CRAFTSMAN 15200 Portable Air Tank Owner’s Manual
- June 13, 2024
- Craftsman
Table of Contents
CRAFTSMAN 15200 Portable Air Tank
Important Safety Instructions and Guidelines
The information listed below should be read and understood by the operator. This information is given to protect the user while operating and storing the portable air tank. We use the symbols below to allow the reader to recognize important safety information. Improper operation or maintenance of this product could result in serious injury and/or property damage. Read and understand all of the warnings and safety instructions provided before using this equipment.
Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.
Risk to Breathing
Keep children, pets, and others out of the area of operation.
This portable air tank does not provide breathable air for anyone or any
auxiliary breathing device.
Risk of Bursting
If the tank develops a leak, then replace the portable air tank.
Never attempt to repair a tank by welding!
NOTE: Discard the empty tank and DO NOT use after 7 years from the date
purchased from Sears by the original owner. This tank is stamped with a
“DISCARD AFTER” date if date is unkown.
Risk of Personal Injury
Compressed air can be hazardous. The air stream can cause injury to soft tissue areas such as eyes, ears, etc. Particles or objects propelled by the air stream can cause injury.
Operating Procedures
Filling the Portable Air Tank
Take your portable air tank to any source of clean dry compressed air. A full
service gas station or truck stop is preferable. Modern convenience mart type
filling stations do not have sufficient air pressure available to allow you to
get the most from your air tank. It is recommended that you fill your tank
with air until the pressure gauge reads between 95 to 135 psi. The air tank is
filled like a car tire by pressing the chuck from the source to the filler
valve.
PLEASE NOTE: Tank can be filled and the pressure gauge can be read with the
RED ON/OFF KNOB in the OFF position.
Using the Portable Air Tank
Turn the RED ON/OFF KNOB counter-clockwise to the open position to allow air
to flow from the tank into the hose. To prevent air from leaking out of the
tank between uses, turn the RED ON/OFF KNOB clockwise to the closed position.
Storage
STORING YOUR PORTABLE AIR TANK
Turn the RED ON/OFF KNOB CLOCKWISE to the OFF position when storing your air tank.
Failure to remove condensation will cause the tank to rust prematurely.
Always drain the tank of all air after the last use for the day and before
repairing or removing any component parts.
Point the safety pressure relief valve AWAY FROM YOUR BODY when releasing air.
Use the pull ring on the safety relief valve to vent any pressure Inside the
tank before attempting to service the tank. Safety goggles must be worn at all
times for eye protection. To disperse any accumulated condensation inside the
tank, begin by reducing the air pressure inside the tank by pulling out on the
safety valve and holding until the tank gauge reaches 25 psi. Invert the tank
with the manifold facing downward and pull the ring on the safety relief
valve. We as the manufacturer and you as the consumer have no control over
the moisture content of air coming from any fill source. Premature rusting
caused by condensation inside the tank is the primary reason for the suggested
replacement date stamped on the tank.
- Never attempt to remove any components while tank is pressurized.
- Never remove or deface the information sticker on tank.
- Never attempt to fill the tank if any air leak is detected in the tank body. Discontinue use of the air tank immediately.
- Warranty is void if any attempt is made to alter or
Parts List
-
Carry Handle
-
Pressure Gauge
Indicates internal air pressure of tank. -
On/Off Valve
Prevents air from leaking out of the air hose and/or tire chuck, when in the off position. -
Filler Valve
Fill tank with compressed air through this point. -
Safety Pressure Relief Valve
Prevents tank from being over-pressurized. -
Air Hose
Delivers compressed air from the tank. -
Steel Legs
Support tank in an upright stable position. -
Tire Chuck
Used to inflate tires and other items.
Manifold Enlargement
Replacement Parts
| Item No (s). | Part No. | Description | Qty |
|---|---|---|---|
| 2 | E100179 | Pressure Gauge | 1 |
| 3, 4, & 5 | E100177 | Manifold Assembly | 1 |
| 6 & 8 | E100178 | Air Hose w/Chuck | 1 |
ONE YEAR FULL WARRANTY ON CRAFTSMAN PORTABLE AIR TANK
If this Craftsman PortableAir Tank fails due to manufacturer’s defects in
material or workmanship within one year
from the date of purchase, return it to your nearest Sears store in the United
States and it will be replaced free of charge.
if this Portable Air Tank is used for commercial or rental purposes, this
warranty applies for only 90 days from the
date of purchase. This warranty gives you specific legal rights and you may
also have other rights which vary from state to state.
For replacement parts call
1-800-4-MY-HOME _ (1-800-469-4663)
www.sears.condcraftsman
4/22/04
Part NO, E100174
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>