AJ-Enjoy AJ1195 Propane Gas Fire Pit Owner’s Manual

AJ-Enjoy AJ1195 Propane Gas Fire Pit Owner’s Manual

WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage,personal injury,or loss of life.

DANGER
FIRE OR EXPLOSION HAZARD If you smell gas:

• Shut off gas to the appliance.
• Extinguish any open flame.
• If odor continues, leave the area immediately.
• After leaving the area, call your gas supplier or fire department.

Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal injury, or death.

WARNING
Do not store or use gasoline or other flammablevapors and liquids in the vicinity of this or any other appliance. An LP-cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

WARNING For outdoor use only
Installation and service must be performed by a qualified installer, service agency, or the gas supplier.

WARNING
Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to the owner’s information manual provided with this appliance. For assistance or additional information consult a qualified installer, services agency or the gas supplier.

SAFETY INFORMATION

WARNING

• The installation of this unit must adhere to local codes or Propane Storage and Handling Code, CSA B149.2.
• THIS UNIT IS INTENDED FOR OUTDOOR USE ONLY! This product shall be used outdoors, in a ventilated space and shall not be used in any enclosed area.
• This unit is to be used with propane gas only! (sold separately)
• Do not attach a remote gas supply to this unit.
• Only use propane gas for this unit.
• Solid fuels shall not be burned in this appliance.
• LP GAS WARNING: Do not use any more than 1/4 in depth lava rocks/pumice stones/Lava Glass above the bur
• If the propane gas tank is leaking gas, you may hear, see, or smell a hiss. Do the following: e department for help.
• Applying too much propane may result in gas pooling and will not burn. Allow fresh air into the unit so that the remaining gas may escape.
• Discontinue use if any part of the propane tank is damaged. Rust and dents may be hazar dous and should be inspected by a gas supplier. rocks/pumice stones/LavaGlass could pop out and cause injury. Should any rocks pop out, discard them.
• Always ensure that lava rocks/pumice stones/LavaGlass are completely dry before use. Failure to do so will cause them to crack or pop.
• Do not operate unit until all parts are fully assembled.
• Do not paint or color any part of this heating unit.
• Unit may be hot while in use, do not attempt to move it while in use.
• Never leave this heating unit unattended while in use.
• This unit is not intended for cooking.
• Keep a safe distance to avoid burning skin or clothing.
• Do not sit or rest hands or feet on this heating unit.
• Keep all electrical cords and fuel supply hose away from heated surfaces. Manifold pressure: 11 inch w.c. (2.74 kPa). Use LP propane tanks with the following dimensions: diameter 12 in, height 18 in – capacity 20 lbs. You must use a propane tank that has a collar to protect the gas valve. The tank system must be set up for vapor withdrawal

Only use the regulator and hose assembly provided with this unit. Replacement parts must be supplied directly by TJX.Inspect the burner before use of this unit. If the burner shows any kind of damage, do not operate the appliance.
NOTE: You must follow all steps to properly assemble this heating item. Make sure the gas valve is turned “OFF” before assembling. Do NOT attempt to assemble without proper tools.

Combustible materials should not be within 72 inches of the top of the unit, or within 48 inches around the entire unit.

PARTS LIST

ASSEMBLY INSTRUCTIONS

1. Check that the control knob for the gas supply system is turned to the OFF position before starting any assembly
   

2. Turn the cylinder valve on the tank clockwise to close the propane tank. Open the door then put the tank into the fire pit, Attach the preassembled regulator to the cylinder valve by turning the regulator coupling nut clockwise. !!! Make sure it is fastened securely and tighten connections by hand only
   

3. Remove the plastic cap on the electronic igniter by unscrewing and slide battery into the battery
   slot. Make sure the positive side of the battery faces outwards. Screw the electronic igniter cap
   over the battery tightly

4. Pour the box of clear glass rocks into the fire bowl, then spread the blue glass beads evenly.
   

WARNING
Do Not Cover the Ignition Screen when placing the rocks into the fire bowl.Always keep the ignition screen visible.

• CORRECT
  

• INCORRECT

WARNING
This heating item should not be used on plastic composite or artificial wood

WARNING
Don’t light or use gas unit if glass rocks are wet. Ensure glass rocks are com pletely dry before igniting.

OPERATION

Before performing a leak test, be sure that no sparks can occur and you are in a spacious outdoor area. Connect the propane gas tank to the regulator and turn the valve on the unit to the “off” position. rush a soap and water mixture on all connections. Turn the gas supply on; if bubbles occur on any connection there may be a leak. If you smell gas or a leak is discovered turn the gas valve off, disconnect propane gas tank and do not use the appliance until the leak is repaired. Do not use the heating unit without inspecting the gas hose. If there are signs of wear or abrasion you must replace the hose (if applicable). Pumice stones/lava rocks/LavaGlass could pop up and strike somebody’s face during the process of lighting this unit; stand away from the unit for the first 20 minutes after igniting. Flame height should be a yellow/blue color between 2 – 10 inches in height. Wait 50 minutes after extinguishing flame prior to placing a lid (if applicable) or protective cover on heating item.

To Light

1. Make sure the control knob is in the “OFF” position.
2. Slowly open the valve on the propane gas tank by turning the knob counterclockwise.
3. Push and hold in the electronic ignitor to create sparks within the electrode, continue to hold
4. Push in the control knob and turn to the “HIGH” position. Keep holding down the control knob to allow gas to fow for 15 seconds
5. If ignition doesn t occur within a few seconds release the control knob and rotate to the”OFF” position. Wait for 5 minutes for gas to clear and then repeat the above lighting instructions
6. Once the fire is lit, the flame intensity may be controlled by turning the control knob between the “LOW and “HIGH” positions
   

To Extinguish

1. Turn control knob clockwise to the “HIGH” position; let the knob pop up and continue turning the control knob to the “OFF” position.
2. Close the cylinder valve on the propane gas tank if you don’t intend to use it for a long time.

MAINTENANCE

Before performing any maintenance always disconnect propane gas tank.

• Store your product indoors during winter months. Avoiding extreme cold temperatures will prevent exposure damage.
• Keep the heating item free and clear from combustible materials. Visually inspect burner for obstructions and keep tank enclosure free and clear from debris.
• Use a soft brush to get rid of the mild stains, loose dirt and soil after the burner and pumice stones/ lava rocks/Lava Glass are completely cooled down. Wipe down with a soft cloth.
• Harsh weather conditions may cause stubborn stains, discoloration and possibly rust pitting. Permanent damage may occur if powder or solvent comes in contact with painted or plastic components on this heating unit.
• Keep the heating unit stored away from direct sunlight. If storing this unit inside, disconnect the propane gas tank from the gas valve.
• Not using manufacturer approved or supplied parts/accessories may result in a defective condition and void the warranty of this heating unit.
• If desired, cover fire pit to protect exterior surfaces and to help prevent build-up in air passages.
• Note: Wait until fire pit is cool before covering.

TROUBLESHOOTING

Problem: Burner will not light using igniter

Problem: Burner will not light with match

Problem: The fire table emits a lot of black smoke when in use

Problem: Sudden drop in gas flow, or a reduced flame height

Problem: Irregular flame pattern, flame does not run the full length of the burner

Documents / Resources

| AJ- Enjoy AJ1195 Propane Gas Fire Pit [pdf] Owner's Manual
L-43018-853, CYH-69895706, BF1103C47, AJ1195, AJ1195 Propane Gas Fire Pit, Propane Gas Fire Pit, Gas Fire Pit, Fire Pit
---|---

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>