Check the power cable for damage each time before operating the device. Do not use a damaged power cable. If the power cable is damaged, replace it with an approved replacement. You can obtain a suitable replacement from KÄRCHER or one of our service partners.
•  Do not charge battery packs that are damaged or not completely functional. Dispose of damaged or non-functional battery packs immediately, following the applicable regulations on transport and disposal.
•  Do not use the charger in an explosive environment or near flammable objects.
•  Do not immerse the device in water or hold it under a water stream.
•  Do not charge the battery pack in explosive environments. Check the condition of the battery pack and charger regularly during the charging process.
•  If you notice a fault, unusual smells, or the development of heat during charging, disconnect the charger from the mains and the battery pack from the charger. Dispose of the battery pack and charger immediately and follow the applicable regulations on transport and disposal.

WARNING

•  Check that the mains voltage corresponds with the voltage stated on the type plate of the charger.
•  Protect the power cable from heat, sharp edges, oil, and moving parts.
•  Do not open the charger. Repairs are only to be carried out by qualified personnel.
•  Pull the plug out of the main socket before cleaning the charger or performing cleaning work.
•  Persons with reduced physical, sensory or mental capabilities and persons lacking experience and knowledge may only use the appliance if they are properly supervised, have been instructed on the use of the appliance safely by a person responsible for their safety, and understand the resultant hazards involved.
•  Children must not play with the appliance.
•  Children must be supervised to prevent them from playing with the device.
•  Children from the minimum age of 8 may use the appliance if they are properly supervised or have been instructed in its use by a person responsible for their safety, and if they have understood the resultant hazards involved.
•  Children may only perform cleaning work and user maintenance under supervision.

CAUTION

•  Do not operate the device together with other devices on an extension cable with multiple power sockets.
•  Do not pull the mains plug out of the socket using the power supply cable.
•  Do not use the battery pack when dirty or wet.
•  Do not put the battery pack into the battery mount of the charger if it is dirty or wet.
•  Do not use the charger in a dusty environment.

ATTENTION

•  Short circuit hazard. Protect the contacts of the battery mount from metal parts.
•  Never cover the charger during use.
•  Do not carry the charger by the power cable.
•  Use the charger only in dry interior spaces with low humidity.

Intended use

CAUTION

• Risk of explosion!

• Risk of injury and damage due to exploding battery pack.

• Do not charge defective or not fully functional battery packs.

• Modifications and changes not authorized by the manufacturer are prohibited. Any other use is prohibited. The user shall be liable for hazards arising as a result of improper use. Charge only battery packs from the KÄRCHER Battery Power / Battery Power+ system.
  ATTENTION

• The charger can only be used with battery packs of the same voltage type (18 V / 36 V). Do not charge any other voltage type of battery pack. Before use, check that the voltage type (18 V / 36 V) of the battery pack and the device match. The voltage information can be found on the device, on the battery pack, and on its nameplate.

Environmental protection

The packing materials can be recycled. Please dispose of the packaging in accordance with the environmental regulations. Electrical and electronic appliances contain valuable, recyclable materials and often components such as batteries, rechargeable batteries, or oil, which – if handled or disposed of incorrectly – can pose a potential threat to human health and the environment. However, these components are required for the correct operation of the appliance. Appliances marked by this symbol are not allowed to be disposed of together with the household rubbish.
Notes on the content materials (REACH)
Current information on content materials can be found at: www.kaercher.com/REACH

Warranty

The warranty conditions issued by our relevant sales company apply in all countries. We shall remedy possible malfunctions on your appliance within the warranty period free of cost, provided that a material or manufacturing defect is the cause. In a warranty case, please contact your dealer (with the purchase receipt) or the next authorised customer service site. (See overleaf for the address)

Symbols on the device

Device description

Illustration A

1.  Battery terminals
2.  Battery mount
3.  Indicator lamp
4.  Wall attachment
5.  Mains cable socket

Operation

Charging process
Note The operating state of the battery pack can be read off the battery pack display. The display symbols are described in the battery pack operating instructions. If the display does not show anything at the start of the charging process, the battery capacity is fully depleted or very low. The display shows the remaining charge time once the battery pack is sufficiently charged. If the display does not show anything 2 minutes after the start of the charging process, the battery is defective and must not be further charged or used and must be disposed of immediately in accordance with applicable regulations.

1.  Plug the main cable into the main cable socket.
   Illustration B

2.  Plug the mains plug into the socket.

3.  Push the battery pack into the mounting on the charger.
   Illustration C
   The charging process begins automatically.
   The indicator light flashes green.
   The battery pack display shows the remaining charging time. The display shows 100% and the indicator lamp lights up green continuously when the battery pack is fully charged.

4.  Remove the battery pack from the charger after charging.

5.  Pull the mains plug out of the socket.
   Note
   The charged battery pack can remain in the charger until it is used. There is no danger of overcharging. Avoid unnecessary energy consumption and unplug the charger when the battery pack is fully charged.

Transport and storage

CAUTION
Failure to observe the weight Risk of injury and damage Be aware of the weight of the device during transport and storage. Store the device only in dry indoor rooms.

Care and service

The device is maintenance-free.

•  Regularly check the battery terminals for soiling.
•  Clean dirty battery terminals.
•  Check the ventilation slits for soiling, and clean if necessary.
•  Occasionally recharge battery packs stored for a longer period.

Troubleshooting guide

Malfunctions often have simple causes that you can remedy yourself using the following overview. When in doubt, or in the case of malfunctions not mentioned here, please contact your authorized Customer Service. Faults during charging The battery pack not charging, and the display is on a Defective charger. Replace the charger. The battery pack not charging, the indicator lamp on the quick charger off, the display off The quick charger is defective.

1.  Replace the quick charger. The battery pack not charging, and the display is off Battery pack is completely discharged or defective.
2.  Wait and see if the display shows the remaining charging time after 2 minutes. If the display shows the remaining charging time after the waiting time, the battery pack can be used normally.
3.  If the display does not appear, the battery pack is defective and may no longer be used. Immediately disconnect the battery pack from the charger and dispose of it according to regulations. The battery pack not charging, the display shows the temperature symbol The battery pack temperature is too low/high.
4.  Put the battery pack in a moderate temperature environment and wait until the battery pack temperature returns to the normal range, see the “Technical data” chapter. The charging process begins automatically.

Technical data

References

• Cher - Official Site
• Cleaning equipment and pressure washers | Kärcher International
• Cleaning equipment and pressure washers | Kärcher International
• Dealer Search | Kärcher International
• Home and Garden Warranty Registration USA - Kärcher

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>