Nu-Calgon 4083-91 DuraCoil Coil and Surface Protectant User Manual
- June 12, 2024
- Nu-Calgon
Table of Contents
Nu-Calgon 4083-91 DuraCoil Coil and Surface Protectant User Manual
FEATURES:
DuraCoil is a field proven coating developed to extend the service life of an installed air conditioning coil or metal component in a corrosive environment. Coils located in coastal regions, industrial/agriculture production settings or refrigeration applications to protect against corrosive food acids are ideal applications if an OEM coating was not applied or has been compromised over time in service. Designed for coils in corrosive environments, the non- flat dual function coating and primer causes negligible heat transfer loss.
DIRECTIONS FOR USE:
This product must be used in accordance to the following directions by HVACR professionals only.
- Coil must be clean and dry free of dust, dirt, grease and grime. Clean with a Nu-Calgon coil cleaner if necessary. Remove any equipment panels necessary to properly apply product. Cover any adjoining surfaces that need to be protected. Please note the product is a gray colored coating ensure acceptability.
- Disconnect all power to the equipment before use. Do not spray near sparks, heat or open flame.
- Use only with adequate ventilation; avoid breathing of vapors and spray.
- For best results, spray when the outdoor temperature is 50ºF or above.
- Shake the canister for one minute after you hear the mixing ball rattle.
- Apply coating in several thin even coats over the coil or metal surface.
- Allow adequate drying time before turning on the system.
Note: For future coil cleanings after DuraCoil has been applied, consider Nu- Calgon coil cleaners such as Tri-Pow’r, Special HD CalClean, CalClean, Cal- Green, Evap-Green, Evap-Pow’r, TriClean 2x, or Green Clean. For additional questions, please contact Nu-Calgon.
DANGER Extremely flammable aerosol. Contains gas under pressure; may explode
if heated. May be fatal if swallowed and enters airways. May cause cancer.
Causes serious eye irritation. May cause genetic defects. May cause harm to
breast-fed children. Causes skin irritation. May cause an allergic skin
reaction. May cause damage to organs through prolonged or repeated exposure.
May cause drowsiness or dizziness.
PREVENTION: Keep away from heat, hot surfaces, sparks, open flames and other
ignition sources. No smoking. Do not spray on an open flame or other ignition
source. Pressurized container: Do not pierce or burn, even after use. Obtain
special instructions before use. Do not handle until all safety precautions
have been read and understood. Wear protective gloves/ protective clothing/eye
protection/face protection. Wash thoroughly after handling. Do not breathe
dust/fume/gas/mist/vapors/ spray. Avoid contact during pregnancy and while
nursing. Do not eat, drink or smoke when using this product. Contaminated work
clothing should not be allowed out of the workplace. Use only outdoors or in a
well-ventilated area. Keep container tightly closed. RESPONSE: IF SWALLOWED:
Immediately call a POISON CENTER or doctor. Do NOT induce vomiting. IF exposed
or concerned: Get medical advice/attention. IF IN EYES: Rinse cautiously with
water for several minutes. Remove contact lenses, if present and easy to do.
Continue rinsing. If eye irritation persists: Get medical advice/attention. IF
ON SKIN: Wash with plenty of water. Take off contaminated clothing. And wash
it before reuse. If skin irritation or a rash occurs: Get medical
advice/attention. Get Medical advice/attention if you feel unwell. IF INHALED:
Remove person to fresh air and keep comfortable for breathing. Call a POISON
CENTER/doctor if you feel unwell. STORAGE: Protect from sunlight. Do not
expose to temperatures exceeding 50°C/122°F. Protect from sunlight. Store in a
well-ventilated place. Store locked up. DISPOSAL: Dispose of
contents/container in accordance with local/ regional/national/international
regulations. KEEP OUT OF REACH OF CHILDREN. Contains (CAS#): Petroleum gases,
liquefied, sweetened (68476-86-8), Aliphatic, light hydrocarbon solvent
(64742-89-8), Isoparaffinic petroleum distillate (64742-47-8), Acetone
(67-64-1), TALC (14807-96-6), Wollastonite (13983-170), Titanium dioxide
(13463-67-7), Butylated hydroxytoluene (128-37-0), Sodium alumina
(57455-37-5), Silica, amorphous (7631-86-9), Octane (111-65-9), n-Heptane
(142-82-5), Quartz (14808-60-7), Propylene glycol monomethyl ether (107-98-2).
Aerosol Coating Category and Limit: Nonflat Coating: 0.95
⚠ WARNING: This product can expose you to chemicals including Silica,
Amorphous which is known to the State of California to cause cancer. For more
information go to www.P65Warnings.ca.gov.
Manufactured for: Nu-Calgon
2611 Schuetz Rd. St. Louis, MO 63043 Customer Service:
800-554-5499 Chemical Emergency:
800-424-9300
www.nucalgon.com (1121) Calgon is a licensed trade
name.