RYOBI PCL663 18 V LED Clamp Light Instruction Manual
- June 9, 2024
- RYOBI
Table of Contents
PCL663 18 V LED Clamp Light
Instruction Manual
OPERATOR’S MANUAL
18 V LED CLAMP LIGHT
PCL663
IMPORTANT SAFETY INSTRUCTIONS
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ
AND KEEP FOR FUTURE REFERENCE.
WARNING!
READ AND UNDERSTAND ALL INSTRUCTIONS. Failure to follow all instructions
listed below, may result in electric shock, fire and/or serious personal
injury.
WARNING!
When using electric appliances, basic precautions should always be followed,
including the following:
-
Read all the instructions before using the appliance.
-
To reduce the risk of injury, close supervision is necessary when an appliance is used near children. Do not permit children to use light.
It is not a toy. The temperature of the LED will become hot after being on for only a short period of time. This hot temperature can cause burn injury if touched and can create sufficient heat to melt some fabrics. -
To reduce the risk of electrical shock, do not put light or charger in water or other liquid. Do not place or store appliance where it can fall or be pulled into a tub or sink.
-
If wrapped or in contact with fabrics, the light lens can produce sufficient heat to melt some fabrics. To avoid serious personal injury, never allow the light lens to come in contact with anything.
-
Do not use or permit use of light in bed or sleeping bags. This light lens can melt fabric and a burn injury could result.
-
Use only the charger supplied by the manufacturer to recharge.
-
Use this product only with batteries and chargers listed in tool/appliance/battery pack/charger correlation supplement 987000-432.
-
Use only recommended battery pack. Any attempt to use another battery pack will cause damage to your light and could possibly explode, cause a fire, or personal injury.
-
Remove battery pack from light before performing any routine maintenance or cleaning.
-
Do not disassemble the light.
-
Do not place or operate LED light, battery or charger near fire, heat, or flammable liquids/gases. They may explode. Also, do not dispose of a worn out battery pack by incinerating. Do not incinerate the battery, even if it is severely damaged or completely worn out. The battery may explode in fire.
-
Keep light dry, clean, and free from oil and grease. Always use a clean cloth when cleaning. Never use brake fluids, gasoline, petroleum-based products, or any strong solvent to clean the light.
-
Don’t expose light to rain. Water entering a power tool will increase the risk of electric shock or malfunction.
LIGHT USE AND CARE
- This product is for household use only.
SAFETY RULES FOR LIGHT
- Always remove battery pack before storing the device.
SAVE THESE INSTRUCTIONS
SYMBOLS
The following signal words and meanings are intended to explain the levels of risk associated with the product.
| SYMBOL | SIGNAL | MEANING |
|---|---|---|
| **** | DANGER: | Indicates a hazardous situation, which, if not avoided, |
will result in death or serious injury.
**| WARNING:| Indicates a hazardous situation, which, if not avoided,
could result in death or serious injury.
**| CAUTION:| Indicates a hazardous situation, that, if not avoided,
may result in minor or moderate injury.
| NOTICE:| (Without Safety Alert Symbol) Indicates information
considered important, but not related to a potential injury (e.g. messages
relating to property damage).
Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to operate the tool better and safer.
| SYMBOL | NAME | DESIGNATION/EXPLANATION |
|---|---|---|
| **** | Safety Alert | Indicates a potential personal injury hazard. |
| Read Operator’s Manual | To reduce the risk of injury, user must read and |
understand operator’s anual before using this product.
| Wet Conditions Alert| Do not expose battery or internal flashlight
components to rain or water.
| Extremely Bright Light| This product uses extremely bright LEDs. To avoid
serious eye injury, do not shine into eyes or face.
| Recycle Symbols| This product uses Lithium-ion (Li-Ion) batteries. Local,
state or federal laws may prohibit disposal of batteries in ordinary trash.
Consult your local waste authority for information regarding available
recycling and/or disposal options.
V| Volt| Voltage
min| Minutes| Time
****| Direct Current| Type or a characteristic of current
PRODUCT SPECIFICATIONS
Light Output ………………………………………900/250 Lumens
OPERATION
See Figures 1 – 3.
WARNING:
If any parts are damaged or missing do not operate this product until the
parts are replaced. Use of this product with damaged or missing parts could
result in serious personal injury.
WARNING:
Do not direct the light beam at persons or animals and do not stare into the
light beam yourself (not even from a distance). Staring into the light beam
may result in serious injury or vision loss.
A – Adjustable head
B – LED lens
C – Hi/low/off button
D – Clamp E – Battery pack
F – Insert the battery pack into the battery port as shown
G – Make sure the latches on the battery pack snap into place and the battery
pack is secured in the product before beginning operation
H – Depress the latches and pull to release and remove the battery pack
A – Tilt
or rotate head and direct light as desired. 
A – Squeeze the ends of the clamp to
open the clamp mouth and install the light to a mounting surface that is 1-3/4
in. thick or less.
To request service, purchase replacement parts, locate an Authorized Service
Center and obtain Customer or Technical Support:
Visit www.ryobitools.com or call
1-800-525-2579
If any parts or accessories are damaged or missing, do not return this product
to the store. Call 1-800-525-2579 for
immediate service.
Please obtain your model and serial number from the product data plate.
This product is covered under a 3-year limited
Warranty. Proof of purchase is required.
TTI CONSUMER POWER TOOLS, INC.
P.O. Box 1288, Anderson, SC 29622
Phone 1-800-525-2579
États-Unis, Téléphone 1-800-525-2579
USA, Teléfono 1-800-525-2579
www.ryobitools.mx
800-843-1111 (en México)
www.ryobitools.com
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>