nature Loo Classic 650 Composting Toilet Instruction Manual

NATURE LOO
CLASSIC 650
INSTALLATION & OPERATION MANUAL
IMNL-009-2023.04.28
©Ecoflo Wastewater Management Pty Ltd

ITEMS REQUIRED (NOT INCLUDED)

Please check the packing slip to ensure everything has been delivered. If anything is missing, please
notify Ecoflo within 72 hrs of receipt.
You will need the following items to complete your installation.
Vent items

• Wall brackets to fix the vent pipe to the building
• A length of 100mm DWV vent pipe to connect to the air exhaust (length depends on specific installation)
• Dektite if DWV vent pipe will penetrate the roof

Leachate drain items (please check with your local authority)

• Ø100mm Agricultural pipe
• 1.5m x 0.5m Synthetic or Hessian geotextile mat
• 50mm PVC pipe to connect the hose to the agricultural pipe
• 0.30m³ 20mm Aggregate

A vent kit and drain kit are available to purchase separately from Ecoflo.

TOOLS REQUIRED

NATURE LOO CLASSIC 650 SCHEMATICS

*Not included in package
A drain kit and vent kit are available to purchase seperately from Ecoflo.

INSTALLATION

STEP 1: POSITION THE PEDESTAL
Locate the approximate area where you want the pedestal to go before cutting the hole.
The usual position for pedestals is centred between side walls.
NOTE: Due to the pedestals being man made, the distance to the centre may vary from 245 to 255mm. Please check before cutting the hole. STEP 2: POSITION THE WASTE CHUTE
A 240mm hole must be cut in the toilet room floor to accommodate the waste chute.

Go to the underfloor area and look for the hole you have drilled.
Check to see if there is a floor joist, water pipe or electrical wiring under the area you are going to cut.
If there is a joist in the way, either reposition the waste hole OR install trimmer joists to each end of the cut joist, and fix all connections with galvanized framing anchors with 4 nails each leg (refer to diagram below). STEP 3: INSTALL THE WASTE CHUTE
First ensure the pad or ground level on which the ‘In-service’ chamber will reside is at its final level beneath the toilet room. EXTRA LENGTH REQUIRED FOR UNDER-FLOOR AREAS If the underfloor height exceeds 900mm (floor-to-floor), you will require additional lengths of chute, fixed together with small stainless steel self-tapping screws below the flange of the additional waste chute.
As the chute joints are tapered, the top waste chute must be inserted through the toilet room floor first with additional waste chutes added from below.
STEP 4: INSTALL THE WHEELS STEP 5: INSTALL THE COMPOST CHAMBER

1. A brush seal is supplied for the ‘In-service’ lid and acts as a seal to prevent any odor emitting from the chamber. Remove the adhesive cover and place the brush seal on the inside surface of the lid as shown below.
2. Add 50mm depth of bulking agent to the chamber to create a bed.
3. Slide the ‘In-service’ compost chamber lid (with pre-cut hole) up onto the waste chute from underneath.
4. Place the chamber underneath the lid and lower it onto the chamber.
5. Hook the bungee loops over the knobs as shown.

STEP 6: CONNECT THE DWV VENT PIPES AND FAN
The fan is IP68 rated so will not be effected by moisture. Do not glue the fan housing to the DWV fittings.
It is recommended that the fan runs 24 hours a day to continuously circulate air through the compost heap.
Air is drawn down the toilet pedestal through the compost chamber and out the vent pipe.

OPTIONAL EXTRAS
A vent kit is available to purchase separately from Ecoflo Wastewater Management.100mm DWV vent kit:

• ø100mm DWV Pipes
• ø100mm DWV Slip Joiners
• ø100mm Stand Off Brackets
• Dektite

STEP 7: CONNECT THE FLEXIBLE VENT PIPE AND LIQUID DRAIN HOSE

POWERING YOUR FAN

Mains Power
A 120 /12 volt regulated transformer is included to run the fan from mains power. The positive wire the transformer is marked with a white line. The fan has anti-polarity protection and would not run if connected incorrectly.
Connect the fans to the transformer as follows: solar Power
Refer to separate installation manual for the solar panel.

LEACHATE DRAIN

A leachate drain kit (not including gravel) is available to purchase separately from Ecoflo Wastewater Management.
Alternatively, if your council allows, you may wish to construct your own leachate drain. The liquid drain hose should run into either a 50mm PVC pipe (drilled to allow liquid to escape) OR a length of socked slotted Ag pipe, buried in an absorption trench as shown in the diagram below.

COMPOSTING ACCELERATORS

Whilst Clivus Multrum users report successful composting without the use of any additives, we strongly recommend the use of the following items in order to optimize composting, particularly when the toilet is in permanent use by more than two people.

Bulking agenT
This should be added on a regular basis, preferably a handful after each solid use. Alternatively, if this is not possible, add the equivalent of this on a daily or weekly basis. The bulking agent can be added through the pedestal.
We do NOT recommend the use of:

• Sawdust as it creates an anaerobic condition within the chamber.
• Cypress, cedar or eucalyptus wood shavings due to their antimicrobial properties.
• Sugar cane mulch as it makes using the mixer difficult.

liquiD enzyMes
A 125ml bottle of enzyme concentrate is supplied with the toilet. Please refer to the label for instructions and spray into the waste chute. A spray flask is provided. Any staining of the pedestal can also be removed with the spray.
MicroBes
This should be used each time a chamber is changed to kick start the process in the new chamber. Shop consumables: ecoflo.com.au/products/consumables

CARE & MAINTENANCE

Daily or weekly

• Clean restroom & toilet fixtures using only biodegradable cleaners.
• Add 1 cup of bulking agent to toilet after every solid use.

MonThly

• Inspect the ‘In-service’ chamber, depends on usage, prepare another ‘In-service’ chamber for use once the chamber becomes full (refer to Rotation of Chambers, page 13).
• Check vent pipe & remove any foreign matter.
• Check the fan is operating
• Check that system is draining correctly

6 MonThs

• Remove and clean fan

Shop consumables at ecoflo.com.au/products/consumables

ROTATION OF CHAMBERS

It is important to observe safety procedures when dealing with fresh human waste.
Please ensure you wear protective clothing (gloves and old clothes). Do not attempt to move the chambers on your own.
your firsT roTaTion of The chaMBers:
The Nature Loo composting toilet chambers will need to be changed on a regular basis. A sufficient number of chambers must be purchased to allow the ‘Out-of- service’ chamber to have a minimum of 5 months (depending on climate) from the time they are disconnected from the waste chute.
Prepare a new ‘In-service’ chamber for use (refer to Step 5: Install the Compost Chamber, page 7).
Pour a small bucket of bulking agent (clean mulch) down the pedestal to cover up the waste pile before removing the full chamber.
EXTra chaMBer/s:
The ‘Out of Service’ chamber should be put in a warm position with the Air Intake Cap attached to threaded connector and the dust plug attached to the camlock. REMoval of coMPosT:
The pile should have reduced in size to approximately 20% of its original size and contain a maximum of 75% moisture. This ‘humus’ must then be disposed of as per the local health department regulations.
This normally means digging the humus into the soil and covering with at least 100mm of soil.
RETurning a chaMBer To service:

1. Ensure all hose and vent connections are clear.
2. Prepare the ‘In-service’ chamber for use (refer to Step 5: Install the Compost Chamber, page 7).

If the ‘Out-of-service’ chamber is to be placed away from the Main Vent assembly, you will need to dig a small second trench (20 x 20 x 20cms) to allow residual liquid to exit the chamber. Connect the second liquid drain hose from the chamber to the trench.

TROUBLESHOOTING

Please reaD This secTion Before using your ToileT.
Nature Loo toilets have proven themselves to be one of the easiest systems to manage. However, being a natural process, reliant on a number of factors beyond our control, it can occasionally need some help to maintain an appropriate balance.
The ‘in-service’ chaMBer is filling Too quickly:
This may be caused by a number of factors:
THE TEMPERATURE IS TOO LOW for effective composting.
INSUFFICIENT AIR FLOW.
This can be caused by a broken fan or the chamber being too full. Check the fan is operating and the level of the pile is not too high. This problem could also be caused by a blocked insect screen in the vent cowl.
THE PILE BEING TOO WET.
This could be the result of the outlet of the liquid chamber being blocked and causing the upper chamber to flood. Check the drain hose is not blocked and flush with a hose if necessary. You may need to change chambers if the blockage is in the chamber and thoroughly flush out the contents of the liquid chamber.
ANTIBIOTICS AND DISINFECTANTS WILL SLOW DOWN OR STOP THE PROCESS.
Restart the composting by reintroducing microorganisms. In many of these situations Nature Flush Enzymes will help solve inefficient composting by breaking down the solids and thereby speeding up decomposition.
The ‘ouT-of-service’ chaMBer is coMPosTing Too slowly:
This may happen due to one or more of the problems described above. You could add 500ml of Nature Flush Enzymes from a domestic spray bottle as you turn the material and add a quantity of Nature Quick Microbes.
You should consider locating the chamber where it has a greater exposure to direct sun light. However, if you find the pile is drying out too quickly put the chamber in a shadier position.
If you find that none of the above measures are effective, it means the local climatic conditions are less than ideal. This can happen in cold or humid conditions and you will need to purchase an additional chamber in order to provide an extended composting period.
If you need to change your ‘In-service’ chamber and the ‘Out-of-service’ chamber is not yet composted, dispose of the waste as normal and order an extra chamber from Ecoflo.
The oDour froM The ‘ouT-of-service’ chaMBer is unPleasanT:
If the ‘Out-of-service’ chamber is not connected to the vent pipe it may smell immediately after it has been taken ‘Out-of-service’. Odours can be greatly reduced or eliminated by covering the top of the  pile with straw or dry grass clippings. You may wish to do this before disconnecting the chamber.
The oDour froM The ‘in-service’ chaMBer is unPleasanT:
If this is not caused by a failed fan, or blockage in the vent pipe, liquid drain hose or fitting, please see the “‘In-service’ chamber is filling too quickly” section for how to resolve this problem.
The Power has faileD resulTing in ToileT rooM oDours:
Cover the pedestal with cling film until the power is restored. If you are connected to mains power consider installing an Uninterrupted Power Supply (UPS), available at Ecoflo Wastewater Management. The UPS will cut in with power from a 7Ah battery when there is a loss of mains power.
Helpful hints from our customers:

• Paint the Vent Stack black to produce an upward air flow.
• Add a wind assisted turbo vent to the Vent Stack.

Find more Troubleshooting and FAQ information online at
ecoflo.com.au/FAQ
or call us on
1300 138 182

PRODUCT & COMPONENT WARRANTY

Ecoflo will furnish new parts to a customer whose toilet fails within the allotted warranty period for the particular component, provided that our inspection shows such failure is due to defective material or workmanship. Any part supplied is warranted for the balance of the original warranty period. The warranty period for a part begins from the date the original product was dispatched (plus 10 working days for transportation).
Warranty Period:

This warranty does not cover:

• Damage resulting from neglect, abuse, accident or alteration; or damage caused by fire, flood, acts of god or other causality.
• Damage resulting from failure of the purchaser to follow normal installation and operating procedures outlined in the manual or in any other printed instructions supplied with the system.
• Labour and service charges incurred in the removal and replacement of any parts found defective under this warranty.

Items subject to a dispute, where photographic evidence is inconclusive, must be sent prepaid to Ecoflo. The cost will be reimbursed by Ecoflo should the claim be found valid.

In addition to the above, Ecoflo will only replace a fan that fails during the warranty period under the following conditions:

• The fan has only ever been connected and powered by either a 12 volt transformer plugged into mains power or a solar system supplied by Ecoflo. Connecting your fan directly to a power source other than one supplied or specified by Ecoflo may result in damage to the fan and void the warranty.
• The fan and transformer must not be modified/altered in any way.
• The faulty fan is returned to Ecoflo for inspection, if required.

Providing the above conditions have been met replacement fans are shipped the same or following day free of charge by regular post.

MAINTENANCE SCHEDULE

Please place this maintenance schedule close to your ‘In-service’ Chamber and complete the table as you rotate your chambers.
Model: __
Date First Put into Service: //____
The ‘Out-of-service’ chamber must compost for a minimum of 6 months from the date it was first rotated ‘Out-of-service’.
Date chambers were last rotated:
Wear protective clothing including gloves and eyewear when servicing, rotating or emptying chambers.

Ecoflo Wastewater Management Pty Ltd
ecoflo.com.au
natureloo.com.au 
Phone: 1300 138 182
(07) 3889 6144
Email: info@ecoflo.com.au
Proudly Designed and Assembled in Australia by
Ecoflo Wastewater Management

References

• Waterless Composting Toilets | Ecoflo Wastewater Management
• Consumables - Wood shavings, microbes, enzymes and humus
• Nature Loo | Composting Waterless Toilets | Environmentally Friendly - Nature Loo | Environmental Waste and Wastewater Management Systems

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>